1. Manuals
  2. Brands
  3. Winnebago Manuals
  4. Motorhomes
  5. Chalet
  6. Manual

Winnebago Chalet Manual

Hide thumbs Also See for Chalet:
Table of Contents

Advertisement

Quick Links

Download this manual See also: Operator's Manual
About this Manual ............................................................................................................................ 1-1
Safety Messages Used in this Manual .............................................................................................. 1-1
Pre-Delivery Inspection .................................................................................................................... 1-2
Front Axle Tire Alignment ............................................................................................................... 1-2
Service and Assistance ...................................................................................................................... 1-2
Reporting Safety Defects .................................................................................................................. 1-2
Specifications and Capacities ........................................................................................................... 1-4
Owner Information ........................................................................................................................... 1-6
Emergency Information .................................................................................................................... 1-6
General Warnings ............................................................................................................................. 2-1
Driving Safety ................................................................................................................................... 2-1
Propane Gas Leak Detector .............................................................................................................. 2-1
Carbon Monoxide Warning .............................................................................................................. 2-2
Carbon Monoxide Alarm .................................................................................................................. 2-2
Smoke Alarm .................................................................................................................................... 2-3
Fire Extinguisher ............................................................................................................................... 2-3
Emergency Exits ............................................................................................................................... 2-4
Formaldehyde Information ............................................................................................................... 2-5
Mold, Moisture and Your Motor Home ............................................................................................ 2-5
Roadside Emergency ........................................................................................................................ 2-6
Jump Starting .................................................................................................................................... 2-7
Engine Overheat ............................................................................................................................... 2-7
Seats .................................................................................................................................................. 3-1
Fold-Down Dinette Seat ................................................................................................................... 3-2
Seat Belts .......................................................................................................................................... 3-2
Child Restraints ................................................................................................................................. 3-3
Rearview Monitor System ................................................................................................................ 3-4
Power Electric Mirrors ...................................................................................................................... 3-5
Foot-Pedal Parking Brakes ............................................................................................................... 3-6
Automatic / Pull-Button Parking Brakes .......................................................................................... 3-6
Grade Brake ...................................................................................................................................... 3-6
Over-Drive Switch ............................................................................................................................ 3-7
Tow/Haul Transmission Mode ......................................................................................................... 3-7
Map Light Switch ............................................................................................................................. 3-7
Rev. 0802080114

TABLE OF CONTENTS

©Copyright 2007 Winnebago Industries, Inc. All rights reserved.
Part No. 161500-08-027

Advertisement

Table of Contents
loading

Related Manuals for Winnebago Chalet

Summary of Contents for Winnebago Chalet

  • Page 1: Table Of Contents

    Foot-Pedal Parking Brakes ....................... 3-6 Automatic / Pull-Button Parking Brakes ..................3-6 Grade Brake ............................3-6 Over-Drive Switch ..........................3-7 Tow/Haul Transmission Mode ......................3-7 Map Light Switch ..........................3-7 Rev. 0802080114 Part No. 161500-08-027 ©Copyright 2007 Winnebago Industries, Inc. All rights reserved.
  • Page 2 Table Of Contents D-Series Class-A Hazard Warning Flashers ........................3-8 Battery Boost Switch ........................3-8 Auto Air Conditioner/Heater ......................3-8 Rear Coach Heater ..........................3-8 Defrost Fans ............................3-9 In-Dash Radio ........................... 3-9 CB Radio Power Wiring ......................... 3-10 Engine Access ..........................3-10 Engine Cooling System ........................
  • Page 3 Table Of Contents D-Series Class-A Ground Fault Circuit Interrupter ....................... 6-4 Electrical Generator .......................... 6-5 12-Volt DC System ........................... 6-6 Auxiliary Battery Disconnect Switch ....................6-6 House Battery Access ........................6-6 Battery Care ............................6-7 12-Volt House Fuses and Circuit Breakers ..................6-8 PLUMBING 7 Fresh Water System ..........................
  • Page 4 Table Of Contents D-Series Class-A Slideout Room – Extreme Weather Precaution ................10-3 Slideout Room Troubleshooting – Electric ..................10-3 Slideout Emergency Retraction – Electric ..................10-5 Slideout Emergency Retraction/ Bedroom – Electric ..............10-5 General Slideout Care ........................10-6 Leveling System ..........................

  • Page 5: Introduction

    DANGER indicates a directly hazardous are intended as a guide, and in no way situation which, if not avoided, will result extend the responsibilities of Winnebago in death or serious personal injury. Industries beyond the standard written warranty as presented in this manual.

  • Page 6: Pre-Delivery Inspection

    CAUTION indicates a potentially you may take your motor home to any authorized hazardous situation which, if not avoided, Winnebago or Itasca dealership and request their could result in damage mainly to assistance. equipment or property, but in some cases...

  • Page 7: Vehicle Certification Label

    2. Chassis manufacture date. 9. Rear Axle Wheel Configuration: Single or 3. Month and year of manufacture at Winnebago Dual as it relates to the inflation. Industries. 10. Serial Number: This is the serial number 4.
  • Page 8 SECTION 1 INTRODUCTION D-Series Class-A SEE NOTES ON FOLLOWING PAGES.
  • Page 9 SECTION 1 INTRODUCTION D-Series Class-A...

