Page 1
DONG FENG DONG FENG H30 CROSS DONG FENG S30 Owner’s Manual This Manual has been prepared for owner’s reference to vehicle’s performance, safety, maintenance and everyday use guidelines. Keeping the manual in your car is recommended for quick reference.
Page 2
In The Name of God OWNER’S MANUAL DONG FENG (H30 CROSS - S30)
Pay special attention to the messages highlighted by these signal words: In the meanwhile consumptive material must be provided through authenticated representatives of IKCO. WARNING: Indicates a potential hazard that could result in death or injury.
The pictures, data and relevant notes in the user’s manual conform to the definition of product upon preparation of the manual. IKCO is continuously dedicated to improving the appearance, interior trims and technical specifications of the vehicle. The pictures, data and relevant notes in this manual are inapplicable as basis for order acceptance.
Page 7
& manual transmission, automatic A/C and MP5 audio system etc.) shall prevail if common to three models. Your Dongfeng car is installed with various advanced automotive electronic control units and can only be maintained and serviced either by the Dongfeng Franchise Store; or IKCO authorised representatives;otherwise, your car may lose the technical and quality guarantee.
Page 8
YOUR VEHICLE AT A GLANCE Thanks for choosing this model. Before driving on road, please read this user’s manual carefully. This manual covers driving modes, important information on equipment, suggestions to be followed strictly as well as service/ maintenance and precautions, so as to ensure your personal safety and car reliability. Comprehensively understanding your car may bring you more driving pleasure.
Page 9
• Do not start the engine when the maintained regularly at either Dongfeng especially the driving safety. battery is under charge, because the Franchise Store or IKCO authorised Therefore, please use and maintain the engine electronic control unit and the representatives as per the Warranty...
Page 10
If it is • Do not drive the vehicle after drunken or drugged; necessary, contact either Dongfeng Franchise Store or IKCO authorised • Make sure to observe the speed limit representatives. marks and do not overspeed;...
Dongfeng for 3 times. for 5 times and all turn signal lamps will Franchise Store or IKCO authorised Locking: The turn signal lamp is on for fl ash for 15s approximately to facilitate representatives correct the fault, if any.
Page 18
- Turn the ignition switch to M position replaced either Dongfeng when the vehicle is stopped. Franchise Store or IKCO authorised - Press down the locking button representatives. the door at the driver’s side for 2s. Replacement of remote controller...
NOTE : If the door (incl. trunk lid) is left open or not properly closed, the electric central locking cannot function. And in this case, only the door at the driver’s side may be locked, with other doors left unlocked. Before leaving the vehicle: The key can be used to connect the NOTE :...
Page 20
If the cipher immobilizer indicator lamp The vehicle cannot be started if the key fails to light up under the above-mentioned fails to be recognized. conditions, please consult with either or IKCO Dongfeng Franchise Store authorised representatives...
DOOR OPENING/CLOSING Opening the door outside Opening the door inside Locking/unlocking doors inside Press down the unlocking button on the Opening the driver’s door from inside will Close all doors, press down the locking remote controller or insert the key into unlock the central locking mechanism button on the armrest at the left side...
CHILD SAFETY LOCK AND TRUNK LID (LIFTGATE) Spare opening mode for trunk lid Child safety latch Trunk lid (liftgate) (liftgate) The child safety lock is designed for There is one opening switch in the When the central locking mechanism is preventing the child on the rear seat from release handle of trunk lid.
ENGINE HOOD OPENING/CLOSING Closing the engine hood Stably support the engine hood by hands and push it backwards slightly to make the strut detach from the supporting hole. Then clamp tightly the strut after being seated, lay down the engine hood slowly to the bottom limit, and check that the engine hood is locked.
Page 24
REFUELING/ FUEL CUTOFF DEVICE Fuel type The label affixed on the fuel tank cap states the allowable fuel type. Lead-free gasoline of 93# or above Fuel tank cap with lock Fuel cut-off device Open the fuel tank cap and insert the The fuel cut-off switch is installed beside key into the fuel tank cap lock hole;...
Page 25
THREE-WAY CATALYTIC CONVERTER The three-way catalytic converter helps - Collision, water pouring and immersion to substantially reduce the hazardous must avoided, orelse, matters contained in the engine exhaust purification effect of converter will be gas, contributing to the environmental weakened considerably; protection.
Page 26
It is prohibited to use the leaded gasoline, which will damage the threeway catalytic Dongfeng Franchise Store or IKCO ignition coil is disconnected; converter and cause the engine failure authorised representatives according –...
Page 27
– During the running-in period, the Dongfeng Franchise Store or IKCO engine speed should not be higher authorised representatives. than 4,000r/ min; – Avoid emergency braking as far as possible;...
