1. Manuals
  2. Brands
  3. Winnebago Manuals
  4. Motorhomes
  5. 2004 Itasca Sunstar
  6. Owner's manual

Winnebago 2004 Itasca Sunstar Owner's Manual

Winnebago 2004 itasca sunstar motorhome owner's manual
Hide thumbs
Table of Contents

Advertisement

Quick Links

Congratulations! We welcome you to the exciting world of motor home travel and camping. You will
find it convenient and enjoyable to have all the comforts of home and still enjoy the great outdoors
wherever you choose to go.
Your motor home has been carefully designed, engineered and manufactured to provide dependability
as well as safety. Before sliding into the driver's seat, take a few minutes to become familiar with opera-
tions and features. This manual was prepared to aid you in the proper care and operation of the vehicle and
equipment. We urge you to read it completely. In addition, spend some time with the dealer when you take
delivery, you will want to learn all you can about your new motor home.
Your new motor home is covered by a factory warranty against defects in material and workmanship.
This warranty should be validated at once and returned to the factory by your dealer.
Read and understand all instructions and precautions in this manual before operating your new motor
home.
About Safety Messages Used in This Manual
Throughout this manual, certain items are labeled Note, Caution, Warning or Danger. These terms alert
you to precautions that may involved damage to your vehicle or a risk to your personal safety. Read and
follow them carefully.
This SAFETY ALERT SYMBOL is used to draw your attention to issues which could involved
potential personal injury. This symbol is used throughout this manual and/or on labels affixed
on or near various equipment in this motor home.
DANGER
DANGER indicates a directly hazard-
ous situation which, if not avoided,
will result in death or serious personal
injury.
.
WARNING
WARNING indicates a potentially
hazardous situation which, if not
avoided, could result in death or seri-
ous personal injury.
May 2003
TO THE OWNER
132000-21-004

Advertisement

Table of Contents
loading

Related Manuals for Winnebago 2004 Itasca Sunstar

Summary of Contents for Winnebago 2004 Itasca Sunstar

  • Page 1 TO THE OWNER Congratulations! We welcome you to the exciting world of motor home travel and camping. You will find it convenient and enjoyable to have all the comforts of home and still enjoy the great outdoors wherever you choose to go. Your motor home has been carefully designed, engineered and manufactured to provide dependability as well as safety.
  • Page 2 CAUTION CAUTION indicates a potentially hazardous situation which, if not avoided, could result in damage mainly to equipment or property, but in some cases may also result in minor or moderate personal injury. NOTE: A ‘Note’ is not necessarily safety related but indicates a recommendation or special point of information that could assist in understanding the use or care of a feature item.
  • Page 3 OWNER’S NAME STREET ADDRESS CITY AND STATE (OR PROVINCE IN CANADA) MOTOR HOME SERIAL NUMBER VEHICLE CHASSIS IDENTIFICATION NO. (VIN) DATE OF DELIVERY TO FIRST RETAIL PURCHASER VEHICLE MILEAGE AT TIME OF DELIVERY SELLING DEALER NAME AND ADDRESS TANK CAPACITIES Chassis Fuel Tank......................21 gal.