  • Page 10: Owner Information

    Motor Home Serial Number ____________________________________________________________ Vehicle Chassis Identification Number (VIN) _______________________________________________ Vehicle Mileage at Time of Delivery______________________________________________________ Selling Dealer Name and Address_______________________________________________________ __________________________________________________________________________________ EMERGENCY INFORMATION YOUR WINNEBAGO INDUSTRIES DEALER Name _____________________________________________________________________________ Address ___________________________________________________________________________ __________________________________________________________________________________ Contact Person _____________________________________________________________________ Phone ____________________________________________________________________________ CHASSIS DEALER/SERVICE CENTER...
  • Page 11 ITEMS NOT SUBJECT TO WARRANTY COVERAGE Winnebago Industries, Inc. of Forest City, Iowa, warrants each new Chassis, drivetrain and related components* Winnebago and Itasca motor home to the owner for recreational use Wheels* in the U.S.A. and Canada as follows:...
  • Page 12 If you are touring or have moved, contact any unresolved warranty disputes for recreational vehicles. This dispute Winnebago Industries motor home dealer in the United States or resolution program reviews eligible product and service related Canada for warranty service.

  • Page 13: Safety / Precautions

    SECTION 2 SAFETY / PRECAUTIONS • Driving through water deep enough to wet the GENERAL WARNINGS brakes may affect stopping distance or cause the vehicle to pull to one side. Check brake • Only seats equipped with seat belts are to be operation in a safe area to be sure they have occupied while the vehicle is moving.

  • Page 14: Carbon Monoxide Warning

    SECTION 2 SAFETY / PRECAUTIONS D-Series Class-A CARBON MONOXIDE WARNING WARNING Never use an open flame to test for gas leaks. When testing for gas line leaks with WARNING a soapy water solution, DO NOT use a detergent containing ammonia or Avoid inhaling exhaust gases, as they chlorine.

  • Page 15: Smoke Alarm

    RV application. We recommend obtaining a replacement from Your motor home is equipped with a smoke your Winnebago Industries dealer. alarm located on the ceiling in the lounge area. The smoke alarm is powered by a 9-volt battery FIRE EXTINGUISHER and has a sensor that is designed to detect smoke.

  • Page 16: Emergency Exits

    This window will be type and size, or larger, as the one originally marked EXIT and have a red handled latch. supplied in your coach. We recommend obtaining a replacement only from your Winnebago Industries dealer or a reliable RV parts supplier.

  • Page 17: Formaldehyde Information

    SECTION 2 SAFETY / PRECAUTIONS D-Series Class-A MOLD, MOISTURE AND YOUR MOTOR HOME What is Mold? Molds are part of the natural environment. They are as old as the Earth itself. And mold spores are almost everywhere at some level waiting to grow.

  • Page 18: Roadside Emergency

    Just ease back on the accelerator slowly and If Winnebago Industries determines that mold gently to continue momentum. The deflated is present in the Winnebago/Itasca motor home tire will slow the vehicle. as a result of a manufacturing defect reported to Winnebago Industries within the limited •...

  • Page 19: Jump Starting

    (wheel lift or frame lift) type towing assembly for Damage to the transmission or other safe towing. parts of the vehicle will occur. Winnebago Industries does not assume responsibility for damage incurred while towing ENGINE OVERHEAT this vehicle. NOTE: Consult the chassis manual for any...
  • Page 20 SECTION 2 SAFETY / PRECAUTIONS D-Series Class-A WARNING Operating a vehicle under a severe overheating condition can result in damage to the vehicle and may result in personal injury. For information on what to do in case of overheating, consult your chassis manual.

  • Page 21: Driving Your Motor Home

    The information in this section refers only to features installed or adapted to the dash and Lift to Recline driver compartment area by Winnebago Industries. It also includes passenger seating in the living area of the coach. See your chassis manual for all original chassis related controls, instrumentation, switches and other features.

  • Page 22: Fold-Down Dinette Seat

    SECTION 3 DRIVING YOUR MOTOR HOME D-Series Class-A Lap Belts FOLD-DOWN DINETTE SEAT The lap belts must be worn as low as possible (Models without front slideout and with and fit snugly across the hip area. Always sit dinette seat directly behind driver or erect and well back into the seat.

  • Page 23: Child Restraints

    SECTION 3 DRIVING YOUR MOTOR HOME D-Series Class-A • Inspect the belts and hardware periodically. Check for cuts, frays, and loose parts. WARNING Damaged parts should be replaced. Do not remove or modify the belt system. Snug and low belt positions are essential. •...

  • Page 24: Rearview Monitor System

    SECTION 3 DRIVING YOUR MOTOR HOME D-Series Class-A Tether Anchor Loop component model/serial sheet which is included in your InfoCase. In case keys are lost or stolen, If your coach has a dinette, it may be equipped your dealer or a locksmith can provide you with with a child seat tether anchor loop located on the duplicate keys or modify the locks.

  • Page 25: Power Electric Mirrors

    SECTION 3 DRIVING YOUR MOTOR HOME D-Series Class-A Basic Operating Instructions Press arrow buttons move mirror in direction indicated Power - Turn ON to activate monitor for rear viewing while driving or parked. Key must be on. In OFF position the monitor is ‘asleep’...