Page 29
FRONT SEAT Headrest adjustment Backrest inclination adjustment Press the button beside the Lift up the adjusting handle headrest rod hole to adjust to adjust the backrest Warning: • For driving safety, adjust the front seat headrest inclination appropriately. when the vehicle is stopped. appropriate height which Afterwards, press down the adjusting •...
Page 30
REAR HEADREST Lift up the headrest from low position to high position. When it is required to lower the rear Warning: During driving, do not take off the headrest, press and hold the locking headrest used to protect the neck. button and press the headrest downwards.
Page 31
REAR SEAT (S30) Rear seat Rear seat cushion tilting With rear seat cushion tilted The rear seat backrest is of one-piece The seat cushion is tiltable. Lift up the and equipped with two headrests. It can rear seat cushion front and back be folded frontwards as a whole.
Page 32
REAR SEAT (S30) Rear seat full-folding Press the buckle of lower anchorage of After folding the rear seat, the cabin Tilt the rear seat cushion and take off the the middle seat belt to detach the latch is connected with trunk, enlarging the rear headrest.
Page 33
REAR SEAT (H30, H30 CROSS) Backrest resetting Place the seat belt at two sides and push the seat backrest upwards until it is locked reliably. Note: When resetting the rear seat backrest, always place the side belt at two sides smoothly, pull out the middle seat belt and insert the lower latch plate into the corresponding buckle.
Page 34
STEERING WHEEL POSITION ADJUSTMENT Warning: It is prohibited to adjust the steering wheel position during driving. Steering wheel position adjustment limit to lock the steering wheel; – When the vehicle is stopped, adjust – Try to move the steering wheel back the seat to the appropriate position and forth as well as up and down to (see Page 30);...
Page 35
DRIVING POSITION Illustrated driving position: Backrest inclination height to make it not obstruct the Correct Adjust the backrest to enable the instrument observation. Incorrect (too close) driver’s back to lean against the seat Incorrect (too far) in whole height comfortably. To ensure Safety belt adjustment (see Page 44) Recommendations on adjustment of Fasten the safety belt and make it pass...
• Replacement of airbag system: After either by the designated Dongfeng the airbag inflates or the vehicle has Franchise Store or IKCO authorised been in service for 10 years, it is a representatives following...
Page 37
AIRBAG Front airbag Front airbag -working airbag, supplementary In case of violent front collision, the protection for safety belt, is used to airbag will swell immediately and deploy create a buffering bag between the front from the steering wheel middle part or passenger and the instrument panel in the instrument panel in front of right front case of strong front collision, so as to...
Page 38
AIRBAG Front airbag – basic knowledge 2. The front airbag will not inflate in 1. Inflating conditions: the following traffic accidents: The airbag inflating command will be – Rear-end collision; sent when the vehicle collision angle and – Vehicle side turn or rollover; intensity detected by the deceleration –...
Page 39
AIRBAG Front airbag – Illustration for possible non-inflating Collision with guardrail or other Collision after the front airbag has vehicles in left / right front been activated once Rear-end collision Entering under the container wagon Side turn or rollover or large vehicle...
Page 40
AIRBAG Front airbag - precautions – Always fasten the safety belt well; – Do not fix or stick any article on the steering wheel middle airbag cap and instrument panel within the area of passenger airbag, because it may impede the normal airbag working or hurt people during airbag inflating;...
Page 41
AIRBAG Side airbag - working In case of violent side collision, the airbag on the collided side will inflate and swell and then deploy from the designated tear on the front seat backrest, so as to mitigate the impact to the front occupant towards the door side;...
SAFETY BELT Why should the safety belt be fastened? It is proved that the safety belt can provide proper protection case of accidents, therefore, the national regulations specify that the safety belt shall be fastened. Taking a simplest vehicle as an example, The vehicle is driven at a certain speed someone takes...
Page 43
SAFETY BELT If the passenger does not wear the safety belt, all of his/her kinetic energy during the collision accident can only be absorbed by his/her body and the collided objects. With the increase of vehicle speed, the force exerted on human body will be geometrically multiplied against the vehicle speed.
Page 44
SAFETY BELT The kinetic energy can be well absorbed by the safety belt; therefore, passengers will benefi t a lot for protection if the safety belt is worn correctly. Other front buffer mechanisms and supplementary safety facilities including airbag system can also absorb the kinetic energy and mitigate passenger’s injury.
Page 45
SAFETY BELT Why the safety belt shall be fastened Why the safety belt shall be fastened Misunderstandings on application of safety belt since the vehicle has been provided if I can drive the vehicle safely? with airbag? Will you be tripped in the car if the In case of traffic accidents even not due safety belt is fastened? Airbag is just a supplementary system...
Page 46
Franchise Store or IKCO authorised - The protection of safety belt can play to the full as long as the belt is fastened products, or else, the latch plate representatives correctly.
