Handover/sale to a new owner ....................31 Guarantee ..........................31 Frame number..........................32 Form service, maintenance, modifications and warranty claims..........33 Contact details manufacturer Van Raam Guldenweg 23 7051 HT Varsseveld The Netherlands Tel. : +31 (0)315 257370 E-mail : info@vanraam.com Internet : www.vanraam.com User Manual | Chat 19.06...
Conformity Van Raam declares as manufacturer that the Chat tricycle, as described in this manual, has been produced in accordance with the 2006/42/EG guidelines. The declaration of conformity can be found on the Van Raam website. Introduction This user manual provides important and necessary information about the use of your tricycle.
Make sure that wide trousers or lose hanging clothing don’t get caught in the chain, spokes or pedals. Block the tricycle to stop it from moving when you are getting on or off the tricycle. Do this by using the parking brake and holding the tricycle. User Manual | Chat 19.06...
Page 5
If not, the guarantee ceases to be valid and you will be personally responsible in the event of possible damage. Specific safety parts should always be replaced by new parts! User Manual | Chat 19.06...
Don't pull out the seat post further than the markings. If you do so, the tube won't be inserted deep enough into the shaft, increasing MIN INSERT the risk of breakage, which may lead to serious injuries. User Manual | Chat 19.06...
Page 7
Feel free to determine what setting is most comfortable for you. To tilt the handlebar: 1. Loosen the screw using an Allen key. 2. Place the handlebars in the desired position and firmly tighten the screw. User Manual | Chat 19.06...
Page 8
1. Fasten the metal fittings together. 2. Adjust them by pulling the loose end of the belt. 3. To remove the belt, lift the top part of the buckle and disconnect the fittings. User Manual | Chat 19.06...
When cycling in the dark, make sure there is always a battery present on the bike! When the battery is almost empty, the motor will no longer provide support while cycling. However, the switchable lighting will still work on the residual power. User Manual | Chat 19.06...
Page 10
5. Have the passengers take their place on the bike and secure the seatbelt around the passengers. Place legs and feet inside the footrest space so limbs do not get trapped! User Manual | Chat 19.06...
Page 11
Only use the footrest when standing still. The footplate is only intended to support the passengers’ feed. Do not load heavy objects on the footrest and don’t stand on it while the footplate is raised. User Manual | Chat 19.06...
Page 12
Gears Your tricycle has eight gears. The gears can be adjusted by turning the handle. Your tricycle has an electric motor at the rear, you must continue pedalling when changing gears. User Manual | Chat 19.06...
Page 13
It may happen that the back wheel comes off the ground on the inside when going round a bend. To avoid this, the rider leans towards the inside of the bend with his body. User Manual | Chat 19.06...
Page 14
Please note that the front has a small blind spot where you do always not have an optimal view. Make sure not to ride at dangerous speeds when riding downhill. Brake in time and bike at a moderate speed. User Manual | Chat 19.06...
Electro system Silent The Silent Electric motor system is a special developed support system by Van Raam for the rehabilitation market. The system is characterized by: A simplicity of operation Individually adjustable support for cycling Modern and efficient electronics The powerful electric motors...
Page 16
Extra support when starting. Extra support for cycling uphill. Tip: when cycling a steep climb, you can use support in level 3 and push the start assist repeatedly for five seconds to achieve maximum support. User Manual | Chat 19.06...
Page 17
The reverse mode is activated by pedalling backwards from a standing position. Within a few seconds the motor is activated and the tricycle cycles at a speed of about 2 km/h backwards (when you start to pedal backwards). User Manual | Chat 19.06...
Page 18
Other functions The smart display has an automatic dimming function. With an inbuilt light sensor the lights of the display will automatically creating less distraction for the cyclist in darker or more shadowy conditions. User Manual | Chat 19.06...
Page 19
7. Once the battery is fully charged, the green LED light stays on. Pull the plug from the mains socket first or turn the switch [A] off. 8. Then pull the connector from the battery. User Manual | Chat 19.06...
Page 20
11. Push the handle forward and close the lock. It is also possible to charge the battery while it is still in the holder. Do not wait until the battery is completely empty. It is better to recharge the battery interim. User Manual | Chat 19.06...
Page 21
Even if the battery is not used, its capacity will decrease. A worn battery can still be used, but please bear in mind that its charge level may decrease. User Manual | Chat 19.06...
Page 22
5 degrees. Only use the charger indoors and in non-humid environments, the charger may not get wet. Only use the Van Raam supplied battery. Only charge the battery with the supplied charger! ...
Van Raam e-Bike App The Van Raam bicycle App is a free smartphone application that you can use while cycling with your Van Raam electric bicycle. You can connect the Smart Display with the Van Raam App due Bluetooth connection.
[A]. Then remove the rings [B] from the cams. Zip open the back flap of the canopy. Hold the front of the canopy, so it cannot tip forwards and undo the pushbuttons on the back. User Manual | Chat 19.06...
Page 25
Remove the top part of the canopy construction and place this in the suspension hooks on the back of the seat. Move the elastic around the poles on both sides. User Manual | Chat 19.06...
Page 26
For the lowest setting [B] move the curved poles down and set the securing pin to the top opening. First set the canopy to the desired height and then pull the canopy to tension. User Manual | Chat 19.06...
Cleaning the upholstery The upholstery of the seat is removable and may be cleaned. To do so, remove the upholstery from the cushions. You can wash the upholstery in the washing machine up to 40°C. User Manual | Chat 19.06...
Page 28
If you choose to replace components by yourself, you will be liable for any damage or injury caused by improperly installed components. Only use original Van Raam spare parts. You can purchase these from your dealer. Upon request, the dealer will provide the necessary information for repair and maintenance.
In that case the rim must be replaced. If not, this may negatively impact the operation of the brakes or may even cause a break in the rim with all sorts of dangerous consequences. Repairs, maintenance and modifications may only be performed with original Van Raam parts. User Manual | Chat 19.06...
4. Lightly tighten the nuts of the rear wheel axis. 5. Make sure the tension on the chain is adequate and that the wheel is attached straight to the frame. 6. Now firmly tighten the nuts. User Manual | Chat 19.06...
Page 31
7. Tighten the nuts of the steering shaft again. 8. Finally point the handlebar straight ahead. Make sure the wheels also face straight ahead at that moment. 9. Check whether the tricycle easily drives straight ahead on the tyres, without resistance and friction. User Manual | Chat 19.06...
This is also the case if unauthorized maintenance is carried out or if technical changes or additions are made with non-original Van Raam parts without permission of Van Raam. The original CE certification will become nul-and-void if modifications are done by third parties.
Frame number The frame number is printed on the sticker. This sticker is located on the frame, see the image below. Example sticker: Position of sticker: behind the seat tube User Manual | Chat 19.06...
The following items are changed to the bike: Changed: Date: Carried out: Beware! Please note that if changes are made by a non-authorized Van Raam dealer or no original Van Raam parts or options are used, warranty may void. User Manual | Chat 19.06...
Page 35
Here you have space to take notes or write down the maintenance on your bike: User Manual | Chat 19.06...
Page 36
Here you have space to take notes or write down the maintenance on your bike: User Manual | Chat 19.06...
Page 37
Here you have space to take notes or write down the maintenance on your bike: User Manual | Chat 19.06...
Page 38
Congratulations on your purchase of your Van Raam tricycle. This bike is produced with utmost care. To guarantee the quality as much as possible Van Raam produces the cycles according to the ISO 9001: 2008 quality standards. Van Raam has been certified by TÜV Rheinland Netherlands BV.