Cautions For Inspection And Service Of Air Cleaner; Checking Hoses And Lines; Checking The Wiring Harness And Fuses - Zetor HORTUS HS CL Operator's Manual

Cautions for inspection and service of air cleaner

(1) Use the standard element and filter and do not apply oil on them.
(2) Remove any dust in the cover thoroughly.
(3) Install it firmly so that dust does not enter below the cover.
(4) Never drive with the element and filter removed.
(5) Replace the air cleaner filter and element according to their replacement schedule and when their
indicator comes on.
Note:
Do not hit the element with a rock or concrete during its cleaning.
Make sure to install the element firmly.
Tighten each part of the air cleaner securely to block dust completely.
Replace the element after cleaning it 5 times or it is damaged.

Checking Hoses and Lines

The fuel lines, radiator hoses, hydraulic and rubber hoses are consumables, which deteriorate by age and
use. Check them regularly and replace if faulty.
Caution:
Damaged fuel lines leak and cause fires.
Damaged radiator hoses can cause hot water burns and in severe cases seize the engine.

Checking the Wiring Harness and Fuses

Loose wires make inferior connections and damaged wires can cause short circuits, fires burnt wiring or
reduce efficiency of components.
Replace or repair any faulty wiring or insulation.
If a fuse burns out again after it has been replaced, do not replace it with wire or a high capacity fuse, find
the cause and rectify it or get an auto electrician to do so.
Where insulation is chafed or peeled off, recover the area with a good quality insulation tape. Where wiring
comes out of it's fitting replace it correctly with the standard fitting.
Important:
Incorrect wiring or fuses can cause fires to both the tractor and surrounding area so get the
dealer to check it annually.
Likewise fuel pipes and wiring age with use.
Ask your dealer to check it at least once every 2 years and replace as required.
MAINTENANCE
100