  • Page 26: Foot-Pedal Parking Brakes

    SECTION 3 DRIVING YOUR MOTOR HOME D-Series Class-A Note: Never drive your vehicle with the parking Mirror Head Pivot Lock brake set. It will reduce parking brake Loosen Allen head set screw effectiveness and cause excessive wear. to pivot mirror head.* (Torque 75-100 in/lbs) See your chassis manual for further information *Set screws may be located on the opposite side...

  • Page 27: Over-Drive Switch

    SECTION 3 DRIVING YOUR MOTOR HOME D-Series Class-A where the transmission will repeatedly shift up and down causing annoyance and reduced fuel economy. See your chassis manual for further information on this switch. Grade Break Symbol TOW/HAUL TRANSMISSION • Press and release the brake pedal once- the MODE grade brake will downshift the transmission a gear to help control the vehicle speed.

  • Page 28: Hazard Warning Flashers

    SECTION 3 DRIVING YOUR MOTOR HOME D-Series Class-A AUTO AIR CONDITIONER/ HEATER Roll panel light Controls for the air conditioner, heater, dimmer wheel defroster and vent are all combined into one upward fully to control panel. turn driver side map light on. HAZARD WARNING FLASHERS The hazard warning flashers provide additional safety when the vehicle must be...

  • Page 29: Defrost Fans

    SECTION 3 DRIVING YOUR MOTOR HOME D-Series Class-A Satellite Radio DEFROST FANS –If Equipped –If Equipped Your coach may be equipped with a Sirius satellite radio receiver that plays through your The two-speed auxiliary fans are intended to radio. See the radio manufacturer’s information assist the automotive windshield defroster in your InfoCase for programming and operating system in clearing fog and frost in cold weather...

  • Page 30: Cb Radio Power Wiring

    SECTION 3 DRIVING YOUR MOTOR HOME D-Series Class-A listening while parked. This prevents accidental ENGINE ACCESS draining of the chassis battery by prolonged use of the radio. Hood NOTE:The Aux. Battery Disconnect switch must Insert the tamper-resistant hood key into the be on while listening to the dash radio hood locks and turn them to the right (clockwise) because the audio relay is powered by...

  • Page 31: Engine Cooling System

    SECTION 3 DRIVING YOUR MOTOR HOME D-Series Class-A • To reinstall the engine cover, position the front end of the cover first, then lower the rear WARNING end. It is important to be sure the front edge is pushed completely forward to the radiator cover to ensure an air-tight seal.

  • Page 32: Automotive 12-Volt Fuses And Circuit Breakers

    SECTION 3 DRIVING YOUR MOTOR HOME D-Series Class-A LIGHTS All exterior lights should be checked for proper operation each time the vehicle is prepared for a trip. Any bulbs which fail to light should be checked and replaced, when necessary, with a new bulb of the same size.
  • Page 33 SECTION 3 DRIVING YOUR MOTOR HOME D-Series Class-A overheat, which could cause you to lose control of the vehicle. See your chassis manual for specific information. 3-13...

  • Page 35: Appliances & Systems

    SECTION 4 APPLIANCES & SYSTEMS The appliances installed in your motor home are manufactured by reputable RV appliance makers and have been tested by independent laboratories to meet all applicable standards and codes set for RV appliances. REFRIGERATOR The refrigerator in your coach can operate Bubble must be at least 1/2 inside circle from either of two energy sources available to the Normal vehicle leveling to provide comfort...

  • Page 36: Refrigerator Service Access Compartment

    SECTION 4 APPLIANCES & SYSTEMS D-Series Class-A To Close: • Auto- Refrigerator will operate on 120-VAC household current if the shoreline is 1. Replace the door into the opening. connected or the auxiliary generator is 2. Push the latch knobs in while turning to the running.

  • Page 37: Microwave Oven

    SECTION 4 APPLIANCES & SYSTEMS D-Series Class-A WARNING Portable fuel-burning equipment including wood and charcoal grills and stoves, shall not be used inside the recreational vehicle. The use of this equipment inside the recreational vehicle can cause fires or asphyxiation. Oven Burner Knob –If Equipped •...

  • Page 38: Tank Capacities

    SECTION 4 APPLIANCES & SYSTEMS D-Series Class-A Water Level Sensors Water Tank At the touch of a button this panel will display For example, if the fluid level is 1-2” below the fresh water and holding tank levels, propane the FULL sensor, the monitor will show the level gas tank level, plus the house battery condition.

  • Page 39: Water Heater - Gas

    SECTION 4 APPLIANCES & SYSTEMS D-Series Class-A Propane Gas Operation 1. Both the chassis engine and the generator engine must be shut off and 120 Volt AC • Press the Water Heater switch on the Monitor shoreline unplugged. Panel. 2. An interior light should be turned on to provide a small load which draws off the battery surface charge.

  • Page 40: Motor Aid Water Heater

    SECTION 4 APPLIANCES & SYSTEMS D-Series Class-A For Propane Gas Operation For Quick Recovery Operation (Dual Heating) Press the Water Heater switch on the Monitor Panel. The “Pilot Out” light will glow for about Turn On both Water Heater switches; the gas 10-15 seconds, then it will go out.