  • Page 5: New Vehicle Limited Warranty

    RV manufacturer (Winnebago Industries) and the chassis manufacturer (Volkswagen of America, Inc.). The Coach Body portion of your motor home is warranted by Winnebago Industries for 1 year or 15,000 miles. This includes the coach section exterior, interior and RV equipment. In addition, there is a 3 year or 36,000 mile structural warranty.
  • Page 7 2004 SUNSTAR NEW VEHICLE LIMITED WARRANTY WINNEBAGO INDUSTRIES, INC. − WARRANTY COVERAGE TO OWNER Rear Suspension and axle components including wheel Winnebago Industries, Inc. of Forest City, Iowa warrants each new bearings. â − Itasca Sunstar motor home to the owner for use in the U.S.A. and Exhaust system rearward of the catalytic converter −...
  • Page 8 CUSTOMER RESPONSIBILITY WHEN REPAIRS ARE NEEDED other place of business, or by any other party other than Winnebago If a part of the system covered by this warranty fails to function or Industries, Inc.
  • Page 9 Winnebago Industries or its authorized dealer before making any claim under that section of the law. If you do have problems with your motor home, you should provide written notice to Winnebago Industries at the following address: Winnebago Industries, Inc. P.O. Box 152...
  • Page 10 This warranty does not cover damage or malfunctions resulting placed in service by a Winnebago Industries dealer as a from improper repair of the vehicle, improper installation of “demonstrator”...
  • Page 11 • intentional or unintentional misfueling, use of the vehicle in This warranty does not cover powertrain components which competitive events or damage caused by accident or fire. malfunction due to normal wear and tear, use or deterioration. Damage or Malfunction Due to Lack of Maintenance Refer to Limited New Vehicle Warranty For Other Warranty This warranty does not cover damage or malfunctions caused by Terms...
  • Page 12 warranty which Volkswagen should pay for in part or in Caution whole, please call us at 1-800-822-8987. Your request should provide the vehicle identification number of the These bulletins are intended for qualified technicians. They are vehicle, mileage, maintenance history not meant for the CASUAL do-it-yourselfer.
  • Page 13 Emissions Warranties. MIL Bulb Emissions-Related Hoses, Gaskets, Clamps and Other The owner of a new Winnebago vehicle sold in states other than Accessories Used on the Above Components California, Massachusetts, Vermont, and Maine has rights only under the Federal Emissions Warranties.
  • Page 14 • used in the maintenance or repair of the vehicle if Winnebago contaminated fuel or fuel not meeting the specifications set forth Industries non-certified part is either defective in materials or in your Owner’s Manual was used.
  • Page 15 30 days. miles will be covered in the same manner as above. As the vehicle owner, you should also be aware that Winnebago Additional Information About the California Emissions Control Industries may deny you warranty coverage if your vehicle or a part...
  • Page 16 If you are not notified within 30 days that a performance warranty claim is not valid, then Winnebago Industries is required to repair the Warranty Coverage for Parts Not Scheduled for Inspection or vehicle free of charge.
  • Page 17 In the event of a service action, Winnebago Industries will notify you by mail and request you to bring your vehicle to your nearest dealer for repair free of charge. If you...

  • Page 19: Table Of Contents

    TABLE OF CONTENTS Radio/Cassette Player ........2- 8 INTRODUCTION About This Manual ........0- 1 Auxiliary Start Switch ........2- 8 Chassis Operating Guide ......0- 1 SECTION 3: IN CASE OF DRIVING Owner’s InfoCase ......... 0- 1 EMERGENCY Before Driving ..........0- 2 Hazard Warning Flasher .......
  • Page 20 TABLE OF CONTENTS Converter Charger......... 6- 3 Overhead Front Bunk........8- 10 Thermal Breaker ........... 6- 3 Couch/Bed Conversion ....... 8- 10 110-Volt Circuit Breakers......6- 3 Dinette/Bed Conversion......8- 11 110-Volt Receptacles (Outlets)..... 6- 4 Fresh Water Toilet ........8- 11 Auxiliary 110-Volt Generator.......

  • Page 21: Introduction

    INTRODUCTION Congratulations on the purchase of your new This manual should be kept in the vehicle at all times for personal reference. The operator’s Sunstar motor home, which has been carefully manual, I and chassis operating guide designed, engineered and quality built by Win- are to be considered permanent components of nebago Industries, Inc.

  • Page 22: Before Driving

    If you need warranty repairs while traveling you may take your motor home to any Winnebago or Itasca dealership and they will assist you. BEFORE DRIVING Before sitting in the driver’s seat, always...

  • Page 23: Reporting Safety Defects

    National Highway Traffic Safety Administration (NHTSA) in addition to notifying Winnebago Industries, Inc. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign.

  • Page 24: Vehicle Certification Label

    (listed in pounds and kilograms). signifies a Multi-purpose Passenger Vehicle. 6. Suitable Tire Choice: Tires recommended to 13. Model: Lists the Winnebago product model meet handling and safety requirements. number of your vehicle. When replacing any of the tires on your 14.

