Table of Contents
Advertisement
Quick Links
Installation and operating instructions
Installation and operating instructions
JUDO PROFI-PLUS
JUDO PROFI-PLUS
Backwash protective filter ¾" - 1¼"
Backwash protective filter ¾" - 1¼"
Valid for: EU countries and Switzerland
Valid for: EU countries and Switzerland
Language: English
Language: English
Read before use and store!
Read before use and store!
Advertisement
Table of Contents
Related Manuals for Judo PROFI-PLUS Series
Summary of Contents for Judo PROFI-PLUS Series
- Page 1 Installation and operating instructions Installation and operating instructions JUDO PROFI-PLUS JUDO PROFI-PLUS Backwash protective filter ¾" - 1¼" Backwash protective filter ¾" - 1¼" Valid for: EU countries and Switzerland Valid for: EU countries and Switzerland Language: English Language: English...
- Page 2 D-71351 Winnenden uct. You have purchased a state-of-the- art device. It has been carefully checked Email: info@judo.eu • judo.eu prior to delivery. Nevertheless, if diffi- culties occur, please contact the closest customer service (see chapter Customer Office address: service).
-
Page 3: Table Of Contents
4.3 Maintenance, repair, spare parts..13 4.4 Temporary removal of the device..13 Servicing...........13 5.1 Cleaning..........13 5.2 Warranty and maintenance....13 Fault..........14 Technical data........15 7.1 Installation dimensions...... 16 7.2 Accessories........16 7.3 Spare parts........17 Disposal..........19 Customer service......20 1701582 • 2018/12 JUDO JPF+... -
Page 4: Safety
Before using the device with water that does not comply with this Directive, it is The installation room must be dry and essential to consult the manufacturer. free from frost. The ambient temperature must not exceed 30 °C! In higher temperatures JUDO JPF+ 1701582 • 2018/12... - Page 5 • Check for damage prior to installa- Unauthorised conversions and changes tion. are forbidden for safety reasons. These • Immediately have any malfunctions in can impair the functioning of the device, operation rectified by qualified tech- nical personnel. 1701582 • 2018/12 JUDO JPF+...
-
Page 6: Symbols Used
• Type label • Cleaning information must be observed and maintained in legible condition. Units used Unit Conversion 1 bar = 10 Pa = 0.1 N/mm ¾" DN 20 1" DN 25 1¼" DN 32 JUDO JPF+ 1701582 • 2018/12... -
Page 7: Materials Used
• DIN 19628 • DIN 50930-6 The device complies with the technical All materials are hygienically and physi- regulations for drinking water installation ologically harmless and fulfill the require- according to DIN EN 806ff. and the national 1701582 • 2018/12 JUDO JPF+... -
Page 8: Installation
This is indicated by an must be provided with additional arrow integral with the casting. fastenings or support. If the installation is twisted, back- INFO_NO_HEADER washing the device is not possible. JUDO JPF+ 1701582 • 2018/12... -
Page 9: Installation Of The Device
(see chapter 3.2). strained! The flange surface of the rotary flange fitting must be upright! For proper sealing the profile of the profile flange seal must point towards the rotary flange fitting (see Figure 2). 1701582 • 2018/12 JUDO JPF+... -
Page 10: Draining Of The Backwash Water
Pro- tect objects near the bucket from water damage! • Carry out the backwashing quickly and finish the backwashing process as soon as the bucket is half full. Otherwise the bucket could overflow. JUDO JPF+ 1701582 • 2018/12... -
Page 11: Commissioning
4.1.2 Due date of backwashing of the fine filter. The backwashing valve Every two months, a beep reminds you that opens on the bottom side of the device. the backwashing is due. 1701582 • 2018/12 JUDO JPF+... -
Page 12: Conversions, Changes
Attention: do not dispose of used batter- ies with the household waste, but in accor- dance with the local waste disposal regula- tions. JUDO JPF+ 1701582 • 2018/12... -
Page 13: Maintenance, Repair, Spare Parts
4.1). The DIN EN 13443-1 pre- ing in water damage to the build- scribes that the backwashing must take ing/home. place every six months. JUDO however recommends to comply with the information in chapter 4.1.1 Backwashing interval. Temporary removal of the... -
Page 14: Fault
Check the safety relief valve of the warm water boiler. stream pressure ble pressure Inform the installer or the closest customer service increases slowly increase due to point. at zero flow. process water heating. Troubleshooting JUDO JPF+ 1701582 • 2018/12... -
Page 15: Technical Data
Technical data Technical data Backwash protective filter JUDO PROFI-PLUS ¾" - 1¼" ¾" - 1¼" The water to be filtered must comply with the European Drinking Water Directive. Information about: JPF+ ¾" JPF+ 1" JPF+ 1¼" Pipe connection ¾" 1"... -
Page 16: Installation Dimensions
D Height below the pipe middle E Installation depth up to the pipe middle F Waste water connection up to the pipe middle G Waste water nominal diameter G1 Waste water nominal diameter (alterna- tive) JUDO JPF+ 1701582 • 2018/12... -
Page 17: Spare Parts
Technical data Spare parts JPF+ ¾" - 1¼" 1701582 • 2018/12 JUDO JPF+... - Page 18 Filter bowl 2010424 149 O-ring 10×3 Driver 2010146 53 Driver complete Driver Suction pipe gasket Sheet metal screw 2,9×9,5 Sieve insert 0,1 mm O-ring 90×4 O-ring 6,3×2,4 List of spare parts JPF ¾" - 1¼" JUDO JPF+ 1701582 • 2018/12...
-
Page 19: Disposal
Packaging waste is to be sent to the local recycling system. To protect environment, old appliances must not be disposed of with household waste. Instead, use the local collection and return points, which are committed to free and environmentally sound disposal. 1701582 • 2018/12 JUDO JPF+... -
Page 20: Customer Service
Industriestrasse 15 • CH-4410 Liestal Phone +41 (0)61 906 40 50 • Fax +41 (0)61 906 40 59 E-mail: info@judo-online.ch • judo-online.ch JUDO Wasseraufbereitung GmbH • Filiaal - Filiale BeNeLux Laarbeeklaan - Av. du Laerbeek, 72 A1 • B-1090 Brussel-Bruxelles BENELUX Phone +32 (0)24 60 12 88 •...
Need help?
Do you have a question about the PROFI-PLUS Series and is the answer not in the manual?
Questions and answers