Page 47
SAFETY BELT How to fasten the safety belt correctly Adult The current safety belt is only applicable to adult in common height. To ensure the safety of each occupant, please follow the specific precautions for the application of safety belt for child and those regulations for infants.
Page 48
SAFETY BELT 5. Pull the safety belt latch plate end The lap belt should be fastened a little Safety belt height adjustment front passenger adjust downwards and the shoulder belt bit low and just in contact with the thigh. the height of safety belt anchorage upwards at the same time to tension the Therefore, in case of collision, the force according to his/her body shape.
Page 49
SAFETY BELT Pretensioned front seat belt The front seat is provided with the height adjustable safety belt with pretensioner and retractor. The pretensioner is designed to tension the safety belt in case of serious front collision, thus keeping the occupant’s body closely against the seat and improving the protection effectiveness.
Page 50
SAFETY BELT The safety belt cannot function for The seating position is too far away from The shoulder belt should not pass protection if the shoulder belt is too the safety belt latch plate. through under the arm but above the loose.
Page 51
If so, smoothen the safety belt to make it work correctly. If the safety belt cannot be smoothened, contact either Dongfeng Franchise Store or IKCO authorised representatives.
Page 52
SAFETY BELT the key to ensuring effectiveness of the safety belt. Application of safety belt for children The accident statistics prove that it is relatively safer to ask the older children (at an age of 10-15) take the rear seat and fasten the safety belt.
Page 53
SAFETY BELT Warning: Never fasten the safety belt as shown! The child as shown takes a seat provided with lap-shoulder belt but with the shoulder belt located at the back of shoulder. In this case, during the vehicle collision, the child may slide under the safety belt to make the action force just exerted on the child belly, possibly causing serious casualties.
CHILD SAFETY When a child takes the vehicle without child restraints. But the safety - Do not leave the child alone in the To ensure safety, please understand and vehicle exposed to the sun. belt is still a must. Child should be placed on the rear consider the following requirements: - Ensure that there is no danger and - The child must take the safety seat.
Page 55
CHILD SAFETY ISO FIX child safety seat anchorage After adjusting the rear seat headrest On H30 and H30 CROSS models, the child seat anchorage supports are height, have the top strap of the child On S30 model, the child seat upper located at the back of the rear seat safety seat threaded through the middle anchorage supports are located on...
Page 56
CHILD SAFETY We recommend to apply the child safety Child of 1-3 years old Child of 1-10 years old seat suitable for securing by safety belt, L2 type seat: Secure it with the 2/3-point L5 type seat: Secure it on the rear seat so as to ensure the child’s safety to the belt.
Page 57
CHILD SAFETY Warning: Never hold the infant in your arm during driving. The weight of the infant before vehicle collision is light, however its inertia mass may increase substantially so that you cannot hold it firmly any more. For Warning: instance, a 5.5kg infant may turns to Do not let several persons share be 110kg and exert gravity on your...
Dongfeng Franchise from the glazing agent, engine oil, be locked in the above-mentioned Store or IKCO authorised representatives chemicals, especially electrolyte. cases, replace the safety belt assembly If torn or worn out, the safety belt is It is much safer to clean the safety mandatorily.
DOOR WINDOW REGULATION Electric regulator switch Press the door window regulator switch forward, and then the corresponding window will lower down. Release the switch to stop. Flip back the door window regulator switch, and then the corresponding window will rise. Release the switch to stop.
DASHBOARD • Central locking switch 1) Left treble loudspeaker button* 2) Left door window defrosting vent 13) Front airbag of front passenger 33) Sun visor 34) Interior lighting lamp 3) Left vent 14) Right vent 4) Light combination switch 15) Right door window defrosting vent 35) Interior rearview mirror •...
INDICATING INSTRUMENT The maximum engine speed should not go within the red area. During the vehicle driving, it is inappropriate to have the engine run at a speed lower than 2,000r/min for a long time. The economic engine speed is about 2,500r/min. Tachometer Speedometer When the engine is started in cold...
Page 64
INDICATING INSTRUMENT Overheating may result from various reasons. Please contact either nearest Dongfeng Franchise Store or IKCO authorised representatives The cooling fan may keep working for a while after the hot engine is stopped. Fuel gauge Water thermometer The vehicle running at a too low fuel High water temperature warning lamp level should be avoided;...
INDICATOR LAMP AND WARNING LAMP Left turn signal indicator lamp By operating the turn signal lamp switch, Right turn signal indicator lamp See Page 78 for details the outside turn signal lamp will glisten See Page 78 for details and the corresponding indicator on the instrument panel will flash.
Page 66
INDICATOR LAMP AND WARNING LAMP Store Position lamp indicator Parking brake warning lamp or IKCO authorised representatives for servicing. See Page 79 for details If the parking brake lever is not released or is just released partially, the Door ajar warning lamp Low beam indicator warning lamp will be lighted.