  • Page 25: Exterior Feature Identification

    INTRODUCTION EXTERIOR FEATURE IDENTIFICATION Typical model shown for illustration purposes only. Actual locations of features depends on your model and option combinations Refrigerator Roof Air Furnace Refrigerator Exhaust Vent Conditioner Intake/Exhaust* Service Access Entrance Storage Water Heater Aux. Exterior Fresh Water Step Compartment Service Access*...

  • Page 27: Section 1: Safety Precautions

    SECTION 1 SAFETY PRECAUTIONS NOTE: A ‘Note’ is not necessarily safety related Read and understand all instructions and pre- but indicates a recommendation or special point cautions in this manual before operating your of information that could assist in understanding new motor home.

  • Page 28: Fuel & Lp Gas

    SECTION 1 SAFETY PRECAUTIONS · Avoid inhaling exhaust gases produced by burned gasoline, diesel fuel or LP gas in items such as the range, chassis engine, gen- erator engine, refrigerator, furnace and water DRIVING heater. They contain carbon monoxide, which is an odorless, colorless and poisonous ·...

  • Page 29: Lp Gas Leaks

    SECTION 1 SAFETY PRECAUTIONS · The following warning label is located in the cooking area to remind you to provide an ad- LP GAS ALARM equate supply of fresh air for combustion. Your coach is equipped with an LP gas detec- tor which sounds an alarm if an unsafe amount of WARNING LP gas is present inside the coach.

  • Page 30: Power Connection

    SECTION 1 SAFETY PRECAUTIONS If the alarm keeps sounding at regular inter- power converter breaker panel shown in section vals, a leak may be present. Contact your dealer or an LP gas service center to have the problem Because the LP gas alarm is connected direct- corrected before using the LP system again.

  • Page 31: Loading

    SECTION 1 SAFETY PRECAUTIONS · Use caution when handling or working near · Do not attempt to start the vehicle by hot electrical storage batteries. Always remove wiring. jewelry and wear protective clothing and eye covering. Avoid creating sparks. FORMALDEHYDE INFORMATION WARNING LOADING Some components in this vehicle con-...

  • Page 32: Carbon Monoxide Alarm

    SECTION 1 SAFETY PRECAUTIONS recommended that the exhaust system and body be inspected by a qualified motor home service center. · Each time the vehicle is raised for an oil change. · Whenever a change in the sound of the ex- haust system is noticed.

  • Page 33: Fire Extinguisher

    SECTION 1 SAFETY PRECAUTIONS window glass open, then slide the screen open We also recommend that you inspect the fire too. extinguisher for proper charge at least once a month in accordance with National Fire Protec- tion Association (NFPA) recommendations as stated on the label.
  • Page 34 SECTION 1 SAFETY PRECAUTIONS 2. Your smoke alarm will not work without power. Never remove the battery to quiet the alarm. When your smoke alarm “beeps” about once a minute the battery is weak. Install a new battery immediately. Be sure to use only batteries specified in manual or on unit.

  • Page 35: Before Entering Your Vehicle

    SECTION 2 DRIVING YOUR MOTORHOME (See also Safety Precautions, Section 1 of this 7. Unhook and store sewer and water supply manual.) hoses. 8. Retract step. NOTE: See your Volkswagen chassis Owner's 9. Be sure that all of your cargo is secured Manual or Quick Reference Guide for before traveling.

  • Page 36: Keys

    REPLACEMENT FUEL CAPS To protect gasoline system from excessive pressure or vacuum, or from sudden pressure, re- place lost caps with caps of the same design available from your Winnebago Industries prod- uct dealer or a Volkswagen dealership.

  • Page 37: Starting And Stopping Engine

    SECTION 2 DRIVING YOUR MOTOR HOME ward. To open the door from inside, pull outward STARTING AND on the door handle. When the door is locked, nei- STOPPING ENGINE ther the inside nor the outside door handle can be operated. Refer to your Volkwagen Owner’s Manual recommendations on starting and stopping the Keyless Entry...