  • Page 41: Pressure-Temperature Relief Valve

    SECTION 4 APPLIANCES & SYSTEMS D-Series Class-A PRESSURE-TEMPERATURE RELIEF VALVE On occasion, water may be seen seeping from Open the water heater pressure temperature relief valve. This is no cause for repair or replacement of the valve. Lift handle straight out to open P-T valve when water heater is cold * 4.

  • Page 42: Heat Pump

    SECTION 4 APPLIANCES & SYSTEMS D-Series Class-A 2. Move THERMOSTAT switch from Off to nuisance smoke alarm. Heat and press the Temp Selector button (Up/ We do not recommend removing the Down arrows) until the desired temperature is smoke alarm battery. shown in the display.

  • Page 43: Ducted Roof Air Conditioning System

    SECTION 4 APPLIANCES & SYSTEMS D-Series Class-A Further Information Refer to the air conditioner manufacturer’s information in your InfoCase for complete operating instructions. ENERGY MANAGEMENT SYSTEM (EMS) –If Equipped (models with 2 roof air units only) The Energy Management System (EMS) •...

  • Page 44: Rear Air Conditioner Power Selector Switch

    SECTION 4 APPLIANCES & SYSTEMS D-Series Class-A REAR AIR CONDITIONER POWER SELECTOR SWITCH –If Equipped (models with 2 roof air units only) If you want to run the rear AC unit, you must switch the Rear A/C Selector switch to the proper power source.

  • Page 45: Furnace-A/C Thermostat Operation Chart

    SECTION 4 APPLIANCES & SYSTEMS D-Series Class-A FURNACE-A/C THERMOSTAT OPERATION CHART The following chart shows the system functions with the “Heat/Cool” thermostat. Disregard references to heat functions when using the “Cool Only” thermostat in the rear bedroom. 4-11...

  • Page 47: Propane Gas

    SECTION 5 PROPANE GAS PROPANE GAS SUPPLY WARNING The propane gas system supplies fuel for the gas range/oven, water heater, furnace and refrigerator (while in gas mode). When used and Do not alter or remove propane tank handled properly, this system is safe and gauge at any time.

  • Page 48: Safe Use Of The Propane Gas System

    SECTION 5 PROPANE GAS D-Series Class-A phone directory yellow pages for locations of local propane gas refilling stations or bulk DAN GE R dealerships. NOTE: If you travel outside the U.S. with your DO NOT FILL CONTAINER TO MORE motor home, you may find butane or THAN 80 PERCENT OF CAPACITY.

  • Page 49: Propane Gas Warnings And Precautions

    SECTION 5 PROPANE GAS D-Series Class-A • Exercise caution at all times. Be familiar with PROPANE GAS WARNINGS the distinctive odor of propane gas. If a leak is AND PRECAUTIONS suspected, turn off the supply valve immediately. Have the propane gas system It is illegal for vehicles equipped with propane checked by your dealer or other qualified tanks to travel on certain roadways or through...

  • Page 50: Propane Gas Pressure Regulator

    SECTION 5 PROPANE GAS D-Series Class-A NOTE:If your model is equipped with a propane powered electrical generator, there will be two regulators stacked one upon another. One regulates the house propane supply pressure; the other regulates pressure to the generator. •...

  • Page 51: Propane Vaporization In Cold Weather

    SECTION 5 PROPANE GAS D-Series Class-A tank and bottle manufacturers and propane gas dealers take every precaution to reduce moisture, but sometimes only a fraction of an ounce entering the tank can cause problems. To help avoid the possibility of freeze-up, always keep tank control valve closed when not in use, even when tank is empty, to prevent moisture from collecting on the inside.

  • Page 53: Electrical

    SECTION 6 ELECTRICAL Your coach is equipped with an electrical portion of the 120-volt current to 12-volt DC system consisting of two separate voltages: current. All equipment in the motor home that is normally powered by the house batteries is then •...

  • Page 54: Power Center

    SECTION 6 ELECTRICAL D-Series Class-A POWER CENTER Converter The power converter is generally located in a lower cabinet face in the galley or living area depending on the floorplan of your model. The converter power panel contains the house electrical system 120-volt circuit breakers and 30 Amp Receptacle 12-volt breakers or fuses.

  • Page 55: 120-Volt Circuit Breakers

    SECTION 6 ELECTRICAL D-Series Class-A Charging Section The converter charges house batteries while 120-volt external power is connected. The converter will automatically “sense” the condition of the battery. If it is below “full charge”, the Charging Section will start charging the batteries.

  • Page 56: 120-Volt Receptacles (Outlets)

    SECTION 6 ELECTRICAL D-Series Class-A Shut off the equipment (example: roof air GROUND FAULT CIRCUIT conditioner) and allow a brief cooling period. INTERRUPTER Then reset the breaker by moving the switch to “Off” and back to “On”. If the breaker is Bath, galley and exterior outlets are connected continually tripped and no overload is evident, to a GFCI (Ground Fault Circuit Interrupter),...

  • Page 57: Electrical Generator

    SECTION 6 ELECTRICAL D-Series Class-A ELECTRICAL GENERATOR –If Equipped WARNING Careless handling of the generator and electrical components can be fatal. Never touch electrical leads or appliances Refer to the hourmeter to determine when when your hands are wet, or when periodic maintenance is due and to record standing in water or on wet ground.

