Jeep cherokee 2000 Service Manual page 1513

XJ
Description Group-Page
ABS BRAKE SYSTEM, BLEEDING . . . . . . . . . 5-36
ABS WARNING LAMP . . . . . . . . . . . . . . . . . . 5-35
ABSOLUTE PRESSURE (MAP) SENSOR,
MANIFOLD . . . . . . . . . . . . . . . . . . . . . . . . . . 14-46
ABSOLUTE PRESSURE (MAP)
SENSOR—PCM INPUT, MANIFOLD . . . . . . . 14-32
ABSORBER, SHOCK . . . . . . . . . . . . . . . . 2-17,2-9
ABSORBERS, SHOCK . . . . . . . . . . . . . . . 2-16,2-7
A/C APPLICATION TABLE . . . . . . . . . . . . . . . 24-47
A/C PERFORMANCE . . . . . . . . . . . . . . . . . . . 24-9
ACCELERATOR PEDAL . . . . . . . . . . . . . . . . . 14-21
ACCESSORY DRIVE BELT DIAGNOSIS
ACCESSORY DRIVE BELTS, ENGINE
ACCESSORY SWITCH BEZEL,
INSTRUMENT PANEL . . . . . . . . . . . . . . . . . . 8E-15
ACCUMULATOR; HEATING AND AIR
CONDITIONING . . . . . . . . . . . . . . . . . . 24-2,24-25
ACCUMULATOR; TRANSMISSION AND
TRANSFER CASE . . . . . . . . . . . . . . . . . . . . 21-117
ACCUMULATOR PISTONS AND SPRINGS
ACTUATION TEST MODE, CIRCUIT
ACTUATOR, FRONT DOOR INSIDE
HANDLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-37
ACTUATOR, MODE DOOR VACUUM
ACTUATOR, REAR DOOR INSIDE
HANDLE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-45
ADAPTER HOUSING . . . . . . . . . . . . . . . . . 21-147
ADAPTER HOUSING SEAL . . . . . . . . . 21-252,21-7
ADAPTER SEAL, SOLENOID HARNESS . . . . 21-261
ADAPTER, SPEEDOMETER . . . . . . 21-148,21-253
ADAPTER/EXTENSION HOUSING AND
FRONT BEARING RETAINER . . . . . . . . . . . . . 21-8
ADDITIONAL, COOLANT—ADDING
ADHESIVE LOCATIONS, STRUCTURAL
ADJUSTER AND MOTORS, POWER
SEAT . . . . . . . . . . . . . . . . . . . . . . 8R-1,8R-2,8R-3
ADJUSTMENT, BRAKE TRANSMISSION
SHIFT INTERLOCK CABLE . . . . . . . 21-198,21-336
ADJUSTMENT, COMPASS VARIATION . . . . . . 8V-4
ADJUSTMENT, DOOR LATCH . . . . . . . . . . . . 23-66
ADJUSTMENT, FOG LAMP . . . . . . . . . . . . . . . 8L-8
ADJUSTMENT, FRONT BAND . . . . . . . . . . . 21-199
ADJUSTMENT, HEADLAMP . . . . . . . . . . . . . . 8L-6
ADJUSTMENT, PRELIMINARY
INSPECTION . . . . . . . . . . . . . . . . . . . . . . . 21-241
ADJUSTMENT, REAR BAND . . . . . . . . . . . . 21-200
ADJUSTMENT, SHIFT LINKAGE . . . 21-372,21-405
ADJUSTMENT, TRANSMISSION
THROTTLE VALVE CABLE . . . . . . . 21-198,21-337
AERATION, COOLANT—LOW LEVEL
AFTER OVERHAUL OR FLUID/FILTER
CHANGE, REFILLING . . . . . . . . . . . . . . . . . 21-248
AFTERMARKET PAINT REPAIR
PRODUCTS . . . . . . . . . . . . . . . . . . . . . . . . . . 23-5
AIR CLEANER ELEMENT (FILTER) . . . . . . . . 14-49
AIR CONDITIONER CONTROL, HEATER . . . . . 24-6