  • Page 38: Entrance Steps

    SECTION 2 DRIVING YOUR MOTOR HOME DRIVER COMPARTMENT DOOR Deadbolt LOCKS Consult your Volkswagen Owner’s Manual. ENTRANCE STEPS Manual Step To extend the entrance step, lift up on the front of the step and pull out until it drops into posi- tion.

  • Page 39: Seats

    SECTION 2 DRIVING YOUR MOTOR HOME CAUTION Always remember to retract the entrance steps before traveling or moving the vehicle. SEATS The driver and co-pilot seats may be indepen- dently adjusted to suit individual preference. Seat Position Adjustment Bar To recline the seats: Turn the reclining knob (Lift to slide forward - back) rearward until seat back is in desired incline.
  • Page 40 SECTION 2 DRIVING YOUR MOTOR HOME Lap-Shoulder Belt Fastening: Hold the belt just behind the tongue using the hand nearest to the door. Next, bring the belt across the body and slide the tongue into the buckle until the latch engages. Unfastening: Press the release button in the buckle.

  • Page 41: Child Restraints

    SECTION 2 DRIVING YOUR MOTOR HOME To Adjust Mirrors Press one of the Mirror Selection Buttons - CHILD RESTRAINTS · Press the L (left) Mirror Selection Button to adjust the driver side mirror. All 50 of the United States and the District of ·...

  • Page 42: Comfort Controls

    SECTION 2 DRIVING YOUR MOTOR HOME STEERING COLUMN CONTROLS Aux. Start Switch See your Volkswagen Owner’s Manual or Quick Reference Guide for all controls located on the steering column or steering wheel. WARNING Do not operate the cruise control on icy or extremely wet roads, winding roads, in heavy traffic, or in any other traffic situation where a constant...

  • Page 43: Section 3: In Case Of Driving Emergency

    SECTION 3 IN CASE OF DRIVING EMERGENCY • Set the parking brake. HAZARD WARNING • Turn on the hazard warning flashers. FLASHER • See your Volkswagen Owner’s Manual for specific tire changing instructions and pre- The hazard warning flasher provides addi- cautions.

  • Page 44: Tire Changing

    DO NOT crawl under the vehicle when it is supported by a jack. RECOVERY TOWING See Volkswagen Owners Manual for proper recovery towing procedures. Winnebago Industries does not assume re- sponsibility for damage incurred while towing this vehicle.

  • Page 45: Jump Starting

    SECTION 3 IN CASE OF DRIVING EMERGENCY CONNECTING JUMPER WARNING CABLES 1. Make sure that the other vehicle has a 12- Stay out from beneath the motor volt battery and negative ground compatible home while it is suspended by the with your vehicle’s electrical system.

  • Page 46: Connecting A Battery Charger

    SECTION 3 IN CASE OF DRIVING EMERGENCY 9. Reverse the above sequence EXACTLY WARNING when removing the jumper cables. Start by removing the cable from the ground location on the engine first, then continue in reverse Operating a vehicle under a severe sequence.
  • Page 47 SECTION 3 IN CASE OF DRIVING EMERGENCY overheat. Check hose connections and tighten if necessary. Make sure there are no broken belts, pulleys or hoses before adding any coolant to the radiator. For further information in case of overheat- ing, consult your chassis operating guide.

  • Page 49: Loading The Vehicle

    SECTION 4 TRAVELING WITH YOUR MOTORHOME (See also SAFETY PRECAUTIONS, Section NOTE: We recommend that you dump all hold- 1 of this manual.) ing tanks before traveling to avoid car- rying unnecessary weight. LOADING THE CAUTION VEHICLE The weight of the loaded vehicle NOTE: Your motor home’s load capacity is des- (including options, attachments, pas- ignated by weight, not by volume, so you...
  • Page 50 SECTION 4 TRAVELING WITH YOUR MOTOR HOME Weigh Stations, etc. If you cannot locate a scale Label on the rear inner jamb of the drivers door. in your area, call your state DOT and ask for rec- (see Section 0) The front and rear axle weight ommendations.

