Checking The Injectors; Checking The Throttle Bodies; Checking The Fuel Pressure; Adjusting The Throttle Position Sensor - Yamaha XVS1300A 2007 Service Manual

Manuals by Motomatrix / www.motomatrix.co.uk / The Solution For Lost Motorcycle Coded Keys
EAS26980

CHECKING THE INJECTORS

1. Check:
• Injectors
Damage → Replace.
EAS26990

CHECKING THE THROTTLE BODIES

1. Check:
• Throttle bodies
Cracks/damage → Replace the throttle bod-
ies as a set.
2. Check:
• Fuel passages
Obstructions → Clean.
M MMM M MMM M M MMM M
a. Wash the throttle bodies in a petroleum-
based solvent.
Do not use any caustic carburetor cleaning
solution.
b. Blow out all of the passages with compressed
air.
L LLL L LLL L L LLL L
EAS3D81005

CHECKING THE FUEL PRESSURE

1. Check:
• Fuel pressure
M MMM M MMM M M MMM M
a. Remove the sub-fuel tank cover.
Refer to "GENERAL CHASSIS" on page 4-1.
b. Disconnect the fuel hose "1" from the fuel
pump.
EWA3D81001
WARNING
Cover fuel hose connections with a cloth
when disconnecting them. Residual pres-
sure in the fuel lines could cause fuel to
spurt out when removing the hoses.
c. Connect the fuel pressure adapter "3" be-
tween the fuel hose "1" and fuel pump "2".
d. Connect the pressure gauge "4" to the fuel
pressure adapter "3".
email: info@motomatrix.co.uk
M MMM M M MMM M M MMM M MMM
L LLL L L LLL L L LLL L LLL
M MMM M M MMM M M MMM M MMM
1
THROTTLE BODIES
Pressure gauge
90890-03153
YU-03153
Fuel pressure adapter
90890-03176
YM-03176
2
3
e. Start the engine.
f. Measure the fuel pressure.
Fuel pressure
324 kPa (46.1 psi) (3.24 kg/cm²)
Faulty → Replace the fuel pump.
L LLL L LLL L L LLL L
EAS27030
ADJUSTING THE THROTTLE POSITION
SENSOR
NOTE:
Before adjusting the throttle position sensor, the
engine idling speed should be properly adjusted.
1. Check:
• Throttle position sensor
Refer to "CHECKING THE THROTTLE PO-
SITION SENSOR" on page 8-101.
2. Adjust:
• Throttle position sensor angle
M MMM M MMM M M MMM M
a. Connect the throttle position sensor coupler
to the throttle position sensor.
b. Connect the digital circuit tester to the throttle
position sensor.
• Positive tester probe →
yellow "1"
• Negative tester probe →
black/blue "2"
Digital circuit tester
90890-03174
Model 88 Multimeter with ta-
chometer
YU-A1927
7-9
1
4
L LLL L L LLL L L LLL L LLL
M MMM M M MMM M M MMM M MMM