Operation - Toro 07385 Operator's Manual

stop using vehicle. Make sure the problem is corrected
before vehicle or attachment is operated again.
•
Since diesel fuel is highly flammable, handle it carefully.
– Use an approved fuel container.
– Do not remove the cap from the fuel tank when the
engine is hot or running.
– Do not smoke while handling fuel.
– Fill the fuel tank outdoors and to about one inch
below the top of tank (bottom of filler neck). Do not
overfill.
– Wipe up any spilled fuel.
•
Operate the vehicle only outdoors or in a well ventilated
area.
•
Use only an approved nonmetal, portable fuel container.
Static electric discharge can ignite fuel vapors in a
ungrounded fuel container. Remove the fuel container
from the bed of the vehicle and place it on the ground
away from the vehicle before filling. Keep the nozzle
in contact with the container while filling. Remove
equipment from vehicle bed before filling.
•
Check the safety interlock system daily for proper
operation. If a switch should malfunction, replace the
switch before operating machine. After every two years,
replace the interlock switches in the safety system,
whether they are working properly or not.

Operation

•
The operator and passenger must use seat belts and
remain seated whenever the vehicle is in motion. The
operator should keep both hands on the steering wheel,
whenever possible, and the passenger should use the hand
holds provided. Keep arms and legs within the vehicle
body at all times. Never carry passengers in the box or
on attachments. Remember your passenger may not be
expecting you to brake or turn and may not be ready.
•
Never overload your vehicle. The name plate (located
under the middle of the dash) shows the load limits for
the vehicle. Never overfill attachments or exceed the
vehicle maximum gross vehicle weight (GVW).
•
When starting the engine:
– Sit on operator's seat and ensure that the parking
brake is engaged.
– Disengage PTO (if so equipped) and return the hand
throttle lever to the Off position (if so equipped).
– Make sure the hydraulic lift lever is in the center
position.
– Move shift lever to Neutral and press the clutch pedal.
– Keep your foot off of the accelerator pedal.
– Turn ignition switch to the On position. When the
glow plug indicator goes off, the engine is ready to
start.
– Turn the ignition key to the Start position.
Note: The glow plug indicator will turn on, for an
additional 15 seconds, when the switch returns to the
Start position.
•
Using the machine demands attention. Failure to operate
vehicle safely may result in an accident, tip over of the
vehicle, and serious injury or death. Drive carefully. To
prevent tipping or loss of control, take the following
precautions:
– Use extreme caution, reduce speed, and maintain
a safe distance around sand traps, ditches, creeks,
ramps, any unfamiliar areas, or other hazards.
– Watch for holes or other hidden hazards.
– Use caution when operating the vehicle on a steep
slope. Normally, travel straight up and down slopes.
Reduce speed when making sharp turns or when
turning on hillsides. Avoid turning on hillsides
whenever possible.
– Use extra caution when operating the vehicle on
wet surfaces, at higher speeds, or with a full load.
Stopping time will increase with a full load. Shift into
a lower gear before starting up or down a hill.
– When loading the bed, distribute the load evenly.
Use extra caution if the load exceeds the dimensions
of the vehicle/bed. Operate the vehicle with extra
caution when handling off-center loads that cannot
be centered. Keep loads balanced and secure to
prevent them from shifting.
– Avoid sudden stops and starts. Do not go from
reverse to forward or forward to reverse without first
coming to a complete stop.
– Do not attempt sharp turns or abrupt maneuvers or
other unsafe driving actions that may cause a loss of
vehicle control.
– Do not pass another vehicle traveling in the same
direction at intersections, blind spots, or at other
dangerous locations.
– When dumping, do not let anyone stand behind
vehicle and do not dump the load on any one's feet.
Release the tailgate latches from the side of box, not
from behind.
– Keep all bystanders away. Before backing up, look to
the rear and ensure that no one is behind the vehicle.
Back up slowly.
– Watch out for traffic when near or crossing roads.
Always yield the right of way to pedestrians and other
vehicles. This vehicle is not designed for use on
streets or highways. Always signal your turns or stop
early enough so other persons know what you plan to
do. Obey all traffic rules and regulations.
– Never operate the vehicle in or near an area where
there is dust or fumes in the air which are explosive.
The electrical and exhaust systems of the vehicle can
produce sparks capable of igniting explosive materials.
– Always watch out for and avoid low overhangs such
as tree limbs, door jambs, over head walkways, etc.
5