Assembly Instructions - Spirit XT485 Owner's Manual

ASSEMBLY INSTRUCTIONS

!!ATTENTION: IMPORTANT UNPACKING INSTRUCTIONS. PLEASE READ
BEFORE UNPACKING YOUR FOLDING TREADMILL!!
Serious injury could occur if this folding treadmill is not unpacked properly.
There is a Velcro strap installed around the treadmill base that prevents the treadmill
from unfolding accidentally during shipping. If this strap is not removed properly the
treadmill could spring open unexpectedly and cause injury if someone is standing near
the treadmill when the strap is removed.
To ensure your personal safety during removal of the shipping strap please make sure
the treadmill is positioned flat on the ground, in the orientation it would be in if you were
using the treadmill. Do not turn the treadmill up on its side while removing the shipping
strap. This could cause the treadmill's folding mechanism to spring open. If the end of
the Velcro strap (that you need to grab to remove it) happens to be under the treadmill
deck, reach under the deck to grab it, but do not tilt the treadmill up to gain access to
the strap end.
Cut the banding straps with a short box cutter (razor knife); separate the carton from the
one underneath it by prying up on the staples (if applicable). Pull the carton over the
treadmill parts and locate the hardware pack. The hardware pack is separated into five
sections; one section containing tools and four sections labeled steps 1-4 which contain
the hardware needed for assembly of each step. The assembly steps below are
numbered one through four and correspond to the hardware in the numbered sections
of the hardware pack. Remove only the hardware for the step you are currently
assembling to avoid confusion and mix ups.
Then remove the treadmill from the carton and lay it on a level surface.
ASSEMBLY TOOLS
#131. Combination M5 Allen Wrench
& Phillips Head Screw Driver
#132. M6 Allen Wrench
Customer Service 1-888-707-1880
Email: customerservice@pincoffs.ca
#148. Phillips Head Screw Driver
#75. Safety Key
7
#30. Deck/Belt Lubricant
Dyaco Canada Inc. 2013