Related Manuals for Judo QUICKSOFT MEGA
Summary of Contents for Judo QUICKSOFT MEGA
- Page 1 Operating instructions JUDO QUICKSOFT MEGA Water softening unit Valid for: EU countries and Switzerland Language: English Read before use and store!
- Page 2 This device is suitable for use in cold drinking water up to a maximum water judo.eu and ambient temperature of 30 °C. Office address The remote control of the JUDO QUICKSOFT MEGA via mobile JUDO Wasseraufbereitung GmbH phones and tablets using the con- Hohreuschstraße 39 - 41...
- Page 3 JUDO QUICKSOFT MEGA...
-
Page 4: Table Of Contents
5.14 Overview of display messages .. 18 6 Fault ..........18 7 Maintenance........18 7.1 Cleaning ........18 8 Warranty and service ...... 19 8.1 Inspection by the operator every two months (visual inspection) .. 19 8.2 Six-monthly maintenance JUDO QUICKSOFT MEGA... -
Page 5: About These Operating Instructions
Therefore, these operating instructions must Fig. 1: Rotary flange fitting be read by the installer and the responsible technical personnel/operators prior to instal- lation, commissioning and maintenance. JUDO QUICKSOFT MEGA... -
Page 6: Safety Instructions And Dangers Due To Non-Observation
Intended use includes observance of the op- = 14.2 ppm erating instructions. CaCO The manufacturer/supplier must be consult- ed before using the water softening system outside the limits of use described in these operating instructions. JUDO QUICKSOFT MEGA... -
Page 7: Indication Of Particular Dangers
Should this occur there is a risk of electric shocks to people. Therefore electrical devices/furnishings and equip- ment in the vicinity must be splashproof and/ or comply with the legal regulations for wet areas. JUDO QUICKSOFT MEGA... -
Page 8: Product Information
All information required for installation is contained in the installation instructions The water softening system is suitable for use 1703525 for the QUICKSOFT MEGA 6 wa- with cold drinking water having a maximum ter softening unit. water temperature of up to 30 °C. -
Page 9: Operation
- Accept value and save dication”) and one menu level back - Acknowledge message – Factory setting (see chapter 5.13 “Resetting to factory Display background lighting: setting”) – None: normal operation – Alternating light blue/dark blue: With a water flow JUDO QUICKSOFT MEGA... -
Page 10: Operating Mode
– Open the water supply (stopcock or Status display: shut-off valve). After a successful conclusion, the following – Ensure that the bypass valve (if in- text is output to the display: stalled) is set to “Operate”. Operating QUICKSOFT-P Fig. 4: Status display JUDO QUICKSOFT MEGA... - Page 11 For a correct high, a reduced water volume is treated. If measuring value comparison, the samples the raw water hardness is low, a greater wa- should be taken with a normal water flow ter volume is treated. JUDO QUICKSOFT MEGA...
- Page 12 1000 water legislation of 200 mg/l, then it can be mg sodium per litre. corrected by increasing the mixing water hardness. The calculation of the sodium content must then be repeated. JUDO QUICKSOFT MEGA...
-
Page 13: Menu Structure
Operation Menu structure Fig. 6: Menu structure JUDO QUICKSOFT MEGA... -
Page 14: Function Description
This means that the residual hardness temporarily increases in the pipe down- stream of the water softening system. JUDO QUICKSOFT MEGA... -
Page 15: Filling With Salt
The remaining salt stock is then primarily used for disinfection of the ion-exchange resin and the softening effect is reduced. In this way, the water softening system re- mains in a hygienic condition for weeks after the low regenerating salt state first occurs. JUDO QUICKSOFT MEGA... -
Page 16: Potential-Free Fault Indication
Setting • Fault relay Press the <OK> key. The display indicates the following: Fault relay Normally open Press key to change between <Nor- mally open> and <Normally closed>. JUDO QUICKSOFT MEGA... -
Page 17: Conversions / Changes / Spare Parts
– The connection flange must be protect- ed against dirt and damage. – Once the water softening system is fitted and started again, it must be flushed and regenerated (see chapter 5.3 “Operating mode”). JUDO QUICKSOFT MEGA... -
Page 18: 5.14 Overview Of Display Messages
(methylated spirits). vice number and order number avail- These substances can chemically attack the able (see fig. 3). plastic parts resulting in embrittlement and even breakage. Therefore do not use these types of cleaner! JUDO QUICKSOFT MEGA... -
Page 19: Warranty And Service
(see fig. 8) in the operating po- al solutions, salt or wear parts, etc. is per- sition. formed by the JUDO factory customer ser- vice team or by an approved technical – Salt deposits inside the water trap. -
Page 20: Data Sheet
The maximum operating pressure is Max. raw water hardness 125 °e lower to ensure the optimum function of the water softening system. Further information can be found in the in- stallation instructions 1703525 for the QUICKSOFT MEGA 6 water softening unit. JUDO QUICKSOFT MEGA... -
Page 21: Scope Of Supply
10 °e), galvanised pipes and copper pipes can be laid. Our recommendation: Installation of a JUDO JULIA dosing pump in the mixing water pipe downstream of the water softening system, so that the water can be admixed proportionally with a JUL mineral solution. - Page 22 Data sheet Fig. 7: Electronic control unit with fault message relay JUDO QUICKSOFT MEGA...
-
Page 23: Spare Parts
Spare parts Spare parts Fig. 8: Spare parts JUDO QUICKSOFT MEGA JUDO QUICKSOFT MEGA... -
Page 24: Disposal
Disposal Spare parts list QUICKSOFT MEGA Designation (recommended average replacement inter- Item Art. no. val for wear part [*]) Wear part set intake strainer ** 2201270 Wear part set pressure regulator **** 2200582 Spare part set injector 2201470 Spare part set hoses, complete... - Page 25 Notes JUDO QUICKSOFT MEGA...
- Page 26 Notes JUDO QUICKSOFT MEGA...
- Page 27 Notes JUDO QUICKSOFT MEGA...
-
Page 28: Customer Service
Tel. +41 (0)61 906 40 50 • Fax +41 (0)61 906 40 59 e-mail: info@judo-online.ch • judo-online.ch JUDO Wasseraufbereitung GmbH • Filiaal - Filiale BeNeLux Laarbeeklaan - Av. du Laerbeek, 72 A1 • B-1090 Brussel - Bruxelles Tel./Tél. +32 (0)24 60 12 88 • Fax +32 (0)24 61 18 85 e-mail: info.benelux@judo.eu •...
Need help?
Do you have a question about the QUICKSOFT MEGA and is the answer not in the manual?
Questions and answers