Interior Cleaning And Sanitizing - Manitowoc S Model Installation, Use & Care Manual

Section 4

Interior Cleaning and Sanitizing

GENERAL
Clean and sanitize the ice machine every six months for
efficient operation. If the ice machine requires more
frequent cleaning and sanitizing, consult a qualified
service company to test the water quality and
recommend appropriate water treatment. The ice
machine must be taken apart for cleaning and sanitizing.
Use only Manitowoc approved Ice Machine Cleaner
and Sanitizer for this application (Manitowoc
Cleaner part number 94-0546-3 and Manitowoc
Sanitizer part number 94-0565-3). It is a violation of
Federal law to use these solutions in a manner
inconsistent with their
understand all labels printed on bottles before use.
CLEANING PROCEDURE
Do not mix Cleaner and Sanitizer solutions together.
Wear rubber gloves and safety goggles (and/or face
shield) when handling ice machine Cleaner or
Sanitizer.
Ice machine cleaner is used to remove lime scale and
mineral deposits. Ice machine sanitizer disinfects and
removes algae and slime.
Step 1 Remove front door and top cover. This will allow
easiest access for adding cleaning and sanitizing
solutions.
Step 2 Set the toggle switch to the OFF position after
ice falls from the evaporator at the end of a Harvest
cycle. Or, set the switch to the OFF position and allow
the ice to melt off the evaporator.
Never use anything to force ice from the evaporator.
Damage may result.
Part Number 000002477 3/08
Maintenance
! Caution
labeling. Read
! Caution
Warning
!
! Caution
Section 4
Step 3 Remove all ice from the bin/dispenser.
Step 4 Place the toggle switch in the CLEAN position.
The water will flow through the water dump valve and
down the drain. Wait until the water trough refills and
water flows over the evaporator, then add the proper
amount of ice machine cleaner.
Model
S0600C/S0800C
S1000C/S1200C
S1470C/S1870C/S2170C
IB620C/IB820C/IB1020C
Step 5 Wait until the clean cycle is complete
and
(approximately 35 minutes) then place the toggle switch
in the OFF position and disconnect power to the ice
machine (and dispenser when used).
Disconnect the electric power to the ice machine at
the electric service switch box.
Step 6 Remove parts for cleaning.
Please refer to the proper parts removal for your
ice machine.
S600C/S850C/S1000C/S1200C - Page 4-2 & 4-3.
S1470C/S1870C/S2170C - Page 4-4 & 4-5.
IB620C/IB820C/IB1020C - Page 4-6 & 4-7.
Maintenance
Amount of Cleaner
3 ounces (90 ml)
9 ounces (270 ml)
5 ounces (150 ml)
! Warning
4-1