To Return Vehicle To Service - Club Car TURF 272 2005 Maintenance Service Manual

GENERAL INFORMATION

TO RETURN VEHICLE TO SERVICE

1. Make sure the key switch is OFF and the Forward/Reverse handle is in the NEUTRAL position. Remove
the key. Chock the wheels.
2. Remove plug from vent tube and connect to tank vent (Figure 3-2, Page 3-3 or Figure 3-3, Page 3-3).
3. Connect battery cables, positive (+) cable first, and tighten terminals to 12 ft-lb (16.3 N·m). Coat terminals
with Battery Terminal Protector Spray (CCI P/N 1014305).
4. Connect the spark plug wire.
5. Completely open fuel shut-off valve (Figure 3-4, Page 3-3). A partially closed fuel valve (Figure 3-6,
Page 3-4) combined with the use of the choke, can result in a fouled spark plug and engine failure.
6. Make sure the Forward/Reverse handle is in the NEUTRAL position.
7. Crank the engine until it starts. Turn the engine off. See following NOTE.
NOTE: Due to the oil added to the engine in preparation for storage, engine may smoke excessively for a
short time when it is run for the first time after storage.
8. Adjust tires to recommended tire pressure. See General Information, Section 8, Page 8-1.
VENT
TO CARBURETOR
VENT TUBE
Figure 3-2 Turf-CA 272/XRT 1200 Fuel Tank
FULL OPEN (ON)
POSITION
VIEWED FROM SELECTOR
SIDE OF VALVE
Figure 3-4 Fuel Valve – Open
2005 Turf/Carryall 272/472 and XRT 1200/1200SE Gasoline Vehicle Maintenance and Service Manual
FUEL GAS
SHUT-OFF TANK
VALVE
GAS
TANK
VENT
TUBE
Figure 3-3 Carryall 472/XRT 1200SE Fuel Tank
WITH OFF MARKINGS ON THE SIDES OF VALVE)
OFF
VENT
FUEL SHUT-OFF VALVE
FUEL PUMP
(under rear
seat)
A
FUEL FILTER
(under rear seat)
CLOSED (OFF) POSITION
(SELECTOR IS ALIGNED
VIEWED FROM SELECTOR
SIDE OF VALVE
Figure 3-5 Fuel Valve – Closed
3
Storage
A
OFF
Page 3-3