Daily Inspection - TOHATSU M 2.5A2 Owner's Manual

ENOM01305-0

1. Daily Inspection

Perform the following checks before and
after use.
Item
• Check the amount of fuel in the tank.
Fuel System • Check for debris in the fuel filters.
• Check the rubber hoses for fuel leakage.
• Check for crack, leakage, damage in the fuel tank cap.
Fuel Tank Cap • Check for crack, damage in the gasket and tether.
• Check for leakage at full close.
• Check that the stop switch functions normally and make sure
the lock plate is in right location.
Electrical
Equipment
• Check cords for loose connections and damage.
• Check the spark plug for dirt, wear and carbon build-up.
• Check that the carburetor choke valve functions normally.
Throttle Sys-
• Check carburetor linkage is working normally when moving the
tem
throttle lever.
• Check the rope for wear and chafing.
Recoil Starter
• Check the ratchet engagement.
• Check that the clutch engages correctly when operation the shift
lever. (3.5B only)
Clutch and
Propeller Sys- • Visually check the propeller and shear pin for bent or damaged
tem
blades.
• Check that the split pin is on the propeller.
• Check the clamp screws attaching the motor to the boat for
Installation of
tightness.
Motor
• Check the thrust rod installation.
• Check that cooling water is discharged from the cooling water
Cooling Water
check port after the engine has started.
• Check that there are tools and spare parts for replacing spark
Tools and
plugs, the propeller, etc.
Spares
• Check that you have the spare rope.
• Check if the anode is securely installed.
Other parts
• Check the anode for corrosion and deformation.
*1 Have this handled by your dealer.
INSPECTION AND MAINTENANCE
ENOW00078-0
Do not use outboard motor if any abnor-
mality is found during pre-operation check
or it could result in severe damage to the
motor or severe personal injury.
Points to Check
WARNING
Remedy
Replenish
Clean or Replace
Replace *1
Replace
Replace
Replace
Remedy or replace *1
Correct or replace *1
Clean or replace *1
Replace *1
Correct *1
Replace *1
Correct or replace *1
Adjust *1
Replace
Tighten
Tighten
Repair *1
Repair if necessary
Replace
41
10