Page 67
Dongfeng Franchise Store as soon or IKCO authorised representatives Minimum fuel level warning as possible. lamp When the minimum fuel warning lamp is lighted, it suggests that about 6L fuel remains in the fuel tank for usage.
COMBINATION DISPLAY Functions of combination display Ignition switch turned on Trip meter zeroing The combination display is divided into The combination display recovers to Press down the function selector button two functional zones: the display before the ignition switch is quickly to select the subtotal mileage Zone : displaying the gears of automatic...
Page 69
COMBINATION DISPLAY Instrument panel luminance adjustment – Turn on the ignition switch (M position). – Press down the function selector button quickly to select the function of Luminance of 0-25% odometer, trip meter and instrument Max. luminance panel luminance adjustment. –...
Page 70
If the gear display on the combination display demonstrates symbol “-” with the “ ” and “ ” indicator lamp flashing and the audible signal sounded, the automatic transmission may operate abnormally. In this case, please contact either Dongfeng Franchise Store or IKCO authorised representatives...
Page 71
“-” shown below. Gear display: with the “ ” and “ ” indicator lamp flashing and the audible signal sounded, the automatic transmission may operate abnormally. In this case, please contact the Dongfeng Franchise Store or IKCO authorized representatives.
MULTI-FUNCTION DISPLAY (SEGMENT CODE) General The multi-function display is used to display clock and date; through the operation of function key D, the following information can be shown in the display area in sequence: Instantaneous fuel consumption/average fuel consumption/average speed /mileage/driving range and others. The backlight of the multi-function display is linked with the light combination switch.
Page 73
MULTI-FUNCTION DISPLAY (SEGMENT CODE) Examples of display mode Average fuel consumption display: Mileage display: 24h system, 18:00 24h system, 18:00 Average fuel consumption: 6.0L/100km Mileage: 560km Normal: Door self-locking deactivated Door self-locking deactivated 24h system, 18:00 Calendar (Feb. 9 Door self-locking deactivated Instantaneous fuel consumption Average speed display: Driving range display:...
Page 74
MULTI-FUNCTION DISPLAY (SEGMENT CODE) Function description Year – Press down the D key again to switch Clock to the mileage display (see examples • Year mode: the year is displayed only of display mode) • Displaying 24h system time with an in year setting mode (with the year digit –...
Page 75
MULTI-FUNCTION DISPLAY (DOT MATRIX) General The multi-function display is used to display clock, date and outside temperature; through the operation of D key, the following information can be displayed in the display area in turns: Travel information such as normal mode and travel information 1 and travel information 2. The multi-function display backlight is linked with the light combination switch.
Page 76
MULTI-FUNCTION DISPLAY (DOT MATRIX) Examples of display mode Travel information 1: Power interface: Displaying the normal mode information as well as: Instantaneous fuel consumption: Displaying the DONGFENG AEOLUS 8.2L/100km brand for about 3s. Average speed: 35km/h Mileage: 366km Normal mode: 24h system time, 11:45 pm Travel information 2: Outside temperature: 4ºC...
Page 77
MULTI-FUNCTION DISPLAY (DOT MATRIX) Examples of display mode The multi-function display may, according to the activated vehicle functions, display the following function states. Interface displaying reverse radar distance Interface indicating that parking brake is not released Interface indicating door self-locking is deactivated Interface indicating door self-locking is activated...
Page 78
MULTI-FUNCTION DISPLAY (DOT MATRIX) Function description Temperature Keep the state for 5s and automatically Clock switch to the month setting mode (with The outside temperature is displayed on the month digits flashing): press down • Displaying 24h system time with an the right top of the display as long as the the H key for increasing months and M initial display of 00:00 and the second...
Page 79
“---” is displayed for three levels of short bars flash all the Driving range. time, please contact the Dongfeng After the system receives the cruise Franchise Store or IKCO authorized control signal, letters reading representatives in time for system “cruise control”...
STEERING WHEEL* are control keys integrated Volume adjustment on the steering wheel. Press the “+” at the upper part of the VOL key to increase the volume; mode switchover Press the “-” at the lower part of the VOL Press MODE realize key to decrease the volume.
H30 CROSS ROOF RACK – Distribute the load uniformly to avoid overload on one side; – The part loaded with the heaviest Note: object should be as close to the middle The maximum load distributed on the roof rack should not be more of the roof as possible;...
LIGHT COMBINATION SWITCH AND HAZARD WARNING LAMP Turn signal lamp switch Press down the combination switch handle to turn left. Lift up the combination switch handle to turn right. During steering, make combination switch handle overpass the limit point in the designated direction, and the turn signal lamp switch handle will automatically reset along with the alignment of steering wheel.
