Yunca Gas LEEDZ Operations, Maintenance & Warranty Information page 12

REPLACING THE GASKET.
The YUNCA LEEDZ has a 10mm fibreglass gasket surrounding the front door. Should it
ever need replacement, use only the replacement gasket that is available from your
YUNCA dealer. The reference number for this is listed in the parts list.
Procedure.
1. Remove the front door as described on previous page.
2. Remove the existing gasket and clean the channel of all loose material.
3. Lay a thin bed of gasket cement around the length of the channel.
4. Lay the gasket in the channel.
5. Replace the door carefully to avoid dislodging the gasket.
Cleaning The Glass
The glass may be cleaned with ordinary household glass cleaner and a soft cloth or
paper towel.
Note: Never clean the glass when it is hot. Do not use abrasive cleaners on the
glass.
CLEANING THE LOG SET AND FIREBOX.
During the annual inspection and maintenance appointment, the service person should
clean dust, lint and any light soot accumulation from the logs and the firebox area. An
extra soft brush should be used on the logs, as they are extremely fragile. If at any time
the logs cannot be removed or installed without force, the cause must be found. The
logs must never be forced.
Procedure,
1. Remove front door as described on page 11.
2. Remove the complete log set from the firebox by lifting it up and out. Brush it gently
over a newspaper and carefully place it out of the way.
3. The bark tray can be removed by lifting its feet over the bottom gasket retainer and
pulling it straight out, with the bark still on it.
4. The bark consists of a mixture of vermiculite and composite chips and it can be
dusted by sieving. If needed a replacement bag can be ordered through your YUNCA
dealer.
(See parts list for reference number)
5. With firebox empty a vacuum cleaner can be used to remove any visible dust and lint
from within the firebox area.
6. Replace the bark tray.
7. Replace log set and redistribute bark.
8. Replace and relatch the front door and close the side panels.
25-07-01 Page 12 of 22 Operation Instructions for Leedz Free Standing July 2001.doc