  • Page 58: 12-Volt Dc System

    SECTION 6 ELECTRICAL D-Series Class-A Refer to the generator manufacturer’s will withstand the frequent drain-and-recharge maintenance information in your InfoCase for cycles that occur under the demanding conditions specific recommendations. of a camping outing. The house batteries are automatically charged by the chassis alternator while the engine is WARNING running.

  • Page 59: Battery Care

    SECTION 6 ELECTRICAL D-Series Class-A ‘sulfating’ and prevents the battery from either releasing or accepting a charge. If this condition occurs, the battery must be replaced. If a battery does not contain at least 80% charge during freezing temperatures, the electrolyte can freeze and crack the battery case.

  • Page 60: 12-Volt House Fuses And Circuit Breakers

    SECTION 6 ELECTRICAL D-Series Class-A To ensure that the battery will always accept and hold a charge, follow these simple WARNING maintenance practices. • Make sure the batteries always remain securely clamped in the battery tray. To prevent wiring damage, it is essential when replacing the cables on the battery, •...

  • Page 61: Battery Charge Meter

    SECTION 6 ELECTRICAL D-Series Class-A A label on the panel states the amperage rating The fuse panel accepts only blade type plug-in and circuit protected for each fuse or breaker. fuses. Always replace fuses with those of the same amperage rating. The fuse panel is on the right-hand side of the power converter.

  • Page 63: Plumbing

    SECTION 7 PLUMBING FRESH WATER SYSTEM The fresh water system provides water to the galley sink, shower, bathroom lavatory, toilet and water heater. Water may be supplied by either of two sources: • a fresh water tank and water pump located within the motor home, or •...

  • Page 64: Water Pump

    SECTION 7 PLUMBING D-Series Class-A 2. Turn Fresh Water Valve to Normal position These devices simply connect in-line between and turn the water pump switches OFF. the supply hose and the city water input on the coach. Water pressure regulators are commonly available at any well stocked RV dealership and many large retail discount or home supply centers.

  • Page 65: Disinfecting Your Fresh Water System

    SECTION 7 PLUMBING D-Series Class-A Initial Water Line Priming Unscrew bowl and remove to clean strainer 1. Make sure that all water drain valves are closed, including water heater valve. 2. Turn water pump switch to “OFF” position. 3. Fill water tank. 4.
  • Page 66 SECTION 7 PLUMBING D-Series Class-A These models require temporarily connecting 2. Fill the tank completely, then open each an external cartridge type water filter assembly faucet in the coach and run the water until a in-line between the city water hose and the city distinct odor of chlorine can be detected in water fill to add disinfecting solution to the tank.

  • Page 67: Shower Hose Vacuum Breaker

    SECTION 7 PLUMBING D-Series Class-A SHOWER HOSE VACUUM TOILET BREAKER The toilet in your motor home is very similar to the household type, except that it is designed to After using the shower, you may notice water use only a small amount of water per flush. It dripping from the shower faucet assembly.

  • Page 68: Dumping Holding Tanks

    SECTION 7 PLUMBING D-Series Class-A The black water holding tank contains the NOTE:DO NOT OPEN BOTH VALVES AT sewage from the toilet and may include bathroom ONCE. Do not open the gray tank valve lavatory on some models. The gray water holding until the black tank is drained and dump tank contains the waste water from the galley valve closed to avoid sewage back-up...

  • Page 69: Water Line And Tank Drain Valves

    SECTION 7 PLUMBING D-Series Class-A Holding Tank Level Indicators See “Systems Monitor Panel” in Appliances section for further information on the monitor panel and checking tank levels. See “Specifications” in Introduction section for Tank Capacities for your model. WATER LINE AND TANK DRAIN VALVES The water drain valves are used to drain water from the water tank and the water supply lines...

  • Page 70: Water Heater Bypass Valve

    SECTION 7 PLUMBING D-Series Class-A inlet and gently press the backflow valve WATER HEATER BYPASS “button” in the center of the inlet to drain any VALVE water trapped in the inlet line. 4. Turn on water pump and open all sink faucets Your coach may be equipped with a water and shower head knobs.
  • Page 71 (A “blow-out” convenience in winterizing fresh water lines. plug can be purchased at any Winnebago or The system features a diverter valve with Itasca dealer. P/N 701705-01-000.) suction tube to draw non-toxic RV water system antifreeze into the water lines.
  • Page 72 SECTION 7 PLUMBING D-Series Class-A • Close dump valves and refit the dust cap onto the drain outlet. Siphon Tube Final Steps for “Blow-Out” or (insert into container of “Water System Antifreeze” RV water Procedure system antifreeze) 1. Close all drain valves and faucets to avoid contamination by dirt or insects.

  • Page 73: Water System Drain Valve Locations

    SECTION 7 PLUMBING D-Series Class-A WATER SYSTEM DRAIN VALVE LOCATIONS Model System Drain Valve Locations 30B, 33T & 35J Water Lines Open exterior shower faucet and lay shower head on ground. Also place the tip of your finger inside the city water connection and gently press the backflow valve (small “button”...
  • Page 74 SECTION 7 PLUMBING D-Series Class-A WATER SYSTEM DRAIN VALVE LOCATIONS Model System Drain Valve Locations 26P & 29R Water Lines Inside utility compartment in passenger side rear cargo compartment. See photo below. Water Tank Large yellow-handled valve in utility compartment. See photo below.