AIR CONDITIONER, HEATER . . . . . . . . . . . . . 24-5
AIR CONDITIONING-HEATER, 8W-42
AIR CONTROL (IAC) MOTOR, IDLE . . . . . . . 14-45
AIR CONTROL (IAC) MOTOR—PCM
OUTPUT, IDLE . . . . . . . . . . . . . . . . . . . . . . . 14-35
AIR EXHAUST GRILLE . . . . . . . . . . . . . . . . . 23-50
AIR FLOW CHECK PROCEDURE,
THROTTLE BODY MINIMUM . . . . . . . . . . . . 14-42
AIR TEMPERATURE SENSOR, INTAKE
MANIFOLD . . . . . . . . . . . . . . . . . . . . . . . . . . 14-50
AIR TEMPERATURE SENSOR—PCM
INPUT, INTAKE MANIFOLD . . . . . . . . . . . . . 14-32
AIR TESTING TRANSMISSION CLUTCH
AND BAND OPERATION . . . . . . . . . . . . . . . 21-131
AIRBAG CONTROL MODULE . . . . . . . 8M-12,8M-3
AIRBAG DOOR, PASSENGER SIDE . . . . . . . 8M-11
AIRBAG MODULE, DRIVER SIDE . . . . 8M-2,8M-6
AIRBAG MODULE, PASSENGER SIDE
AIRBAG MODULE TRIM COVER, DRIVER
SIDE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8M-7
AIRBAG SYSTEM . . . . . . . . . . . . 8M-1,8M-4,8M-5
AIRBAG SYSTEM, 8W-43 . . . . . . . . . . . . . . . 8W-1
ALIGNMENT . . . . . . . . . . . . . . . . . . . . . . . 2-1,2-6
ALIGNMENT, HEADLAMP . . . . . . . . . . . 8L-6,8L-9
ALIGNMENT SCREEN PREPARATION,
LAMP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8L-6
ALIGNMENT, VEHICLE PREPARATION
FOR HEADLAMP . . . . . . . . . . . . . . . . . . . . . . 8L-6
ALIGNMENT, WHEEL . . . . . . . . . . . . . . . . . 2-1,2-4
ALUMINUM THREAD REPAIR
. . . . 21-144,21-249
AMBIENT TEMPERATURE SENSOR . . . . . . . . 8V-8
AMPERAGE TEST, FUEL PUMP . . . . . . . . . . . 14-8
Description
AMPLIFIER . . . . . . . . . . . . . . . . . . . . . . . . . . . 8F-7
ANALYSIS, GEAR CONTACT PATTERN
ANALYSIS, PRESSURE TEST . . . . . . . . . . . 21-242
ANALYSIS, TIME LAG TEST . . . . . . . . . . . . 21-243
ANALYZING ROAD TEST
ANGLE, FRONT AXLE PINION INPUT
ANGLE MEASUREMENT PREPARATION,
DRIVELINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-6
ANGLE MEASUREMENT, PROPELLER
SHAFT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-6
. . . . . . 7-9 ANGLE, PROPELLER SHAFT JOINT . . . . . . . . . 3-3
. . . . . . . 7-35 ANGLE, REAR AXLE PINION INPUT
ANTENNA . . . . . . . . . . . . . . . . . . . 8F-10,8F-2,8F-5
ANTILOCK BRAKE, HYDRAULIC
CONTROL UNIT/CONTROLLER . . . . . . . . . . . 5-39
ANTILOCK BRAKE SYSTEM . . . . . . . . . . . . . . 5-33
ANTILOCK BRAKES
ANTI-LOCK BRAKES, 8W-35
. 21-264 ANTILOCK BRAKES, CONTROLLER
. . . . . . . . 25-2 ANTILOCK BRAKES, HYDRAULIC
CONTROL UNIT/CONTROLLER . . . . . . . . . . . 5-36
A-PILLAR COWL TRIM, LOWER
. . . . . . 24-43 A-PILLAR TRIM . . . . . . . . . . . . . . . . . . . . . . 23-51
APPLICATION, BULB
APPLICATION TABLE, A/C
APPLIQUE, QUARTER WINDOW