  • Page 51: Maximum Occupancy

    For safety towing and vehicle han- pancy, called Cargo Carrying Capacity (CCC). dling, maintain proper trailer weight To calculate the CCC, Winnebago uses vehi- distribution. cle sleeping capacity, however your coach may be equipped with more belted seating positions...

  • Page 52: Pre-Travel Checklist

    SECTION 4 TRAVELING WITH YOUR MOTOR HOME - Fire Extinguisher - Make sure it is fully charged and secured in mounting bracket. CAUTION - Lights - Make sure all exterior lights operate. - Sewer and Water Supply Hose - Unhook and Exceeding any of the recommended gross vehicle weight ratings may re- store.

  • Page 53: Severe Weather Information

    SECTION 4 TRAVELING WITH YOUR MOTOR HOME 5. Store liquids in plastic containers with tight the side view mirror frequently to observe fitting caps to prevent spills. how close you are driving to the center line. 6. Keep an eye on the water and holding tank levels.

  • Page 54: Nighttime Driving

    SECTION 4 TRAVELING WITH YOUR MOTOR HOME · During a flash flood, if you cannot move your When severe weather threatens, forecasters at vehicle, abandon it. Do not attempt to return the local National Weather Service office inter- to your vehicle before the water has receded. rupt the broadcasts with storm warnings, either recorded or “live”...

  • Page 55: Campsite Set-Up

    SECTION 4 TRAVELING WITH YOUR MOTOR HOME This is done by stacking various lengths of planking (blocks) into a ramp-like formation in a CAUTION low spot to drive the tire onto, thus leveling the coach as shown. Observe the engine temperature Wedge a pair of wheel chocks or similar de- gauge more frequently than normal.

  • Page 56: Humidity And Condensation

    SECTION 4 TRAVELING WITH YOUR MOTOR HOME HUMIDITY AND CONDENSATION Moisture condensing on the inside of win- dows is a visible indication that there is too much humidity inside the coach. Excessive moisture can cause water stains or mildew which can dam- age interior items such as upholstery and cabi- nets.

  • Page 57: Section 5: Lp Gas System

    SECTION 5 LP GAS SYSTEM · Have the entire LP gas system inspected for (See also Safety Precautions, Section 1 of this manual.) possible leaks and missing or damaged parts at each tank filling. Also inspect before and after each trip, and any time trouble is sus- pected.

  • Page 58: Selecting Lp Fuel Types

    SECTION 5 LP GAS SYSTEM cessible only from the outside of the vehicle. The SELECTING LP tank supply valve is located near the top center of FUEL TYPES the tank, next to the regulator. Before opening the supply valve, check to be sure all controls for gas We recommend using straight propane in your appliances are in the “Off”...

  • Page 59: Air In The Lp Gas Tank

    SECTION 5 LP GAS SYSTEM Since the LP tank is permanently mounted to the frame, the motor home must be taken to an LP WARNING dealership for filling. Do not attempt to remove the LP tank from the vehicle. The tank is equipped with a fill adapter with both internal DO NOT FILL CONTAINER TO and external threads which allows easy filling...

  • Page 60: Lp Gas Leaks

    SECTION 5 LP GAS SYSTEM WARNING If moisture begins to cause problems, have your LP gas dealer inject a small amount of dry methyl alcohol in your tank (approximately one Inspect the pressure regulator vent once to 20 pounds or one pint to 100 gallons) to hole periodically for blockage.

  • Page 61: Winter Use Of Lp Gas

    SECTION 5 LP GAS SYSTEM Percentage of BTU’s WARNING Temperature Available at 0° F. 20° F. 200% Never use an open flame to test for 10° F. 150% gas leaks. When testing for gas lines 0° F. 100% leaks with a soapy water solution, DO -5°...

  • Page 63: 110-Volt Ac System

    SECTION 6 ELECTRICAL SYSTEMS (See also Safety Precautions, Section 1 of this WARNING manual.) Your motor home is equipped with an electri- cal system consisting of two separate voltages; a Do not connect the external power 12-volt DC system and a 110-volt AC system. cord to any receptacle until you have The 12-volt system consists of two internal pow- contacted the owner and/or attendant...