  • Page 75: Entertainment

    SECTION 8 ENTERTAINMENT To Watch VCR (if self-installed) VIDEO SELECTION SYSTEM • Press VCR button on MAIN TV section of –If Equipped Video Selection System panel. To Watch Rear/Bedroom TV (if equipped) • Video selection for the rear TV is similar to front TV viewing except all selections are made with buttons in the TV2 grouping.

  • Page 76: Dvd Home Theater System

    SECTION 8 ENTERTAINMENT D-Series Class-A • Volume is adjusted with the DVD remote (or DVD HOME THEATER SYSTEM volume control on DVD player). –If Equipped TV Sound through Theater Speakers When watching TV programs (broadcast, cable or satellite), the TV normally plays sound through its own built-in stereo speakers.

  • Page 77: Flip-Down Screen Video Players

    SECTION 8 ENTERTAINMENT D-Series Class-A • Volume is adjusted with the TV remote or FLIP-DOWN SCREEN VIDEO volume buttons. PLAYERS Set TV Video Input (Rear Bunk models only) • Turn On both TV and –If Equipped DVD player The flip-down LCD screen TV/DVD Video •...
  • Page 78 SECTION 8 ENTERTAINMENT D-Series Class-A • See Video Player instruction guide in your • When the main menu screen appears, press InfoCase for remote control instructions and button on the player or PLAY ENTER additional information on wireless button on the remote control to begin playing headphones.

  • Page 79: Rear Bedroom Tv 12-Volt Power Switch

    SECTION 8 ENTERTAINMENT D-Series Class-A • See Video Player instruction guide in your InfoCase for more information. Reading Lights • Slide switch to either position to turn DOOR* reading lights on. REAR BEDROOM TV 12-VOLT POWER SWITCH 300-Watt DC-AC Power Inverter –If Equipped •...

  • Page 80: Tv Signal Amplifier

    SECTION 8 ENTERTAINMENT D-Series Class-A Raising Antenna to Operating Position Turn elevating crank clockwise in “UP” CAUTION direction until some resistance to turning is noted (about 13 turns). Antenna is now in operating Always align directional handle to position. “DOWN” position before lowering. Turn amplifier power switch “ON”...

  • Page 81: Cable Tv Hook Up

    SECTION 8 ENTERTAINMENT D-Series Class-A An indicator light will glow when the switch Exterior Connection for Satellite is on and the signal amplifier is active. Dishes and Cable TV (In Utility Compartment) TV Signal Amplifier Switch on Video Selection System – if equipped NOTE:For coaches without the video selection Cable TV Hook-Up system, be sure the TV antenna amplifier...

  • Page 82: Exterior Entertainment Center

    SECTION 8 ENTERTAINMENT D-Series Class-A Further Information Please read the manufacturer’s operating information in your InfoCase for operation of Radio/CD player. Digital Satellite Dish Control located on ceiling We recommend that you read the satellite dish manual thoroughly to understand the system completely before attempting any setups or adjustments.

  • Page 83: Furniture & Softgoods

    SECTION 9 FURNITURE & SOFTGOODS SWIVEL GLIDER LOUNGE CHAIR –If Equipped This chair is not equipped with a seat belt and is not intended for seating while the coach is in motion. The chair has a glide-lock mechanism to prevent chair movement while the coach is moving.

  • Page 84: Couch/Bed Conversion

    SECTION 9 FURNITURE & SOFTGOODS D-Series Class-A 2. Remove the table from the wall support COUCH/BED CONVERSION bracket by lifting the end of the table. Then lower the table to rest on the cleats attached to Couch to Bed: each dinette bench. Lift the front edge of the couch seat upward and pull outward from the wall while gently pushing downward on the backrest until the...

  • Page 85: Day/Nighter Pleated Blinds

    Bracket –If Equipped People are drawn to the natural beauty of wood. At Winnebago Industries, our craftsmen work with the art found in each piece of wood to 2. Make sure that the table leg is secured into the create cabinets of superior quality, backed by the floor support bracket and the leg brace is Winnebago Industries warranty.
  • Page 86 SECTION 9 FURNITURE & SOFTGOODS D-Series Class-A No matter which species you choose for your new Winnebago Industries motorhome cabinetry, please keep in mind that no two pieces of wood are exactly the same. Stains are likely to exaggerate the difference between open and closed grains and other markings in wood.

  • Page 87: Slideout / Leveling

    SECTION 10 SLIDEOUT / LEVELING to withstand the force exerted by the room SLIDEOUT ROOM OPERATION extension mechanism and will not prevent – ELECTRIC accidental extension of the room. The travel strap is located near the floor at the Slideout rooms provide a spacious living area front end of the slideout room.
  • Page 88 SECTION 10 SLIDEOUT / LEVELING D-Series Class-A Extend Procedure: • Flip buckle downward and press toward strap until it “snaps” snugly into place against the See “Before Extending!” before proceeding. strap. • Start the engine so the alternator can provide •...