Page 83
LIGHT COMBINATION SWITCH When turning off the position lamp, the ring B for front/rear fog lamp will rotate along with it, automatically disconnecting the rear fog lamp and returning to the front fog lamp position. Note: The fog lamp is used in foggy, rainy or snowy days only.
WIPER COMBINATION SWITCH Rear windshield washer switch (H30, H30 CROSS) Rotate the ring on the handle forwards continuously to the position , and then the washing and wiping will be performed at the same time; release the handle to stop the fluid spraying. Then, when the switch returns to position automatically, the wiper continues wiping for three times and then automatically...
Page 85
YOUR VEHICLE AT A GLANCE A: Working position of electrical driver’s safety belt unfastening warning accessories lamp. If the ignition key is at this position, the electrical accessories can be used and the battery charging indicator lamp will be lighted. Ignition switch operating...
ENGINE START Ensure that the shift lever is switched to the N (MT) or P/N position (AMT). Engine cold start Danger: Do not take off the ignition key if Before starting, do not depress the the vehicle is not completely stably accelerator pedal back and forth in parked, or else, there is a risk that advance.
REARVIEW MIRROR Interior rearview mirror Electric exterior rearview mirror The rearview mirror plane is of sphere to enlarge the visual field on sides. Grip and rotate the interior rearview Select the rearview mirror to be adjusted: The distance of objects seen from the mirror to adjust it to the appropriate Rearview mirror at driver’s side mirror is father than the actual situation;...
HEADLAMP ADJUSTMENT If the vehicle drives on the bumps, the headlamp may directly project to the rearview mirror or the exterior rearview mirror of the vehicle in front or to the windshield of the incoming vehicle, making other drivers fail to see clearly. If it is necessary to adjust to the appropriate light velocity, rotate the corresponding switch.
Page 90
DRIVING TRANSMISSION (STARTING/DRIVING) * ......90 ELECTRIC POWER STEERING* ........96 BRAKE ................. 97 REVERSE RADAR* ............99 REVERSE IMAGE* ............100 *If installed on your vehicle...
TRANSMISSION (STARTING/DRIVING) * Note: When the vehicle equipped with the reverse radar is shifted to the reverse gear, the radar alarm will beep once. Note: Protect automatic transmission control panel guide groove from invasion of foreign matters such as coins and melon seeds as well as fluids such as water and juices, to avoid transmission Manual transmission...
Page 92
TRANSMISSION (STARTING/DRIVING) * Gear display automatic Snow mode: The relatively transmission gentle driving mode is applicable The upper area of the combination for driving on the wet and slippery road display on the instrument panel is for since the engine speed during automatic gears display of automatic transmission.
Page 93
TRANSMISSION (STARTING/DRIVING) * Gear selection automatic D: Automatic direct gear D gear is for normal use and can be transmission applied for vehicle start at any time. The Note: P: Parking gear It is prohibited to make the vehicle automatic transmission can automatically During parking, park...
Page 94
TRANSMISSION (STARTING/DRIVING) * When the vehicle is travelling at D gear, the M gear can be switched to at Note: any time, and the transmission can be When the vehicle equipped with the switched to manual mode. According reverse radar is shifted to the reverse to the road condition, push the shift gear, the radar alarm will beep once.
Page 95
TRANSMISSION (STARTING/DRIVING) * Gear display for automatic & Snow mode: The relatively manual transmission gentle Note: The upper area of the combination driving mode is applicable for driving The automatic & manual transmission display on the instrument panel is for on the wet and slippery road since the is not provided with shift level P-gear gears display of the automatic &...
Page 96
TRANSMISSION (STARTING/DRIVING) * Gear selection of automatic & manual D: Automatic direct gear transmission D gear is for normal use and can be P: Parking gear applied for vehicle start at any time. During parking, park vehicle automatic transmission completely stably at first and then switch automatically realize shifting within 1 the shift lever to this gear.
Dongfeng Franchise Store or to operate the steering wheel the steering wheel becomes harder. It, IKCO authorised representatives. especially during sharp turning or however, will recover to be normal after low-speed driving. the temperature of the electric power steering system lowers down.
BRAKE Type of brake Function of ABS The brake system has two independent hydraulic oil circuits. If one circuit fails, This vehicle applies the vacuum booster ABS is the abbreviation for anti-lock the other can brake the wheel as well. brake, which utilizes the engine vacuum brake system.
Page 99
BRAKE If the ignition switch is connected but the parking brake lever is not released or not Warning released completely, the parking brake • Do not drive the vehicle when warning lamp will be lighted. the parking brake is applied, or else, the brake will fail to work due to overheating, thus causing accidents.