ARM AND BLADE, WIPER . . . . . . . . . . . . . . . . 8K-2
ARM, LOWER SUSPENSION
ARM, PITMAN . . . . . . . . . . . . . . . . . . . . . . . 19-24
ARM, ROCKER
ARM, UPPER SUSPENSION
. . . . . . . . 7-21 ARM, WIPER . . . . . . . . . . . . . . . . . . . . . . . . . 8K-8
. . . 23-124 ARMS AND BUSHINGS, LOWER
SUSPENSION . . . . . . . . . . . . . . . . . . . . . . . . . . 2-8
ARMS AND BUSHINGS, UPPER
SUSPENSION . . . . . . . . . . . . . . . . . . . . . . . . . . 2-8
ARMS AND PUSH RODS, ROCKER
ASD AND FUEL PUMP RELAYS . . . . . . . . . . 14-41
ASSEMBLY, DRIVE AXLE
ASSEMBLY, ENGINE . . . . . . . . . . . . . . . . . . . . 9-92
ASSEMBLY, FINAL
ASSEMBLY, INSTRUMENT PANEL
ASSEMBLY (SHORT BLOCK), SERVICE
ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . 9-27,9-88
ASSEMBLY, TUBE AXLE . . . . . . . . . . . . . . . . . 3-23
ASSIST HANDLE
AUDIO SYSTEM . . . . . . . . . . . . . . . . . . . 8F-1,8F-2
. . . . . . . 7-21 AUDIO SYSTEM, 8W-47 . . . . . . . . . . . . . . . . 8W-1
AUDIO SYSTEMS . . . . . . . . . . . . . . . . . . . . . 8F-12
AUGAT CONNECTORS, TERMINAL/
CONNECTOR REPAIR- . . . . . . . . . . . . . . . . 8W-11
AUTO SHUTDOWN (ASD) RELAY—PCM
OUTPUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-34
AUTOMATIC SHUTDOWN (ASD) RELAY
AUTOMATIC SHUTDOWN (ASD) RELAY
. . . . . . 8W-1 SENSE—PCM INPUT . . . . . . . . . . . . . . . . . . 14-29
AUTOMATIC TRANSMISSION, 30RH
AUTOMATIC TRANSMISSION, AW-4
AUTOMATIC TRANSMISSION, AW–4 . . . . . 21-218
AUTOMATIC TRANSMISSION, AW–4
AUTOMATIC TRANSMISSIONAW–4 . . . . . . 21-217
AUTOMATIC TRANSMISSION DIAGNOSIS . 21-126
AUTOMATIC TRANSMISSION OIL
COOLER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-2
AUTOMATIC TRANSMISSIONAW–4
AUTOMATIC TRANSMISSION, AW–4 . . . . . 21-217
AUTOMATIC TRANSMISSION—
30RHAUTOMATIC TRANSMISSION—
30RH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21-88
AW-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21-344
. 8M-3,8M-9 AW-4 AUTOMATIC TRANSMISSION . . . . . . 21-338
AW–4 AUTOMATIC TRANSMISSION
AW–4 AUTOMATIC TRANSMISSIONAW–4
AUTOMATIC TRANSMISSION . . . . . . . . . . 21-217
AX5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21-40
AX5 MANUAL TRANSMISSION
AX5 MANUAL TRANSMISSION
COMPONENTS . . . . . . . . . . . . . . . . . . . . . . . 21-37
AXLE, 181 AND 186 FBI
AXLE, 181 FBI . . . . . . . . . . . . . . . . . . . . 3-16,3-61
AXLE, 186 FBI
. . . . . . . . . . . . . . . . . . . . 3-17,3-61
AXLE, 194 RBI
AXLE, 8 1/4
. . . . . . . . . . . . . . . . . . . . 3-103,3-125
AXLE, 8 1/4 INCH
AXLE, 8 1/4 REAR . . . . . . . . . . . . . . . . . . . . 3-103
Group-Page
. . . . 3-129,
