Related Manuals for Yunca Gas EROS
Summary of Contents for Yunca Gas EROS
-
Page 1: Warranty Information
FREESTANDING GAS HEATER July 2001 OPERATIONS, MAINTENANCE & WARRANTY INFORMATION 25-07-01 Page 1 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc... -
Page 2: Table Of Contents
FAULT FINDING GUIDE Appendix A GAS TYPE CONVERSION Appendix B PARTS LIST Appendix C INJECTOR SIZES Appendix D WARRANTY, WIRING DIAGRAM Appendix E WARRANTY REGISTRATION 25-07-01 Page 2 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc... -
Page 3: Introduction
Control valve compartments, burners, fan, and air circulating passageways of the EROS must be kept free from any lint and dust build-up to ensure efficient and safe operation of the heater. -
Page 4: Installation
INSTALLATION Considerations The most desirable and beneficial location for a YUNCA EROS HEATER is in the centre of a building, thereby allowing the most efficient use of the heat created. The location of windows, doors and the traffic flow in the room where the heater is to be located, should all be considered. - Page 5 25-07-01 Page 5 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc...
-
Page 6: Clearances
CLEARANCES The YUNCA EROS FLUED GAS HEATER should be installed with clearances equal to or greater than those recommended below and comply with NZS 5261/ AG601. This is to ensure adequate air circulation around the heater and avoid heat damage to wall coverings. - Page 7 Burn only the fuel for which the heater is equipped. The YUNCA EROS may be shipped from the factory equipped to burn natural gas, Propane or L.P.G. The data plate affixed to the back of the heater specifies the gas type which the heater is factory equipped for.
- Page 8 CAUTION: Do not use this heater if any part has been under water or exposed to moisture causing corrosion. A Qualified service technician should inspect the heater and replace any part of the gas system that has been under water. 25-07-01 Page 8 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc...
- Page 9 Reposition in an unobtrusive place. CONNECTING THE FAN The fan should be connected to the mains supply (240V 50Hz) via the 3m flex and 3pin plug 25-07-01 Page 9 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc...
-
Page 10: Operation
8. After the front burner has been on for at about 3 minutes. Turn the back burner on, by pushing in knob “C” and turning Anti-Clockwise to maximum position. 25-07-01 Page 10 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc... - Page 11 3. Push in the pilot control knob “A” and turn it clockwise to off. Note: The knob cannot be turned from “pilot” to “off” unless it is pushed in slightly. Do not force it. 25-07-01 Page 11 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc...
-
Page 12: Maintenance
3. To remove the front glass place one hand under it and lift it up and out of the doorframe. 4. New glass with gasket attached can be ordered through your YUNCA EROS agent. Note: Only recommended heat resistant glass may be fitted. - Page 13 REPLACING THE GASKET. The YUNCA EROS has a 10mm fibreglass gasket surrounding the front door. Should it ever need replacement, use only the replacement gasket that is available from your YUNCA dealer. The reference number for this is listed in the parts list.
- Page 14 There must be no blockages and the flue must be in good repair. Any sections that are taken apart for inspection must be reassembled and sealed as required. 25-07-01 Page 14 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc...
- Page 15 6. The fan blades can be cleaned of any dirt and grim. 7. Reassemble The fan assembly should only be disassembled by an electrician or trained Yunca Technician. 25-07-01 Page 15 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc...
-
Page 16: Fault Finding Guide
Purge gas lines. No Supply Gas. L.P.G. -- Refill tank Natural -- Check with gas supplier 25-07-01 Page 16 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc... - Page 17 Weak or improperly located Adjust the height of the pilot flame. thermocouple (using the brass nut at its base) The flame should engulf the 25-07-01 Page 17 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc...
- Page 18 Extract the control valve, note the position. Clean the control valve clean and re- assemble. Test operation. 25-07-01 Page 18 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc...
-
Page 19: Gas Type Conversion
The two screws that attach the pilot assembly are now accessible under the front burner, remove these screws. 25-07-01 Page 19 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc... - Page 20 15. Test all connections for gas tightness and replace logs and door. 16. Update or replace appliance data plate for new specifications and gas type. 25-07-01 Page 20 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc...
-
Page 21: Parts List
BACK BURNER NATURAL 2.5 mm diameter 2.95 mm diameter L.P.G. (NZ only) 1.10 mm diameter 1.30 mm diameter PROPANE 1.20 mm diameter 1.40 mm diameter 25-07-01 Page 21 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc... - Page 22 APPENDIX D: Warranty: The Yunca EROS Gas Heater is covered by a limited Five-Year Warranty against defects in materials and workmanship. All gas and electrical components including control, burners, pilot assembly, tubing, fan and switches are warranted for a period of one year from date of purchase.
-
Page 23: Warranty Registration
Purchasers’ Address. _________________________________________________________ City. _____________________________ Postcode. ____________ Telephone __________ Where Purchased. ____________________________________________________________ Installed By. ________________________________________________ Date. _____________ Return to: Yunca Heating PO Box 932 INVERCARGILL 25-07-01 Page 23 of 23 Operation Instructions for Eros Free Standing Gas Fire July 2001.doc...