REVERSE RADAR* If the obstacle is about 30cm away from the detecting sensor, the buzzer will send out continuous alarms. Be much Note: The detecting range of the reverse radar, more careful at this moment. even if equipped, is limited; therefore, Activating/deactivating observe the environmental condition carefully behind the vehicle tail as well so...
REVERSE IMAGE* Reverse image Reverse image display Green area: safety area where the Reverse camera The display will show the relative distance obstacle is about 300cm away from the The reverse camera is installed beside the between the vehicle tail and the obstacle vehicle tail Yellow area: trunk lid switch.
Page 102
REVERSE IMAGE* Danger: • The reverse image system can facilitate the drivers, but not substitute the correct reverse method. Before reversing, check the rear side for safety and reverse slowly. • Due to the application of wide-angle lens, the distance seen from the reverse image system is different from the actual one and the objects will be distorted.
VENT Air inlet To ensure the normal cooling/heating Air outlet Please keep the air inlet grille damper effect of the rear seats, please do not The knob controlling the air outlet and vent clean (removing foreign block exhaust ports on both sides of flow and the grille damper (which can matters such as fallen leaves, snow trunk.
AUTOMATIC A/C* The system will adjust temperature Refrigeration button (A/C switch) Temperature adjustment knob and air volume inside the vehicle Adjustment button of air distribution Display of set temperature automatically depending your Selector button of external air Refrigeration switch display choice.
Page 107
AUTOMATIC A/C* The following five functions can be 1-Temperature adjustment knob 4-Air distribution display managed automatically depending on The system can adjust and display the the chosen temperature: set temperature. To central & side vents - Air volume; To adjust or display the set temperature, - Cabin temperature;...
Page 108
AUTOMATIC A/C* 7-Defrosting/defogging front 9-Internal & external air circulation The air volume is displayed by filling the windshield & front side windows display vertical bar gradually; When the function comes to work, the When maintaining other adjustments, The maximum air volume is displayed defrosting/defogging symbol will appear closing the external air intake can isolate on the display:...
STORAGE DEVICE Glove box Central glove box Hold the handle and pull the cover Open the central glove box cover from backwards to open the glove box; and front to rear, and then the lower glove box push the cover forwards to close it. is visible.
INTERIOR LIGHTING & TRUNK LIGHTING Interior front & rear roof lamps Trunk lamp & are the switches of left/right Operation of the interior front & rear roof The trunk lamp will turn on automatically reading lamps, after either of them is lamps: when the trunk lid is opened, and pressed down, the corresponding roof...
SUN VISOR & GLASSES BOX* Sun visor Glasses box* The sun visor can also be turned to the side door for shielding the sun from the The left sun visor face has an interlayer The glasses box is on the left door frame side.
CIGAR LIGHTER, ASHTRAY* & HANDLE* Cigar lighter Removable ashtray* Handle* Cigar lighter is in the rear of transmission Open the cover to use it. The passenger seat door frame is provided shift lever. When it is required to empty it, pull it with a handle.
REAR SHELF Rear shelf (S30) Rear shelf (H30, H30 CROSS) The rear shelf behind the rear seats is The rear shelf behind the rear seats is stationary and only some light and soft removable. The rear part of the rear shelf items can be placed on it.
TRUNK Trunk (S30) Trunk (H30, H30 CROSS) The trunk bottom is flat and practical, The trunk capacity varies with the folding and after folding the rear seats, the trunk of the rear seats. will be connected for carrying larger After removing the rear shelf and folding luggage.
SUNROOF* Control panel Slide to open/close the sunroof Slide forwards for closing Slide backwards for opening Slide backwards to turn on/slantwise In case that the sunroof is opened, to turn off the control button. Briefly press down the button (less briefly press the button (less than Slide forwards to turn off/slantwise to...
Page 116
SUNROOF* Anti-pinch function If being held down by obstacles during closing, the sunroof will return to the completely open state immediately, afterwards, press down operate the sunroof again. anti-pinch function only applicable to the short press mode but not the press-hold mode. During high speed driving, the air resistance may cause that the sunroof Slantwise open/close the sunroof...
Page 117
SUNROOF* Auto-closing function The anti-pinch function is effective during Sunroof visor When the sunroof is at any opening automatic closing and the anti-pinch The opening/closing of the sunroof visor position, the sunroof glass panel will be function will comes into work for five times, can be controlled by pushing/pulling closed automatically 3 s after turning off that is, returning to the original position if...
Page 118
SUNROOF* Special note The sunroof can only be opened upon Do not put heads or hands out of the Do not open the sunroof when it is driving for 5 min at least after raining sunroof when driving. raining or vehicle is being cleaned. or vehicle cleaning (in order to dry stagnant water on the roof by air).
If the faults are still unsolved, please contact either Dongfeng Franchise Store or IKCO authorised representatives. WARNING Before opening the sunroof, please ensure that no obstacle on the roof affects the glass panel movement.
