Air Filter; Fuel - Jacobsen HR 9016 Turbo Parts & Maintenance Manual

4 MAINTENANCE
4.7

AIR FILTER_______________________________________________________________

Check the service indicator daily. Replace air cleaner
element immediately when red band becomes visible (A)
Do not remove the element for inspection or
cleaning. Unnecessary removal of the filter increases
the risk of injecting dust and other impurities into the
engine.
When service is required, first clean the outside of the
filter housing, then remove the old element as gently as
possible and discard.
1. Carefully clean the inside of the filter housing without
allowing dust into the air intake.
2. Inspect the new element. Do not use a damaged
element and never use an incorrect element.
3. Assemble the new element and make sure it seats
properly. Reset the indicator by depressing button
(B).
4. Reassemble cap making sure it seals completely
around the filter housing. Dust evacuator (C) must
be facing down.
4.8

FUEL ____________________________________________________________________

Handle fuel with care - it is highly flammable. Use an
approved container, the spout must fit inside the fuel filler
neck. Avoid using cans and funnels to transfer fuel.
!
WARNING
Never remove the fuel cap from the fuel tank, or add
fuel, when the engine is running or while the engine is
hot.
Do not smoke when handling fuel. Never fill or drain
the fuel tank indoors.
Use4 care to avoid spilling fuel. If fuel is spilled, clean
it up immediately.
Never handle or store fuel containers near an open
flame or any device that may create sparks and ignite
the fuel or fuel vapors.
Be sure to reinstall and tighten fuel cap securely.
• Fill the fuel tank to within 1 in. (25 mm) below the filler
neck.
• Use clean, fresh, #2 Low or Ultra Low Sulfur Diesel
fuel. Minimum Cetane Rating 45. Refer to Engine
Manual for additional information.
en-22
5. Check all hoses and air ducts. Tighten hose clamps.
B
A
C
• Replace fuel lines and clamps at the first sign of
damage.
• Store fuel according to local, state, or federal
ordinances and recommendations from your fuel
supplier.
• Never overfill or allow the tank to become empty.
Read Engine Owner's Manual for additional fueling
information.
HR009
Figure 4E