Subaru 1600 Service Manual page 156

3. Station Wagon
1) Removal
I) Detach rear trim and rear quarter
trim.
2) Remove separator from rear
quarter panel.
3) Disconnect hoses from separator.
4) Remove screw securing band to
separator, and take out separator by
expanding the band.
2) Installation
1) Fit band to separator with screw.
2) Connect hoses to separator with
clips.
3) Install separator onto rear quarter
panel with 2 screws.
4) Attach rear trim and rear quarter
trim as before.
4·8. Fuel Filter
FUEL SYSTEM
4. 4WD BRAT
1) Removal
1) Detach rear side panel cover on
right side of rear cargo space.
2) Detach separator from back side
of rear side panel, and pull it out
through side panel hole.
Fig. 4·97
A2H65
NOTE:
2. Inspection
a. Before starting the job, be sure to
carry out the following.
1) Place "No fire" signs near the
working area.
2)
Disconnect ground cable from
battery.
b. Be careful not to spill fuel on the
floor.
1. Replacement
NOTE:
Before removing the fuel filter, pinch
the delivery hose on the fuel tank side
(as viewed from the fuel filter) with a
pinch cock, etc., to block the dis-
charge of fuel.
1) Unfasten the clip which connects
the fuel hose to the fuel filter and
disconnect the hose.
2) Remove the fuel filter from the
holder.
NOTE:
The fuel filter has a cartridge design.
NOTE:
The fuel filter has a cartridge design
and cannot be disassembled.
a. Check the interior of the fuel filter
for any indication of dust or dirt.
If dust or dirt is noticed, replace
the fuel filter.
b. If water is in the fuel filter, point
the fuel outlet down and shake the
fuel filter to remove water.
r
I
d
Front
Non-BRAT
Fig.
4-98
Non-BRA T
Pipe assembly
A21·1B4
3) Disconnect hoses from separator.
4) Remove screw securing band to
separator, and take out separator by
expanding the band.
2) Installation
1) Fit band to separator with screw_
2) Connect hoses to separator with
clips.
3)
Install separator onto back side of
rear side panel with
2
screws.
4) Attach rear side panel cover as
before.
Front
BRAT
A21·185
Fig. 4·99 BRA T