Xtreme Manufacturing XR1147 Operation And Safety Manual page 47

Operation
Lead-acid batteries produce flammable and potentially ex-
plosive gases. To avoid death or serious injury when check-
ing, testing, or charging batteries:
• DO NOT use smoking materials near batteries.
• Keep arcs, sparks, and open flames away from batteries.
• Provide ventilation for flammable vapors.
• Wear proper personal protective equipment, including
safety glasses.
Fluid in electric storage batteries contains sulfuric acid,
which is poison and could cause severe chemical burns.
Avoid all contact of fluid with eyes, skin, or clothing. Use
protective gear when handling batteries. DO NOT tip a bat-
tery beyond a 45° angle in any direction.
If contact does occur, follow these First Aid suggestions:
• External contact - Flush with water.
• Eyes - Flush with water (including under the eyelids)
for at least 15 minutes and get medical attention
immediately. Flushing must begin immediately to
avoid permanent eye tissue damage.
• Internal contact - Drink large quantities of water or milk
to dilute stomach contents. Do not induce vomiting.
Get medical attention immediately.
IMPORTANT - In case of internal contact, DO NOT give fluids
that induce vomiting.
California Proposition 65
Battery posts,
accessories contain lead and lead compounds,
chemicals known to the State of California
to cause cancer, birth defects, or other
reproductive harm. Wash hands after handling these items.
Wear eye protection when starting a Telehan-
dler with jump start cables. Improper jump
start procedures could cause the battery to
explode, which could result in death or seri-
ous injury.
Warning
Warning
terminals, and
Warning
• Never jump start a frozen battery, as it can explode. Let
the battery thaw out before charging.
• NEVER jump start the Telehandler when travel select
lever is in gear, which can cause the Telehandler to lurch
forward or backward, and could result in death, serious
injury, or property damage.
• To avoid injury or death when jump starting with
another Telehandler, make sure the two (2) Telehandlers
are not touching.
• DO NOT allow jump start cable ends to contact each
other.
• Connect charged battery positive (+) to stalled battery
positive (+).
• Connect charged battery negative (–) to stalled
Telehandler ground. Make the connection to the stalled
Telehandler ground last.
• Connect jump start cable to stalled Telehandler ground
a safe distance from the battery to prevent sparks near
the battery.
• Jump start only with a power source with the same
voltage as the stalled Telehandler.
• Turn off all lights and accessories on the stalled
Telehandler to prevent them from operating when the
power source is connected.
• Electrolyte contains acid and could cause serious
personal injury if it contacts the skin or eyes.
related
Use DEF meeting ISO 22241-1. There is NO acceptable
substitute. Using anything other than DEF fluid may result
in permanent aftertreatment damage.
parts or components are corroded excessively.
Inspect Telehandler and attachments periodically for corro-
sion.
47
Warning
Tires must have proper ballast. DO NOT
replace foam-filled tires with pneumatic tires.
Use of pneumatic tires will severely affect
Telehandler load capacity, which could result
in death, serious injury, or property damage.
Warning
All the attachments should be stored in an
appropriate enclosure as to prevent corro-
sion and deterioration due to environmental
conditions.
Do not use Telehandler or attachments if any
Operation Manual