Gearbox Oil; Engine Coolant - BOMBARDIER outlander 800 Operator's Manual

Repeat the above procedures until
oil level reaches the dipstick's upper
mark. Do not overfill.
Properly tighten dipstick.

Gearbox Oil

Recommended Oil
Use XP-S synthetic chaincase oil
(P/N 413 803 300) or an equivalent.
CAUTION: Do not use unrecom-
mended other types of oil when
servicing. Do not mix with other
types of oil.
Gearbox Oil Level
CAUTION: Check level and refill if
necessary. Do not overfill. Oper-
ating the gearbox with an improp-
er level may severely damage gear-
box. Wipe off any spillage.
Place the vehicle on a level surface.
Select NEUTRAL position then apply
parking brake.
Check the gearbox oil level by remov-
ing the gearbox oil level plug.
vmo2006-007-018_a
1. Oil level plug
2. Oil drain plug
The oil should be level with the bottom
of the oil level hole. Refill as required
until gearbox oil level flows through oil
level hole.
To change gearbox oil, refer to MAIN-
TENANCE section.
______________________
82

Engine Coolant

Recommended Coolant
Always use ethylene-glycol antifreeze
containing corrosion inhibitors specifi-
cally for internal combustion aluminum
engines.
Cooling system
with Bombardier premixed coolant
(P/N 219 700 362) or with distilled
water and antifreeze solution (50%
distilled water, 50% antifreeze).
Coolant Level
WARNING
Check coolant level with engine
cold. Never add coolant in cool-
ing system when engine is hot.
Remove front access panel.
vmo2006-007-016_a
With vehicle on a level surface, liquid
should be between MIN. and MAX.
level marks of coolant reservoir.
NOTE: When checking level at tem-
perature lower than 20°C (68°F), it
may be slightly lower than MIN. mark.
must be filled