Options; Tables Of Options - Carrier 30RBM 160 Installation, Operation And Maintenance Instructions

12 - OPTIONS

12.1 - Tables of options

Options No.
Medium-temperature brine 5B
solution
Low-temperature brine solution 6B
High Static fans 12
Low noise level 15
Very low noise level 15LS Acoustic compressor enclosure and low-speed fans
High ambient temperature 16
IP54 control box 20A
Grilles and enclosure panels 23
Enclosure panels 23A
Soft Starter 25
Winter operation 28
down to -20°C
Winter operation 28B
down to -10°C
Winter operation 28C
down to -10°C at low speed
Water exchanger frost protection 41
Exchanger & hydraulic frost 42A
protection
Partial heat recovery 49
Master/slave operation 58
Compressor suction and 92A
discharge valves
Compressor discharge valves 93A
Hydronic module 116R Single high-pressure water pump, water filter, electronic water flow
Single HP pump
Hydronic module 116S Dual high-pressure water pump, water filter, electronic water flow
Dual HP pump
Hydronic module 116T Single low-pressure water pump, water filter, electronic water flow
Single LP pump
Hydronic module 116U Dual low-pressure water pump, water filter, electronic water flow control,
Dual LP pump
HP evap. variable-speed 116V Single high-pressure water pump with variable speed drive (VSD), water
single pump.
HAP variable-speed 116W Dual high-pressure water pump with variable speed drive (VSD), water
dual pump.
Free Cooling Dx system 118A Patented Carrier free-cooling system with cooling micro-pump on
on 2 circuits
Free Cooling Dx system 118B Patented Carrier free-cooling system with cooling micro-pump on one
on 1 circuit
J-Bus gateway 148B Two-directional communication board complying with JBus protocol
Lon gateway 148D Two-directional communication board complying with Lon Talk
Bacnet over IP 149
Energy Management Module 156
Touch Pilot control, 5" user 158
interface
Compliance with Russian 199
regulations
Power factor correction 231
Enviro-Shield anti-corrosion 262
protection
Description
Low temperature chilled water production down to 0°C with ethylene
glycol and propylene glycol.
Low temperature chilled water production down to -15°C with
ethylene glycol and -12°C with propylene glycol.
Unit equipped with high static variable-speed fans (maximum 200
Pa), each fan equipped with a connection flange allowing the
connection to the ducting system.
Aesthetic and sound absorbing compressor enclosure
Unit equipped with electrical panel cooling fan
Increased leak tightness of the unit
Metal grilles on the 4 unit sides, plus side enclosure panels at each
end of the coil
Side enclosure panels at each end of the coil
Electronic starter on each compressor
Fan speed control of lead fan for each circuit using a variable
frequency drive
Two-speed lead fan for each circuit
Two Low speed fans on lead fan on each circuit
Electric heater on the water exchanger and the water piping
Electrical heaters on the water type heat exchanger, water pipes,
hydronic module and optional expansion
Unit equipped with one desuperheater on each refrigerant circuit
Unit equipped with an additional leaving water temperature sensor, to
be installed on site, enabling Master/Slave operation of 2 units
connected in parallel
Shut-off valves on the compressor suction and discharge piping
Shut-off valves on the compressor discharge piping
control, pressure transducers. For more details, refer to the dedicated
chapter (expansion tank not included.Option with built-in safety
hydraulic components available.)
control, pressure transducers. For more details, refer to the dedicated
chapter (expansion tank not included) Option with built-in safety
hydraulic components available)
control, pressure transducers. For more details, refer to the dedicated
chapter (expansion tank not included Option with built-in safety hydraulic
components available)
pressure transducers. For more details, refer to the dedicated chapter
(expansion tank not included Option with built-in safety hydraulic
components available)
filter, electronic water flow control, pressure transducers. Multiple
possibilities of water flow control. For more details, refer to the dedicated
chapter (expansion tank not included Option with built-in safety hydraulic
components available)
filter, electronic flow switch, pressure transducers. Multiple possibilities of
water flow control. For more details, refer to the dedicated chapter
