Cornelius FCB 3 H.P. POST-MIX DISPENSER Installation & Service Manual page 6

TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING CONTROL PANEL SWITCHES AND FAULT
MESSAGES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ONE OR MORE CONTROL PANEL SWITCHES NOT OPERATING.
ALL CONTROL PANEL SWITCHES NOT OPERATING.
ALL CONTROL PANEL SWITCHES NOT OPERATING. (COND'T)
CONTROL PANEL SWITCHES CANNOT BE DEACTIVATED.
PARTIAL MESSAGE OR DULL (POORLY ILLUMINATED) DISPLAY.
ONE OR MORE FAULT MESSAGES NOT OPERATING.
ALL FAULT MESSAGES NOT OPERATING.
''CO2 OUT'' FAULT MESSAGE GOES ON DURING OPERATION.
''H2O OUT'' FAULT MESSAGE GOES ON DURING OPERATION.
''SYRUP 1'' OR ''SYRUP 2'' FAULT MESSAGE GOES ON DURING
OPERATION.
''ERROR 1'' OR ''ERROR 2'' FAULT MESSAGE GOES ON DURING
OPERATION.
FREEZE CYLINDER AUTOMATIC DEFROST CYCLE DOES NOT
OPERATE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
UNIT DOES NOT GO OFF AUTOMATIC DEFROST CYCLE.
MANUAL DEFROST CYCLE DOES NOT OPERATE WHEN ''DEFROST''
SWITCH IS PRESSED.
DEFROST CYCLE DOES NOT CANCEL AFTER PRESSING ''CANCEL
DEFROST '' SWITCH.
TROUBLESHOOTING PRODUCT BLENDER TANKS AND CARBONATORS
CARBONATOR WATER PUMP MOTOR WILL NOT OPERATE.
CARBONATOR WATER PUMP WILL NOT SHUT OFF.
ERRATIC CARBONATOR WATER PUMP CYCLING.
TROUBLESHOOTING DISPENSED PRODUCT
BRIX (WATER-TO-SYRUP) ''RATIO'' TOO LOW.
BRIX (WATER-TO-SYRUP) ''RATIO'' TOO HIGH.
IMPROPER PRODUCT DISPENSED.
PRODUCT WILL NOT DISPENSE OUT OF DISPENSING VALVE, IN ONLY
SMALL AMOUNTS, OR ONLY LIQUID.
FREEZE CYLINDER DOES NOT REFILL AT ALL TIMES WHEN
DISPENSING.
FROZEN PRODUCT CONSISTENCY VARIES EXCESSIVELY.
CYLINDER FREEZE-UP.
TROUBLESHOOTING REFRIGERATION SYSTEM
UNIT EQUIPPED WITH AIR-COOLED REFRIGERATION SYSTEM
UNIT EQUIPPED WITH WATER-COOLED REFRIGERATION SYSTEM
ACCESSORIES AND TOOLS
ACCESSORIES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GENERIC FLAVOR TABS
SERVICE TOOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
WARRANTY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TABLE OF CONTENTS (cont'd)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . .
. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .
v
Page
63
63
. . . . . 63
63
. . . . . . 64
64
. . . . . 64
64
64
. . . . . . . 65
. . . . . . . 65
65
65
65
65
65
66
. . 66
. . . . . . . . . 66
66
66
67
67
67
67
67
67
. . . . . . . . . 67
68
68
. . . . . 68
. . 68
68
68
68
68
69
312026000