Service Schedule; All Sx Models - KTM 125 SX Owner's Manual
Hide thumbs
Also See for 125 SX:
- Owner's manual (135 pages) ,
- Owner's handbook manual (45 pages) ,
- Owner's manual (46 pages)
Table of Contents
Advertisement
9
SERVICE SCHEDULE
9.1
All SX models
9.1.1
Service schedule
Change the gear oil.
(All 125/150 models)
Change the gear oil.
(250 SX)
Check the front brake linings. (
Check the rear brake linings. (
Check the brake discs. (
Check the brake lines for damage and leakage.
Check the rear brake fluid level. (
Check the free travel of the foot brake lever. (
Check the frame and swingarm.
Check the swingarm bearing.
Check the shock absorber linkage.
Check the tire condition. (
Check the tire air pressure. (
Check the wheel bearing for play.
Check the wheel hubs.
Check the rim run-out.
Check the spoke tension. (
Check the chain, rear sprocket, engine sprocket, and chain guide. (
Check the chain tension. (
Grease all moving parts (e.g., hand lever, chain, ...) and check for smooth operation.
Check/rectify the fluid level of the hydraulic clutch. (
Check the front brake fluid level. (
Check the free travel of the hand brake lever. (
Check the play of the steering head bearing. (
Change the piston and check the cylinder and Z dimension.
Change the piston and check the cylinder.
Change the piston and check the cylinder and Z dimension. (under difficult operating conditions)
els)
Change the piston and check the cylinder. (under difficult operating conditions)
Change the spark plug and spark plug connector.
Change the spark plug and spark plug connector.
Check the inlet membrane.
Check the exhaust control for functioning and smooth operation.
Check the clutch.
Check all hoses (e.g. fuel, cooling, bleeder, drainage, etc.) and sleeves for cracking, leaks, and incorrect routing.
Check the antifreeze and coolant level. (
Check the cables for damage and routing without sharp bends.
Check that the throttle cables are undamaged, routed without sharp bends, and set correctly.
Clean the air filter and air filter box.
Change glass fiber yarn filling in the main silencer.
Check the screws and nuts for tightness.
Check idle.
Final check: Check the vehicle for safe operation and take a test ride.
Make the service entry in the KTM Dealer.net and in the Service and Warranty Booklet.
●
Periodic interval
p. 77)
p. 82)
p. 75)
p. 80)
p. 79)
p. 86)
p. 87)
p. 87)
p. 67)
p. 76)
p. 75)
p. 50)
(250 SX)
(All 125/150 models)
(250 SX)
p. 93)
(
p. 59)
(
p. 68)
p. 73)
(All 125/150 models)
(250 SX)
p. 62)
Every 20 operating hours
Every 10 operating hours/after every race
(All 125/150 mod-
27
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
●
Advertisement
Table of Contents
