Electrical Equipment - SPX Votator II Instruction Manual

Waukesha Cherry-Burrell

Electrical Equipment

NO. OF
ITEM #
QTY
CYLINDERS
1 1
1 2 2
3 3
1 1
2 2 2
3 3
1 1
3 2 1
3 1
1 1
4 2 2
3 3
1 1
5 2 1
3 1
1 1
6 2 1
3 1
1 1
7 2 1
3 1
1 1
8 2 1
3 1
1 1
9 2 1
3 1
11/2012
The electrical components, if furnished by Waukesha Cherry-
Burrell, are loose and require installation by customer.The list
below is keyed to the suggested wiring diagrams on the following
pages and describe typical components used in analog control
panels.
If a Votator PLC Control Panel was purchased for the Votator II
unit, Item 3 below is furnished loose for inclusion in Buyer's high
voltage panel and Items 7 and 8 are not needed. The PLC panel
for Votator II refrigeration units duplicates the control operation
shown on the following pages; it serves as the operator station for
the Votator II line. See the pertinent manual pages for operating
instructions for the PLC panel.
Cylinder Drive Motor(s)
Motor Starters:
Customer responsible for correct sizing of starter, coil, and thermal
overload protection based on motor nameplate voltage, frequency,
FLA's, service factor, and horsepower.
Current sensing relay and plug-in base
set at motor nameplate FLA's
(R-K Electronics CJD-120A-5 or equal)
(Plug-in base = A-B 700-HN 125 or equal)
Cylinder Start/Stop push buttons
(Start = A-B 800H-AR1A or equal)
(Stop = A-B 800H-BR6D2 or equal)
3-Position selector switch Labeled:
"REFRIGERANT SYSTEM MODE" "DEFROST OFF ON"
Red, push to test, pilot light Labeled: "REFRIGERANT CONTROLS
ON" (A-B 800H-JR2A/800H-PRTH16R or equal)
2-Position selector switch Labeled:
"VOTATOR REFRIGERATION" "OFF ON"
Red, push to test, pilot light Labeled "VOTATOR REFRIGERATION
ON" (A-B 800H-HR2A/800H-PRTH16R or equal)
Digital current indicator
(1/8 DIN) 1.77" x 3.62" Panel Cutout
Labeled: "PERCENT FULL LOAD CURRENT"
(Red Lion APL-ID-400 or equal)
Instrument transformer
(Ohio Semitronics CTD-050A or equal)
Red, push to test, pilot light Labeled:
"DEFROST ON"
(A-B 800H-HR2A/800H-PRTH16R or equal)
95-03057
DESCRIPTION
Installation
FURNISHED BY
SPX Others
X
X
X
X
X
X
X
X
X
Page 19