It is recommended to use fuel additives Please contact either Dongfeng verified by us, all of which can be bought Franchise Store or IKCO authorised either from Dongfeng Franchise Store or representatives for fluid purchase.
Page 123
The coolant have the cooling system checked at Capacity: 1.5L should be refilled or replaced at Dongfeng Dongfeng Franchise Store or IKCO Franchise Store or IKCO authorized When the engine is stopped, check the representatives.
Page 124
Dongfeng When the engine hood is opened for engine oil level with a dipstick. The fluid Franchise Store or IKCO authorised check, if the engine is hot, please be level should be between the upper limit representatives regularly.
Page 125
The coolant should be changed either Note: at Dongfeng Franchise Store or IKCO If the brake fluid level is lowered down obviously Note: authorised representatives. in a short time, the brake system may have leakage.
Dongfeng avoid color difference. Do not leave the Various solvents have more or less Franchise Store or IKCO authorised stains stuck on the interior surface for a corrosive effect on the interior synthetic representatives.
Page 127
INTERIOR MAINTENANCE Clear the interior (such as the interiors, plastic parts, seats etc.) dust and dirt frequently with a vacuum cleaner or duster, and wipe off the dirt on nylon or leather items with a piece of clean and soft cloth soaked in soft soap, and dry them with the soft cloth.
Dongfeng Franchise Store or should be used. IKCO authorised representatives. alcohol etc. Body cleaning Paint polishing It is recommended to perform paint To maintain a good painted surface, it is necessary to clean the body frequently...
Page 129
VEHICLE MAINTENANCE Asphalt & gasoline stains on bumper Typically, vehicle corrosion The anti-corrosion coating at the vehicle The stains should be cleared with resulted from the following two reasons: lower side should be checked and special cleaning agents. Moisture accumulated in the body repaired regularly.
FUEL-SAVING MEASURES Driving: Keep the appropriate engine speed: higher than 2,500r/min during normal driving and higher than 3,000r/ min during upshifting. Avoid the engine running at too low speed. The vehicle speed when driving should be stable to avoid frequently sudden braking. Make proper preparation for changes in traffic conditions in advance to avoid flat footed.
Page 132
FUEL-SAVING MEASURES Save fuel & reduce emission Adjust the engine Check the tyre pressure Fuel saving is not completely determined Check the main components of ignition Check it weekly, and the insufficient tyre by the vehicle design and its technical system and fuel supply system annually pressure will increase the wheel rolling characteristics, but also related to your...
For any malfunction or negative consequences caused by any electrical accessories which are not supplied by us or not installed either at Dongfeng Franchise Store or IKCO authorised representatives as required, and also for all losses resulting from hereto, our company will not be liable for...
FUSE Fuse box There is a fuse box at the lower left of instrument panel and in the engine compartment respectively. Fuse replacement Before replacing the fuse, find out the causes of faults and troubleshoot them correspondingly. Number of each fuse is marked on the fuse box, and the unnumbered fuse is for spare.
Page 135
FUSE Number of cabin fuse box Capacity Fuse functions Type Right front position lamp, left rear position lamp, left license plate lamp, right license plate lamp Mini Cab backlight Mini Left front position lamp, right rear position lamp Mini Combination instrument, diagnostic instrument, automatic transmission control module, anti-theft Mini controller, multi-function display, hazard warning lamp switch, radio &...
Page 136
FUSE Engine compartment fuse box The corresponding fuse instructions are The engine compartment fuse box is provided on the fuse box cover. beside the battery, open the fuse box Capacity Relay functions cover to access the fuse. Starter protection Micro After the operation, note to close the Starter Micro...
Page 137
FUSE Number of engine compartment fuse Capacity Fuse functions Type Left front high beam Mini Right front high beam Mini Left front low beam Mini Right front low beam Mini Mini Ignition coil Mini Engine Mini Horn/ignition switch Mini Mini Fuel pump Mini Engine...
BATTERY Battery: Battery inspection Battery removal Have it checked either at Dongfeng Franchise Store or IKCO authorised WARNING Remove the battery from the negative Never make the battery close to the fire or representatives regularly. electrode. sparks (avoiding explosion). Battery refitting...
START BY EMERGENCY BATTERY vehicles should not contact with Emergency battery each other. Breakdown vehicle battery Note: - Connect the battery wires in the Ground (metal) point of breakdown During the operation, do not touch specified order as shown above, vehicle the metal part of the clip.
Have the damaged left front high headlamp will appear a thin layer beam bulb replaced at Dongfeng Note: of water vapor in some application Franchise Store or IKCO authorized The lamp bulge should be aligned with conditions. representatives. lamp holder notch.
Page 141
Dongfeng Franchise Store or IKCO authorised representatives. avoid damaging headlamp...