3-59,3-97
. . . . . . . . . . . . . . 21-129
. . . . . . 3-15
. . . . . . . 3-15
. . . . . . . . . . . . . . . . 5-33,5-36
. . . . . . . . . . . . 8W-1
. . . . . . . . 5-33
. . . . . . . . . 23-51
. . . . . . . . . . . . . . . . . . 8L-20
. . . . . . . . . . . . . . 24-47
. . . . . . . . . 23-49
. . . . . . . . . . . . . 2-10
. . . . . . . . . . . . . . . . . . . . 9-6,9-66
. . . . . . . . . . . . . 2-11
. . 9-113,9-36,
9-53,9-96
. . . . . . . . . . . . . . . . 3-22
. . . . . . . . . . . . . . . . . 3-47,3-85
. . . . . . . . 8E-26
. . . . . . . . . . . . . . . . . . . . . 23-52
. . . 14-43
. . . . 21-212,
21-89
. . . . . 21-338
. . . . . 21-218
. . . . . . . . . . . 21-1
. . . . . . . . . . . . . . . . 3-61
. . . . . . . . . . . . . . . . . . . 3-65,3-99
. . . . . . . . . . . . . . . . . . . . 3-131
INDEX
Description Group-Page
AXLE ASSEMBLY, DRIVE . . . . . . . . . . . . . . . . 3-22
AXLE ASSEMBLY, TUBE . . . . . . . . . . . . . . . . . 3-23
AXLE BUSHING, FRONT . . . . . . . . . . . . . . . . 2-11
AXLE BUSHING REPLACEMENT . . . . . . . . . . 3-33
AXLE COMPONENTS . . . . . . . . . . . . . . . 3-47,3-91
AXLE PINION GEAR DEPTH, 8 1/4
AXLE PINION INPUT ANGLE, FRONT
AXLE PINION INPUT ANGLE, REAR
AXLE, REAR . . . . . . . . . . . . . . . . . . . . 3-111,3-72
AXLE SEAL AND BEARING . . . . . . . . . . . . . 3-112
AXLE SHAFT . . . . . . . . . . . . . . . . . . . . 3-111,3-76
AXLE SHAFT, HUB BEARING . . . . . . . . . . . . . 3-30
AXLE SHAFT OIL SEAL . . . . . . . . . . . . . . . . . 3-36
AXLE SHAFT SEAL AND BEARING
AXLE SHAFT—CARDAN U-JOINT . . . . . . . . . 3-23
AXLE, TUBE, 181, AND 186 FBI . . . . . . . . . . 3-16
AXLES, 8 1/4 . . . . . . . . . . . . . . . . . . . . . . . . 3-131
BACKLASH, 181 FBI DIFFERENTIAL
BEARING PRELOAD AND GEAR . . . . . . . . . . 3-52
BACKLASH, 186 FBI DIFFERENTIAL
BEARING PRELOAD AND GEAR . . . . . . . . . . 3-56
BACKLASH, DIFFERENTIAL BEARING
PRELOAD AND GEAR . . . . . . . . . . . . . 3-127,3-94
BACK-UP/BRAKE/REAR TURN SIGNAL/
TAIL LAMP . . . . . . . . . . . . . . . . . . . . . . . . . 8L-16
BACK-UP/BRAKE/REAR TURN SIGNAL/
TAIL LAMP BULB . . . . . . . . . . . . . . . . . . . . 8L-11
BALANCE, TIRE AND WHEEL . . . . . . . . . . . . . . 22-9
BALL STUD, LIFTGATE SUPPORT ROD . . . . 23-63
BALL STUDS, STEERING KNUCKLE
BAND ADJUSTMENT, FRONT . . . . . . . . . . . 21-199
BAND ADJUSTMENT, REAR . . . . . . . . . . . . 21-200
BAND OPERATION, AIR TESTING
TRANSMISSION CLUTCH . . . . . . . . . . . . . 21-131
BANDS . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21-123
BAR, STABILIZER . . . . . . . . . . 2-12,2-16,2-17,2-9