  • Page 64: Power Center

    SECTION 6 ELECTRICAL SYSTEMS WARNING Do not plug the power cord into an outlet which is not grounded, or adapt the plug to connect to a receptacle for which it is not designed. Be sure that all three prongs of the supply cord are properly plugged into the receptacle.

  • Page 65: Converter Charger

    SECTION 6 ELECTRICAL SYSTEMS Power Center if the power converter becomes overheated. This can result from operating above its maximum limit for an extended period of time or by obstruction of ventilation to unit. NOTE: Power converter section will automati- cally route 12-volt lights and motors to battery power in this event.

  • Page 66: 110-Volt Receptacles (Outlets)

    SECTION 6 ELECTRICAL SYSTEMS The GFCI outlet is located in the bath, bed- 110-Volt 12-Volt room or dinette area, depending on the floor plan Circuit Breakers House Fuses of the vehicle. Push to Reset Push to Test Power Converter Further Information Refer to the converter manufacturer’s infor- mation provided in your InfoCase for additional information about your power converter system.

  • Page 67: Starting And Stopping The Generator

    SECTION 6 ELECTRICAL SYSTEMS Generator Switch WARNING Careless handling of the generator and electrical components can be fa- tal. Never touch electrical leads or appli- ances when your hand are wet, or when standing in water or on wet ground. Do not attempt to repair the generator yourself.

  • Page 68: Generator Hourmeter

    SECTION 6 ELECTRICAL SYSTEMS · Press the generator switch Off and hold until Generator Switch the generator engine comes to a complete stop. CAUTION Continuous generator overloading can cause high operating tempera- tures that can damage the generator windings. Keep the electrical loads within the generator wattage rating.

  • Page 69: 12-Volt Dc System

    SECTION 6 ELECTRICAL SYSTEMS Check auxiliary generator oil level frequently Automotive (Starting) Battery during periods of use. Refer to the generator The chassis battery is used solely to operate manufacturer’s information in your InfoCase for the engine starter and all automotive accessories specific recommendations.

  • Page 70: Battery Information

    SECTION 6 ELECTRICAL SYSTEMS To service or remove the batteries, unfasten 110-Volt 12-Volt the retainer strap and disconnect battery cables. Circuit Breakers House Fuses House Battery Storage (in floor behind front seats) Power Converter The fuse panel accepts only blade type plug-in fuses.
  • Page 71 SECTION 6 ELECTRICAL SYSTEMS Further precautions are: · Remove the battery from the coach. WARNING · Store it in a cool place on a wooden or rubber pad to inhibit conductive transfer. Before removing any battery cables or · Check the state of charge periodically to battery, make sure all 12-volt equip- avoid discharge or sulfating.

  • Page 72: Battery Condition Meter

    SECTION 6 ELECTRICAL SYSTEMS BATTERY CONDITION METER This meter allows you to check the level of charge in the house battery in your motor home. It is located on the monitor panel in the galley ar- ea. (See Section 8.) To obtain an accurate reading: 1.

  • Page 73: Section 7: Plumbing Systems

    SECTION 7 PLUMBING SYSTEMS constant flow from the tank. When the faucet is FRESH WATER closed, the pump automatically shuts off. SYSTEM WATER PUMP SWITCH The fresh water system provides water to the The water pump switch is located on the galley sink, shower, bathroom lavatory, toilet and monitor panel (See Section 8).

  • Page 74: Disinfecting Fresh Water

    SECTION 7 PLUMBING SYSTEMS DISINFECTING FRESH WATER EXTERNAL WATER SUPPLY (“City Water”) SYSTEMS ON RECREATION VEHICLES (As approved by the U.S. Public Health Service) To assure complete disinfection of your fresh water system, it is recommended that the follow- ing procedure be followed on a new system, one that has not been used for a period of time, or one that may have become contaminated.