Page 142
Remove the fender and pull out the recommended to have it replaced either plug, turn the fog lamp bulb base at Dongfeng Franchise Store or IKCO counterclockwise for about 45° to authorised representatives. remove it (with the base) for replacement of bulb and its base.
Page 143
Rear fog lamp (P21W) damaged, have them replaced at Rear fog lamp: P21W Turn the lamp holder (in orange) Dongfeng Franchise Store or IKCO Reversing lamp: W16W counterclockwise for 45° to remove authorized representatives. Open the trunk lid and two small trim...
Page 144
Turn the lamp holder counterclockwise replaced at Dongfeng Franchise Store for 45° to remove the lamp holder and for 45° to remove the lamp holder and or IKCO authorized representatives. bulb, press the bulb inward gently and bulb, press the bulb inward gently and...
Page 145
(LED) replaced at Dongfeng lamp assembly and dismantle the lamp the lampshade with a slotted screwdriver, Franchise Store or IKCO authorized holder plate to replace the bulb. Reinstall then remove bulb representatives.
Page 146
Front roof lamp: 5W, bulb length: 42mm; Bulb type: C5W, bulb length: 38mm. If the retro-reflector is damaged, it is Rear roof lamp: C5W, bulb length: recommended to have it replaced at 38mm. Dongfeng Franchise Store or IKCO authorized representatives.
TOWING Parallel towing (with four wheels of the Towing when the front or rear of the towed vehicle left on the ground) Towing vehicle is lifted Note: eye is provided at the front and rear of Use the special towing device made of When the vehicle equipped with the the vehicle.
WHEEL REPLACEMENT Spare tyre The driver’s tools of S30 model is placed Spare tyre There is a buckle on the carpet below in the spacer of spare tyre. Remove the Turn counterclockwise and remove the the trunk lock. Pull the buckle upwards tool spacer to expose the spare wheel.
Page 149
WHEEL REPLACEMENT Driver’s tool Remove the wheel the jack handle until the jack is loaded, 1. Park the vehicle on the level hard but the wheel should not be off the Warning triangle ground stably; hold the parking brake ground; Jack handle firmly to stop the engine, and shift the 4.
Page 150
Put back the wheel wrench and tool than 80km/h to the nearest Dongfeng Tighten the wheel bolts with wheel spacer. Franchise Store or IKCO authorized wrench diagonally. representatives for repair, after the Inflate the wheel enough, and check wheel acceptable for normal running is...
TYRE Tips: To ensure safety driving, it is very important to always keep tyres in good condition. Note that the tyre inflation pressure should always meet our recommendations and should be check regularly (for example once per week). Before long driving, perform systematic checks, and do not forget to check spare tyres! The tyre should be checked in cold, for the tyre...
Page 152
Dongfeng use limit, Replace the tyre immediately types, treads or with large condition Franchise Store or IKCO authorized when the wear limit is targeted. differences on the same axle (except representatives.
Note: condition and should be adjusted The engine will be stopped when wading, in the case, do not restart the engine properly and kept clean. forcibly but seek help from Dongfeng Franchise Store or IKCO authorized representatives.
Page 154
SAFETY TIPS Warning triangle (accessory) Unfold the warning triangle Ordinary highway Expressway When the vehicle cannot be driven off Unfold the 4 bottom brackets Distance 50-100m ≥150m the lane or is stopped on road shoulder Unfold the 2 folded edges because of failures, accidents etc., it is Fasten the snap , and put the side...
Page 155
In order to maintain good braking immediately to check, and contact performance, replace the brake fluid Dongfeng Franchise Store or IKCO regularly as specified in Warranty authorized representatives if necessary. Manual, and the brake fluid must be...
VEHICLE IDENTIFICATION Product label VIN plate VIN printing position It is in the right of engine compartment. It is in the right lower part of front VIN is printed on the front cross member windshield. of right front seat in cabin, and it is visible once the seat is moved to the rearmost position and the access hole in carpet is opened.
Page 161
VEHICLE IDENTIFI CATION Identifi cation positions Tyre pressure label (at lower part of Product label left front door frame) VIN plate Engine No.
Page 163
INDEX Interior Equipment 59 & 60 Adjusting Safety Belts Demisting Introducing Fueling System Adjusting The Steering Wheel Digital instrument Panel Placed In Trunk Lid Air Bag Dimensions Air Pressure Of The Tires Disconnection Of Battery Anti Pinch System Driving & Environment Locking &...
Page 164
INDEX remote control 16 & 17 Warning Lamps Rear Ash Tray Winter Precaution Rear shelf Recommendations For Washing The Vehicle Releasing Of The Lock For Steering Whee l 79 Safety Of The Road Safety Of The Vehicle Saving In Fuel Consumption Seat Belts Safety Tips Seats Starting and Driving...