Floor Mat; Floor Mat Removal; Floor Mat Installation - Club Car TURF 272 2005 Maintenance Service Manual

4
BODY AND TRIM

FLOOR MAT

Read General Warning, Section 1, Page 1-1.

FLOOR MAT REMOVAL

1. Turf 272/Carryall 272/XRT 1200:
1.1. Remove the brake and accelerator pedals. See Accelerator Pedal Removal, Section 5,
Page 5-5. Also see Brake Pedal Removal, Section 5, Page 5-1.
1.2. Remove the top edge of the floor mat from the overlapping flange under the dash, and remove the
mat.
1. Carryall 472/XRT 1200SE:
1.1. Begin at the corner where the rear seat frame meets the floorboard and roll the mat corner toward
the center of the vehicle, from under the side support angle, pulling it diagonally from the vehicle.

FLOOR MAT INSTALLATION

1. Turf 272/Carryall 272/XRT 1200:
1.1. Install the floor mat in the reverse order of removal.
1.2. Install the brake and accelerator pedals. See Brake Pedal Installation, Section 5, Page 5-1. Also
see Accelerator Pedal Installation, Section 5, Page 5-5.
2. Carryall 472/XRT 1200SE:
2.1. Begin at the corners of where the rear seat frame meets the floorboard, and slide each corner under
the frame, sliding each side under the angle supports and lastly lapping the edge against the back
of the front seat support.
Page 4-16 2005 Turf/Carryall 272/472 and XRT 1200/1200SE Gasoline Vehicle Maintenance and Service Manual
Floor Mat