Fireplace Insert Components - kozy heat CHASKA-XL CSK-335 Installation & Operating Manual

FIREPLACE COMPONENTS:
Check the assembly diagram below to ensure you have all the necessary components to properly install
this fireplace insert.
This insert includes the following:
1. Fireplace insert.
2. Spring-loaded latch glass assembly.
3. Millivolt board with burner cover.
Model CSK-335 includes 150 CFM fan with limit switch and speed control.
Model CSK-335-RF includes modulating valve on millivolt board, fan kit and remote control.
WARNING:
Additional components which are necessary for proper installation are:
1. Vent System: Part #816-CL: For use with minimum 6" x 8" I.D. masonry or 7" I.D. Class 'A' metal
chimneys - Includes 12 ft. compressed, expandable to 35 ft. co-linear 3" x 3" flexible
chimney, and termination cap.
This insert is also approved for use with Dura-Vent, Ameri-Vent, & Selkirk Metalbestos 3" x 3" Co-linear vent
systems. Refer to the instructions accompanying the vent system as well as the venting requirements and
instructions in this manual.
2. Shroud - 3 pc & 4 pc.: Standard shrouds are available for this insert and will fit most applications. Custom
shrouds may be ordered on a non-returnable basis. When ordering a custom shroud, please specify the
existing fireplace front opening height and width. An upper hood and lower grill are included.
3. Blank Shrouds - 3 & 4 pc. blank shrouds are available for on-site custom fit applications and are sized to the
opening after the insert has been installed. The interior perimeter is properly sized to fit onto the insert. The
outer perimeter must be cut, formed and finished (painted). An upper hood and lower grill are included.
4. Full door shrouds: Full door decorative shrouds are available for this insert and are used in place of a standard
or blank shroud.
4. Co-linear air duct
5. Log set (See page #16)
6. Refractory Panels
2
3
Failure to position the parts in accordance with the diagrams in this
installation manual or failure to use only parts specifically approved for this
appliance may result in property damage or personal injury.
6
Page 3
4
1