Table of Contents
Advertisement
Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Used to address practices not related to personal injury.
Installation Standard Work Checklist . . . . . . . . . . . . . . . . . . . . 3
1 Product Specific and Important Safety Information
A. Appliance Certification . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
B. Glass Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
C. Gas Pressure Requirements . . . . . . . . . . . . . . . . . . . . . . . 4
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . . 5
E. Non-Combustible Materials Specification. . . . . . . . . . . . . . 5
F. Combustible Materials Specification . . . . . . . . . . . . . . . . . 5
G. Electrical Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
2 Getting Started
A. Design and Installation Considerations . . . . . . . . . . . . . . . 6
B. Good Faith Wall Surface/TV Guidelines . . . . . . . . . . . . . . 6
C. Tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . . 6
D. Inspect Appliance and Components . . . . . . . . . . . . . . . . . . 7
3 Framing and Clearances
A. Appliance/Decorative Front Dimension Diagrams . . . . . . . 8
B. Clearances to Combustibles . . . . . . . . . . . . . . . . . . . . . . 10
C. Constructing the Appliance Chase . . . . . . . . . . . . . . . . . . 12
4 Termination Location and Vent Information
A. Vent Termination Minimum Clearances . . . . . . . . . . . . . . 13
B. Chimney Diagram. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
C. Approved Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
D. Use of Elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
E. Measuring Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
F. Vent Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
5 Vent Clearances and Framing
A. Pipe Clearances to Combustibles . . . . . . . . . . . . . . . . . . 27
B. Wall Penetration Framing/Firestops . . . . . . . . . . . . . . . . . 27
C. Ceiling Firestop/Floor Penetration Framing . . . . . . . . . . . 28
D. Install Attic Insulation Shield . . . . . . . . . . . . . . . . . . . . . . . 28
6 Appliance Preparation
A. Vent Collar Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . 29
B. Installing the Optional Heat-Zone
C. Securing and Leveling the Appliance . . . . . . . . . . . . . . . . 30
D. Non-Combustible Material Installation . . . . . . . . . . . . . . . 31
2
Table of Contents
-240V Kit . . . . . . . . . . 29
®
Heat & Glo • SLR-X-AU Installation Manual • 2493-980 Rev. B • 12/17
7 Venting and Chimneys
A . Assemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 32
B. Assemble Slip Sections . . . . . . . . . . . . . . . . . . . . . . . . . . 33
C. Secure the Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 33
D. Disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 34
E. Vertical Termination Requirements . . . . . . . . . . . . . . . . . . 35
F. Horizontal Termination Requirements . . . . . . . . . . . . . . . 36
8 Electrical Information
A. General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
B. Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
9 Gas Information
A. Fuel Conversion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
B. Gas Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
C. Gas Service Access . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
D. Gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
E. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . 42
F. Air Shutter Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
10 Finishing
A. Facing Materials . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
B. Non-Combustible Board and Drywall Installation . . . . . . . 44
C. Mantel and Wall Projections . . . . . . . . . . . . . . . . . . . . . . . 46
D. Decorative Front Finishing . . . . . . . . . . . . . . . . . . . . . . . . 48
11 Appliance Setup
A. Remove Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . 50
B. Remove the Shipping Materials . . . . . . . . . . . . . . . . . . . 50
C. Clean the Appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
D. Install the Refractory (Optional) . . . . . . . . . . . . . . . . . . . 50
E. Install Media Option . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
F. Install Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . . . 51
G. Install Fan Brackets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
H. Install Decorative Front . . . . . . . . . . . . . . . . . . . . . . . . . . 52
12 Reference Materials
A. Vent Components Diagrams . . . . . . . . . . . . . . . . . . . . . . 53
B. Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
= Contains updated information.
Advertisement
Table of Contents
