Battery Charger; Troubleshooting; Circuit Breaker; Fuses - Shoprider Valencia User Manual

Battery Charger

The battery charger is a 4-amp switch type off board. The battery charging port is located on the
battery pack. This special feature allows the batteries to be charged independently of the main
scooter. Before using our scooter for the first time be sure to fully charge the batteries, this may take
up to 12 hours.
To charge the batteries connect the 3-pin male charger plug into the charging socket on the battery
pack. Plug the 3-pin mains plug into a wall socket and switch on. The battery charger has two lights.
A constant red light will show when the battery charger is connected (this will flash if there is a break
in the connection). The flashing green light indicates that the batteries are receiving charge, this will
change to solid green when the charging cycle is complete.
Caution:
Do not charge the batteries for longer than 12 hours. Always charge the batteries in a
well-ventilated indoor area.
You must still maintain charging the batteries even if the scooter is not to be used for a
prolonged period of time (2 to 3 weeks). Failure to do so could result in permanent
damage and render the batteries unusable.
Wherever possible do not interrupt the charge cycle until the batteries are fully charged.
Continual interruption can permanently damage the batteries. If the charging lead should
get damaged discontinue use immediately and seek a replacement from your dealer.
Only use the charger supplied with your scooter. Do not leave the charger plugged into to
the charger port after the charge is complete. Always remove the keys from the scooter
when charging.

Troubleshooting

Circuit Breaker

Your scooter is fitted with the latest in electronic controls that are programmed to protect the electrical
system from abnormal overloads. Fitted for extra protection is a circuit breaker, which is located on
the battery pack. Should there be a situation where your scooter stops for no apparent reason please
check that the circuit breaker has not tripped. Simply press the button to reset the circuit breaker.
Note:
Should the circuit breaker continue to trip turn off the scooter immediately and consult
your dealer.

Fuses

There are two 40 amp blade type fuses inside the battery pack to give protection against possible
overload on the wiring.
Caution:
Do not attempt to open the battery pack to replace the fuses. Please take the battery pack
to an authorised dealer to replace any blown fuses.
15