Yamaha FX10X 2008 Service Manual page 8

OIL PAN AND OIL PUMP .............................. 5-44
REMOVAL ................................................ 5-47
INSPECTION ............................................ 5-47
INSTALLATION ........................................ 5-49
CRANKCASE ................................................. 5-51
REMOVAL ................................................ 5-53
INSPECTION ............................................ 5-53
INSTALLATION ........................................ 5-54
CONNECTING RODS AND PISTONS ........... 5-57
REMOVAL ................................................ 5-58
INSPECTION ............................................ 5-59
INSTALLATION ........................................ 5-65
CRANKSHAFT AND BALANCER SHAFT .... 5-68
REMOVE .................................................. 5-70
INSPECTION ............................................ 5-71
INSTALLATION ........................................ 5-74
CHAPTER 6.
COOLING SYSTEM
RADIATOR ....................................................... 6-1
INSPECTION .............................................. 6-3
INSTALLATION .......................................... 6-4
THERMOSTAT ................................................. 6-5
INSPECTION .............................................. 6-6
INSTALLATION .......................................... 6-6
WATER PUMP.................................................. 6-7
REMOVAL .................................................. 6-9
DISASSEMBLY........................................... 6-9
INSPECTION ............................................ 6-10
ASSEMBLY............................................... 6-10
INSTALLATION ........................................ 6-11
OIL COOLER AND HEAT EXCHANGER ...... 6-12
INSPECTION ............................................ 6-14
CHAPTER 7.
FUEL INJECTION SYSTEM
FUEL INJECTION SYSTEM............................. 7-1
CIRCUIT DIAGRAM.................................... 7-2
ECU SELF-DIAGNOSTIC FUNCTION ....... 7-4
SELF-DIAGNOSTIC FUNCTION TABLE ... 7-4
TROUBLESHOOTING CHART .................. 7-6
DIAGNOSTIC MODE.................................. 7-7
TROUBLESHOOTING DETAILS.............. 7-13
OIL PRESSURE SWITCH ........................ 7-26
INTAKE AIR TEMPERATURE
SENSOR................................................... 7-26
ISC (IDLE SPEED CONTROL) UNIT........ 7-27
AIR FILTER CASE ......................................... 7-28
THROTTLE BODY.......................................... 7-29
INJECTORS.............................................. 7-30
REMOVAL................................................. 7-32
INSPECTION ............................................ 7-32
FUEL PRESSURE INSPECTION ............. 7-33
INSPECTION AND ADJUSTMENT .......... 7-34
CHAPTER 8.
ELECTRICAL
SWITCH INSPECTION ..................................... 8-1
SWITCH INSPECTION ............................... 8-1
INSPECTING A SWITCH SHOWN IN
THE MANUAL ............................................. 8-1
IGNITION SYSTEM .......................................... 8-2
CIRCUIT DIAGRAM.................................... 8-2
TROUBLESHOOTING ................................ 8-4
IGNITION SPARK GAP .............................. 8-6
IGNITION COIL........................................... 8-6
CRANKSHAFT POSITION SENSOR ......... 8-7
THROTTLE OVERRIDE SYSTEM
(T.O.R.S.).................................................... 8-8
ENGINE STOP SWITCH ............................ 8-9
THROTTLE SWITCH .................................. 8-9
MAIN SWITCH .......................................... 8-10
ELECTRICAL STARTING SYSTEM .............. 8-11
CIRCUIT DIAGRAM.................................. 8-11
TROUBLESHOOTING .............................. 8-12
STARTER MOTOR ................................... 8-14
CHARGING SYSTEM ..................................... 8-18
CIRCUIT DIAGRAM.................................. 8-18
TROUBLESHOOTING .............................. 8-19
BATTERY.................................................. 8-20
STATOR COIL .......................................... 8-20
LIGHTING SYSTEM ....................................... 8-22
CIRCUIT DIAGRAM.................................. 8-22
TROUBLESHOOTING .............................. 8-24
BULB(S) .................................................... 8-27
HEADLIGHT BEAM SWITCH ................... 8-27
HEADLIGHT RELAY................................. 8-28
LOAD CONTROL RELAY ......................... 8-28
SIGNAL SYSTEM ........................................... 8-30
CIRCUIT DIAGRAM.................................. 8-30
TROUBLESHOOTING .............................. 8-32
BRAKE LIGHT SWITCH ........................... 8-38