  • Page 89: Slideout Room - Extreme Weather Precaution

    SECTION 10 SLIDEOUT / LEVELING D-Series Class-A Retract Procedure: • The circuit breaker may be tripped. The circuit breaker, labeled ‘Slideout Power’ is See “Before Retracting!” before proceeding. located on a panel on an interior wall of the • Start the engine so the alternator can provide passenger side storage compartment just maximum power for proper operation of behind or ahead of the entrance door.
  • Page 90 SECTION 10 SLIDEOUT / LEVELING D-Series Class-A Manual Mode: Green light will flash error code, Manual Mode lets you individually move the if system malfunctions two room arms by pressing the IN and OUT buttons on the control pad. This mode can be used only if there is not a motor failure or full electrical system failure.

  • Page 91: Slideout Emergency Retraction - Electric

    SECTION 10 SLIDEOUT / LEVELING D-Series Class-A the other. The most effective way to retract the SLIDEOUT EMERGENCY room using a single person is to crank one side RETRACTION – ELECTRIC ahead of the other, then crank the other side in (“walk”...

  • Page 92: General Slideout Care

    SECTION 10 SLIDEOUT / LEVELING D-Series Class-A the bed, remove the access cover to access the gear endshaft, and continue using the wrench and hex shaft only as shown. 3. Attach the shaft extension to hex-end shaft and place the ratchet wrench onto the hex end shaft, then insert into the hole in the bed base as shown.

  • Page 93: Leveling System

    SECTION 10 SLIDEOUT / LEVELING D-Series Class-A LEVELING SYSTEM WARNING –If Equipped The hydraulic leveling system control pad is located on the lower left side of the dash. Keep all people clear of the coach while the leveling system is operating. The leveling system makes selecting a parking site easier and faster by reducing the effect of •...
  • Page 94 SECTION 10 SLIDEOUT / LEVELING D-Series Class-A These switches allow you to extend or retract NOTE:If the leveling jacks should fail to retract, your jacks and observe them at the same time. It see “Troubleshooting” and “Control also allows you to stop them suddenly, if needed, Panel Jumper Instructions”...

  • Page 95: Maintenance/Storage

    • Have the sealant replaced if you notice any of seams, etc., should also receive immediate the above. Your local Winnebago Industries attention. Delaying these repairs may allow water dealer has the correct and necessary parts and leakage and result in damage to interior ceiling experience to help you maintain your sealants.

  • Page 96: Underbody

    SECTION 11 MAINTENANCE/STORAGE D-Series Class-A the fallout and neutralize the acid. After the UNDERBODY initial 60-day cure stage, a coat of wax or polish can help protect the surface from these Buildup of mud and dirt under the body can types of contaminates.
  • Page 97 SECTION 11 MAINTENANCE/STORAGE D-Series Class-A Bug Removal under heavy pressure. They are designed to clean heavy road films on semi trailers • Rinse the loose debris off with water and and are often dirty. They are not designed allow the remaining residues to soak and for custom painted RV’s and they will soften.

  • Page 98: Care Of Appliques And Decals

    SECTION 11 MAINTENANCE/STORAGE D-Series Class-A CARE OF APPLIQUES AND DECALS CAUTION The pressure-sensitive appliques and decals on your coach require very little maintenance. DO NOT use citrus based cleaners on They should be treated like any painted surface polycarbonate finishes. on your vehicle.

  • Page 99: Interior Soft Goods

    SECTION 11 MAINTENANCE/STORAGE D-Series Class-A spotting. Avoid harsh and excessive rubbing INTERIOR SOFT GOODS while cleaning. Soft leather needs delicate care. We recommend a weekly routine of vacuuming all fabrics and carpet throughout the • Never use harmful substances (e.g. stain motor home to prevent an accumulation of dirt removers, solvents, saddle soap, shoe polish which can detract from the appearance and...

  • Page 100: General Stains

    SECTION 11 MAINTENANCE/STORAGE D-Series Class-A Detergent/ Cleaner/ Type of Stain Water Degreaser Coffee, Tea Red Wine, Liquor Cola, Soft Drinks Milk Ketchup Steak/Soy Sauce Mayonnaise, Butter Salad Oil Chocolate Cosmetic Makeup Lipstick Face Cream Suntan Oil/Lotion Shoe Polish Urine Machine Oil Vinyl Fabrics (including ceiling) –If Equipped Vinyl should be cleaned with a soft, damp...

  • Page 101: Ceiling Fabric Care

    SECTION 11 MAINTENANCE/STORAGE D-Series Class-A Most commercially available carpet and CEILING FABRIC CARE upholstery cleaners will do an excellent job removing stains. From time to time, additional While using your coach, your ceiling fabric cleaning methods may need to be used to remove may become soiled and require spot cleaning stubborn or difficult stains.

  • Page 102: Cabinetry

    SECTION 11 MAINTENANCE/STORAGE D-Series Class-A Steam cleaning is also an option. Again, take care not to over-saturate the material. REMEMBER, this is polypropylene—basic plastic—so do not be afraid to clean it. CABINETRY Wooden items may be cleaned with a soft cloth and a good quality wood finish cleaning product.