(expansion tank not included Option with built-in safety hydraulic
components available)
both refrigerant circuits. Operation without glycol, no extra
free-cooling coil. See Dx Free-cooling option chapter
refrigerant circuit. Operation without glycol, no extra free-cooling coil.
See Dx Free-cooling option chapter
protocol
Two-directional high-speed communication using BACnet protocol
over Ethernet network (IP)
EMM Control board with additional inputs/outputs. See Energy
Management Module option chapter
Touch Pilot control supplied with a 5 inch colour touch screen user
interface
EAC certification
Capacitors for automatic regulation of power factor (cos phi) value to
0.95.
Coating which uses a conversion process to alter the aluminium surface
into a coating which forms an integral part of the coil. Complete
immersion in a bath to ensure 100% coverage. No heat transfer variation,
tested 4000 hours salt spray per ASTM B117
Advantages
Covers specific applications such as ice storage and industrial
processes
Covers specific applications such as ice storage and industrial
processes
Ducted fan discharge, optimised condensing (or evaporating on Heat
pump version) temperature control, based on the operating
conditions and system characteristics
Noise level reduction by 1 to 2 dB(A)
Noise level reduction by 6 to 7 dB(A)
Extended unit part-load operation up to 52°C ambient temperature
Protects the inside of the electrics box from dust, water and sand. In
general, this option is recommended for installations in polluted
environments
Improves aesthetics, protection against intrusion to the unit interior,
coil and piping protection against impacts.
Improves aesthetics, coil and piping protection against impacts.
Reduced start-up current
Stable unit operation for outside air temperature from 0°C down to
-20°C in cooling mode
Stable unit operation for outside air temperature down to -10°C
Reduces the noise level and enables stable unit operation for outside
air temperature down to -10°C
Water exchanger module frost protection between 0°C and -20°C
outside air temperature
Water exchanger and hydronic module frost protection down to -20°C
outside air temperature
Production of free high-temperature hot-water simultaneously with chilled
water production (or hot water for Heat pump)
Optimised operation of two units connected in parallel operation with
operating time equalisation
Simplified maintenance. Possibility to store the refrigerant charge in the
cooler or condenser side during servicing
Simplified maintenance. Possibility to store the refrigerant charge in
the condenser side during servicing
Easy and fast installation (plug & play)
Easy and fast installation (plug & play)
Easy and fast installation (plug & play)
Easy and fast installation (plug & play)
Easy and fast installation (plug & play),significant pumping energy
cost savings (more than two-thirds), tighter water flow control,
improved system reliability
Easy and fast installation (plug & play),significant pumping energy
cost savings (more than two-thirds), tighter water flow control,
improved system reliability
Energy savings for applications with cooling demand throughout the
entire year
Energy savings for applications with reduced demand for cooling in
the cold season (e.g. Office space with computer room, meeting
rooms...)
Connects the unit by communication bus to a building management
system
Connects the unit by communication bus to a building management
system
Easy and high-speed connection by Ethernet line to a BMS. Access
to multiple unit parameters
Extended remote control capabilities (Set-point reset, ice storage
end, demand limits, boiler on/off command...)
Control with advanced communication technology over Ethernet (IP),
user-friendly and intuitive user interface with 5" colour touch screen
Conformance with Russian regulations
Reduction of the apparent electrical power, compliance with
minimum power factor limit set by electricity suppliers
Improved corrosion resistance, recommended for use in moderately
corrosive environments
Use
30RBM/30RBP
160-520
30RBM/P 160-400
down to CW -15°C
30RBP160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM 160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM 160-520
30RBM 160-520
30RBM 160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
220-520
30RBM/30RBP
160-520 Except
size 360/400 on
30RBP
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
30RBM/30RBP
160-520
45