Toro WORKMAN GTX 07131 Operator's Manual page 34

Note: Ensure that the charger-voltage setting matches
the voltage at the power outlet being used.
Note: In high-ambient temperature environments,
remove the seat assembly for optimal charging time;
refer to Removing the Seat Assembly (page
battery charger is too hot, it may not charge properly.
In cold temperatures, it may take a longer for the
batteries to charge.
Figure 36
1. Charger-status light
2. Charging receptacle
3. The battery is near empty.
4. Plug the charger power cord into the power outlet.
Note: While the batteries are charging, the green light
on the charger blinks on and off. When the batteries
are fully charged, the green light stops blinking and
stays on.
5. Disconnect the cord from the power outlet.
6. Disconnect the charger from the machine.
29). If the
4. The battery is almost
charged.
5. The battery is charged.
6. Charger fault; refer to the
charger manual for the
fault codes.
Refer to the following table and
the meanings of the varying colors of the charger-status light.
Charger-Status Light Table
Charger-Status
Light Color
Green Solid
Green Flashing
Amber Flashing
Red Flashing
Checking the Water Level of the
Batteries
Service Interval: Before each use or daily
1. Park the machine on a level surface, shut off the
machine, remove the key from the key switch, and
raise cargo box;
Position (page 19).
2. Remove the seat assembly to access the batteries; refer
to Removing the Seat Assembly (page
3. Check the eyelets on each of the batteries to see if they
are either black or white
Note: Black eyelets indicate that the batteries are full
of water. White eyelets indicate that water is needed
for the batteries.
1. Battery eyelet
34
Figure 36 for information on
Solid/Flashing Meaning
Charging complete
Short flash—less
than 80% charge
Long
flash—greater than
80% charge
Reduced-power
mode—low AC
voltage or high
internal charger
temperature;
charge immediately
Charger
error—reset the
charger power
If this error persists,
refer to the blink
codes in the
charger manual
Raising the Cargo Box to the Service
29).
(Figure 37).
Figure 37