Storage - Toro 07385 Operator's Manual

Storage

1. Position the machine on a level surface, set the parking
brake, stop the engine, and remove the ignition key.
2. Clean dirt and grime from the entire machine, including
the outside of the engine cylinder head fins and blower
housing.
Important: You can wash the machine with mild
detergent and water. Do not use high pressure
water to wash the machine. Pressure washing
may damage the electrical system or wash away
necessary grease at friction points. Avoid excessive
use of water, especially near the control panel,
lights, engine, and the battery.
3. Inspect the brakes; refer to
Checking the Brake Fluid (page 23).
4. Service the air cleaner; refer to
Servicing the Air Cleaner (page 39).
5. Seal the air cleaner inlet and the exhaust outlet with
weatherproof tape.
6. Grease the machine.
7. Change the engine oil; refer to
Changing the Engine Oil And Filter (page 39).
8. Flush the fuel tank with fresh, clean diesel fuel.
9. Secure all fuel system fittings.
10. Check the tire pressure; refer to
Checking the Tire Pressure (page 23).
11. Check anti freeze protection and add a 50/50 solution
of water and anti freeze as needed for expected
minimum temperature in your area.
12. Remove the battery from the chassis, check the
electrolyte level, and charge it fully; refer to
Servicing the Battery (page 42).
Note: Do not connect the battery cables to the battery
posts during storage.
Important: The battery must be fully charged to
prevent it from freezing and being damaged at
temperatures below 0° C (32° F). A fully charged
battery maintains its charge for about 50 days
at temperatures lower than 4° C (40° F). If the
temperatures will be above 4° C (40° F), check the
water level in the battery and charge it every 30
days.
13. Check and tighten all bolts, nuts, and screws. Repair or
replace any part that is damaged.
14. Paint all scratched or bare metal surfaces.
Paint is available from your Authorized Service Dealer.
15. Store the machine in a clean, dry garage or storage area.
16. Remove the ignition key and put it in a safe place out
of the reach of children.
17. Cover the machine to protect it and keep it clean.
54