  • Page 75: Shower Valve Pressure Bleed-Off

    SECTION 7 PLUMBING SYSTEMS To disconnect from the external source: 1. Turn the external source off. 2. Open a faucet inside the vehicle to relieve line pressure. 3. Disconnect the hose from the vehicle and replace the cap on the connection. SHOWER VALVE PRESSURE BLEED-OFF After using the shower, you may notice water dripping from the shower faucet assembly.

  • Page 76: Using On-Site Sewer Hook-Ups

    SECTION 7 PLUMBING SYSTEMS 5. Open the (large) black water tank valve with in suspension, allowing them to be carried out a quick pull. Move hose gently about to dis- with the liquids when the dump valve is opened. lodge any waste and to ensure complete If the valve is left open, the liquids will drain off, drainage.
  • Page 77 SECTION 7 PLUMBING SYSTEMS freeze into the water lines. This feature is located near the water pump and drain valves. See page CAUTION 7-6 for location in your coach. Leave by-pass valve handle in NORMAL FLOW position if drain- ing water and blowing out water lines.

  • Page 78: Holding Tank Capacities

    SECTION 7 PLUMBING SYSTEMS HOLDING TANK CAPACITIES HT1 - Black Water Holding Tank (Toilet & Lavatory) ............16 gal. HT2 - Grey Water Holding Tank (Galley & Shower) ............16 gal. WATER SYSTEM DRAIN VALVE LOCATIONS Winterizing Siphon Hose Water Tank Drain Closed Winterizing Valve and Water Tank Drain Valve Access in RH Storage Compartment Water Tank Drain Open...
  • Page 79 SECTION 7 PLUMBING SYSTEMS Water Heater Bypass Valve behind Access Panel beneath Bath Lavatory Vanity RV Antifreeze Winterizing Valve & Siphon Tube Hot and Cold Water Line Drains Pull to Drain Pull to Drain (in front of water service center) Gray Tank Black Tank Holding Tank Dump Valves...

  • Page 81: Refrigerator

    SECTION 8 APPLIANCES & INTERIOR FEATURES (See also Safety Precautions, Section 1 of position of the bubble in relation to the circle in top of the level. this manual.) NOTE: Some items described may be optional or unavailable on your coach. The appliances installed in your motor home are manufactured by reputable RV appliance makers and have been tested by independent lab-...
  • Page 82 SECTION 8 APPLIANCES & INTERIOR FEATURES OPERATING INSTRUCTIONS WARNING NORCOLD -N400 The refrigerator controls are located at the top front of the refrigerator. Do not hold gas valve in more than 30 The Lighting and Start-up Instructions are lo- seconds. If the flame is not indicated cated on the top portion of the interior door liner.

  • Page 83: Range And Oven

    SECTION 8 APPLIANCES & INTERIOR FEATURES Further Information See the Norcold operating instructions provid- RANGE AND OVEN ed in your Owner InfoCase for further informa- tion, including precautions and periodic The range and oven in your motor home are maintenance. operated on LP gas and will provide nearly all of the functions that the range in your home does.

  • Page 84: Operating Oven Control

    SECTION 8 APPLIANCES & INTERIOR FEATURES Be sure all valves are WARNING in the “OFF” Position. The oven control knob should be in “OFF” Portable fuel-burning equipment position. including wood and charcoal grills Turn on main gas sup- Oven Control Knob and stoves, should not be used inside ply to range.

  • Page 85: Microwave Oven

    SECTION 8 APPLIANCES & INTERIOR FEATURES MICROWAVE OVEN For complete operating instructions, refer to the manufacturer’s information provided with the oven. RANGE HOOD The range hood vent draws cooking odors and airborne grease particles into the filtration grid and recirculates the air or vents it to the outside of the coach depending on model.

  • Page 86: Water Heater

    SECTION 8 APPLIANCES & INTERIOR FEATURES * Green - good or adequate charge. * Yellow - marginal charge. * Red - battery needs charging before use. Water Heater Switch Be sure the water heater is filled with water before pressing this switch. To fill the water heat- er, turn the water pump switch on and open a hot water faucet until water begins to flow.