BAR, TRACK . . . . . . . . . . . . . . . . . . . . . . 2-12,2-9
BASE BRAKE BLEEDING . . . . . . . . . . . . . . . . 5-13
BASE BRAKE SYSTEM . . . . . . . . . . . . . . . 5-1,5-7
BASE BRAKES . . . . . . . . . . . . . . . . . . . . . . . . 5-32
BASE COAT/CLEAR COAT FINISH . . . . . . . . . 23-4
BATTERY . . . . . . . . 8A-1,8A-21,8A-23,8A-24,8A-5
BATTERY CABLES . . . . . . . . . . . 8A-14,8A-18,8A-3
BATTERY CHARGING . . . . . . . . . . . . . . . . . . 8A-16
BATTERY HOLD DOWNS . . . . . . . . . . . 8A-20,8A-4
BATTERY REPLACEMENT, REMOTE
KEYLESS ENTRY TRANSMITTER . . . . . . . . . 8P-6
BATTERY TEMPERATURE SENSOR . . . . 8C-2,8C-5
BATTERY THERMOGUARD . . . . . . . . . 8A-22,8A-5
BATTERY TRAY . . . . . . . . . . . . . . . . . . 8A-22,8A-5
BATTERY VOLTAGE—PCM INPUT . . . . . . . . 14-29
BEARING AND AXLE SHAFT, HUB . . . . . . . . . 3-30
BEARING, AXLE SEAL . . . . . . . . . . . . . . . . . 3-112
BEARING, AXLE SHAFT SEAL . . . . . . . . . . . . 3-77
BEARING, CLUTCH RELEASE . . . . . . . . . . . . . 6-3
BEARING, HUB . . . . . . . . . . . . . . . . . . . . . . . 2-12
BEARING NOISE . . . . . . . . . . . . . 3-109,3-21,3-70
BEARING, OUTPUT SHAFT REAR . . . . . . . 21-153
BEARING, PILOT . . . . . . . . . . . . . . . . . . . . . . 6-12
BEARING PRELOAD AND GEAR
BACKLASH, 181 FBI DIFFERENTIAL . . . . . . . 3-52
BEARING PRELOAD AND GEAR
BACKLASH, 186 FBI DIFFERENTIAL . . . . . . . 3-56
BEARING PRELOAD AND GEAR
BACKLASH, DIFFERENTIAL . . . . . . . . . 3-127,3-94
BEARING, RELEASE . . . . . . . . . . . . . . . . . . . . 6-12
BEARING RETAINER, ADAPTER/
EXTENSION HOUSING AND FRONT . . . . . . . . 21-8
BEARING RETAINER SEAL, FRONT
BEARINGS, CAMSHAFT . . . . . . . . . . . . 9-104,9-47
BEARINGS, CRANKSHAFT MAIN . . . . . 9-105,9-47
BEARINGS, DIFFERENTIAL SIDE . 3-115,3-36,3-80
BEARINGS, FITTING CONNECTING ROD
BEARINGS, FITTING CRANKSHAFT MAIN
BEARINGS—FITTING, CONNECTING ROD . . . 9-21
BELT DIAGNOSIS, ACCESSORY DRIVE
BELT SWITCH, DRIVER SEAT . . . . . . . . . . . . 8U-2
BELT TENSION . . . . . . . . . . . . . . . . . . . . . . . . 7-40
BELT WEATHERSTRIP, FRONT DOOR
INNER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-37
BELT WEATHERSTRIP, FRONT DOOR
OUTER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-38
BELT WEATHERSTRIP, REAR DOOR
INNER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-45
BELT WEATHERSTRIP, REAR DOOR
OUTER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-45
BELT/BUCKLE, FRONT SHOULDER
1
. . . . . . . 3-126
. . . . . . 3-15
. . . . . . . 3-15
. . . . . . . . 3-77
. . . . . . . 3-31
. . . . . . . . 21-6
. . . . 9-80
. . 9-23,
9-83
. . . . . . 7-9
. . . . . . . 23-55