  • Page 103: Range And Refrigerator

    SECTION 11 MAINTENANCE/STORAGE D-Series Class-A To tighten tension RANGE AND REFRIGERATOR Wrap the lower end of the guide cords (on For care and appearance maintenance of the each side of the shade) a few turns around the range and refrigerator, refer to the operation and spools at the lower corners of the blinds.

  • Page 104: Removal From Storage

    SECTION 11 MAINTENANCE/STORAGE D-Series Class-A Clean and Prep Coach for Storage materials and compounds can be purchased from your dealer. Badly damaged weather 1. Turn off the propane gas tank seals may need to be replaced by your dealer. 2. Turn the furnace thermostat switch OFF. 10.
  • Page 105 SECTION 11 MAINTENANCE/STORAGE D-Series Class-A 12. Check around all appliances for obstructions and ensure that all vent openings are clear. 13. Start refrigerator and check for proper cooling. 14. Clean wall and counter surfaces. 15. Replace batteries if necessary and check out electrical system to make sure all lights and electrical components operate.

  • Page 106: Coach Maintenance Chart

    SECTION 11 MAINTENANCE/STORAGE D-Series Class-A COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System Have propane gas system checked for leaks.
  • Page 107 SECTION 11 MAINTENANCE/STORAGE D-Series Class-A COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items Headlights, Taillights and Marker Lights Turn Signals...
  • Page 108 SECTION 11 MAINTENANCE/STORAGE D-Series Class-A COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants Inspect (see “Sealants” at the beginning of this section for proper inspection technique) Replace (see “Recommended Sealant Application”...

  • Page 109: Recommended Sealant Application

    SECTION 11 MAINTENANCE/STORAGE D-Series Class-A RECOMMENDED SEALANT APPLICATION 11-15...

  • Page 111: Miscellaneous

    SECTION 12 MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motor home’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available CAUTION space when loading your motor home.
  • Page 112 SECTION 12 MISCELLANEOUS D-Series Class-A chairs, etc., a full fuel tank, full propane tank, and You will receive a weight ‘ticket’ that states a partial tank of fresh water - but empty holding your current Front Gross Axle Weight, Rear tanks.

  • Page 113: Car Or Trailer Towing

    SECTION 12 MISCELLANEOUS D-Series Class-A When the front wheel has been weighed, pull CAR OR TRAILER TOWING the coach straight ahead until only the right rear wheel/dual set is on the scale pad as shown. Hitch pulling capacity: 5,000 lbs. max. Tongue weight 350 lbs.

  • Page 114: Trailer Wiring Connector

    SECTION 12 MISCELLANEOUS D-Series Class-A WARNING For safe towing and vehicle handling, maintain proper trailer weight distribution. The total weight of the motor home and the vehicle towed must not exceed the Gross Combined Vehicle Weight rating. See the “Body and Chassis Specification” chart in the Introduction Section.

  • Page 115: Electric Entrance Step

    The step is equipped with an automatic are independent of towing vehicle ratings.) retraction feature that stores the step NOTE: All Winnebago Industries models automatically when the Ignition Switch key is equipped with a Class 4 hitch have a turned to the On or Start positions and the label stating vertical tongue load is entrance door is closed.

  • Page 116: Power Roof Ventilator

    SECTION 12 MISCELLANEOUS D-Series Class-A Vertical Slider Windows WINDOWS Vertical windows have spring-loaded catches on both sides of the window that pop out to hold Crank-Out Windows the window in its fully raised position. Press the Turn the crank-out knob clockwise to open catches outward toward the frames while window;...

  • Page 117: Storage Compartment Doors

    SECTION 12 MISCELLANEOUS D-Series Class-A To Operate Ceiling Ventilator TOOL AND LADDER STORAGE 1. Turn the Dome Crank Knob to raise the dome The roof ladder extension and various about 3" or more to allow the turbine fan to supplied tools are stored in clips on the walls of operate.

  • Page 118: Roof Ladder

    SECTION 12 MISCELLANEOUS D-Series Class-A • Be aware that the vehicle may sway as you climb the ladder. Do not use the ladder in high winds. • As you climb the ladder, grasp the side rails firmly and always use both hands. Keep your body centered between the side rails.

  • Page 119: Effects Of Prolonged Occupancy

    SECTION 12 MISCELLANEOUS D-Series Class-A EFFECTS OF PROLONGED OCCUPANCY Your motor home was designed primarily for recreational use and short term occupancy. If you expect to occupy your coach for an extended period, be prepared to deal with condensation and humid conditions that may be encountered.
  • Page 121 INDEX 120-Volt AC System ........6-1 Effects of Prolonged Occupancy ....12-9 120-Volt Circuit Breakers ......6-3 Electric Entrance Step ........ 12-5 120-Volt Receptacles (Outlets) ....6-4 Electrical Cautions ........6-1 12-Volt DC System ........6-6 Electrical Generator ........6-5 12-Volt House Fuses and Circuit Breakers ..
  • Page 122 Index D-Series Class-A Over-Drive Switch ........3-7 Slideout Room – Extreme Weather Precaution ....10-3 Owner Information ........1-6 Slideout Room Operation – Electric ..10-1 Plastic Parts - Cleaning ......11-4 Slideout Room Troubleshooting – Electric 10-3 Power Center ..........6-2 Smoke Alarm ..........

Table of Contents