  • Page 87: Water Heater Pressure Temperature Relief Valve

    SECTION 8 APPLIANCES & INTERIOR FEATURES condition (“W.H. Pilot” light on). When Normally there is an air gap at the top of the water heater tank which acts as a pressure buffer. water cools, reset by placing switch in “Off” In time, however, heated water may expand and position for at least 30 seconds, then return fill this air gap, causing a slight increase in water...

  • Page 88: Lp Gas Furnace

    SECTION 8 APPLIANCES & INTERIOR FEATURES Normal By-Pass Flow Mode CAUTION 3. Furnace fan will start to blow immediately Leave by-pass valve handle in NOR- after setting thermostat. MAL FLOW position if draining 4. After about 30 seconds, the furnace burner water and blowing out water lines.

  • Page 89: Roof Air Conditioner

    SECTION 8 APPLIANCES & INTERIOR FEATURES alarm battery. If it were inadvertently left disconnected, the smoke alarm would be WARNING inoperative. Never allow the antenna to touch electrical power lines or any other ROOF AIR CONDITIONER electrical wires. Refer to the manufacturer’s information in your Owner InfoCase for complete operating in- structions.

  • Page 90: Tv Signal Amplifier

    SECTION 8 APPLIANCES & INTERIOR FEATURES CABLE TV-HOOK-UP CAUTION Always align directional handle to Some models are equipped with external con- “DOWN” position before lowering. nections for cable television. The connector is lo- cated in the shoreline cord compartment. NOTE: Be sure the TV antenna amplifier switch TV SIGNAL AMPLIFIER is turned OFF while connected to cable.

  • Page 91: Couch/Bed Conversion

    SECTION 8 APPLIANCES & INTERIOR FEATURES DINETTE/BED CONVERSION To Convert Dinette to Bed: 1. Release the catch on the table leg brace and fold the leg up against the bottom of the table. Shown with mattress stacked in stowed position COUCH/BED CONVERSIONS Continental Bed 2.

  • Page 92: Fresh Water Toilet

    SECTION 8 APPLIANCES & INTERIOR FEATURES To Revert to Dinette: Please refer to the manufacturer’s information supplied with the toilet for further operating and 1. Replace the table onto the wall support and maintenance instructions. lower the table leg. 2. Make sure that the table leg is secured into Important “Don’ts”...

  • Page 93: Power Roof Vent

    SECTION 8 APPLIANCES & INTERIOR FEATURES POWER ROOF VENT - Bath Area Some models are equipped with a powered roof vent in the bath area. A push button switch for the vent fan is located up on the vent. The vent dome can be raised and lowered using the crank handle.
  • Page 94 SECTION 8 APPLIANCES & INTERIOR FEATURES Carefully remove the clock from the socket by rotating to the left (counterclockwise) as shown. After replacing the battery, simply place the clock back into the socket with 12 at the 10 o’clock position and rotate upright. 8-14...

  • Page 95: Roof

    Always have damage to the roof arated. Resealing, if necessary, is quite simple. area repaired immediately. Damaged or detached Appropriate compounds are sold at Winnebago sealant around the vents, air conditioner, body- and Itasca dealers, and the materials are quickly to-roof seams, etc., should also receive immedi-...

  • Page 96: Care Of Stripes And Decals

    SECTION 9 CARE & MAINTENANCE home to prevent an accumulation of dirt which can detract from the appearance and shorten the lift of carpet and fabrics. Care of Stripes Carpet Care & Cleaning See the carpet manufacturer’s Carpet Care and Decals Guide in your InfoCase.

  • Page 97: Vinyl

    SECTION 9 CARE & MAINTENANCE Some stains or soils, such as lipstick, ink, TABLES AND COUNTERTOPS Work surfaces are covered with a plastic lam- grease or mustard, are extremely difficult or inate that resists solvents, stains and abrasions. A impossible to remove completely and should coat of furniture wax applied to these surfaces on receive immediate attention.

  • Page 98: Doors And Windows

    SECTION 9 CARE & MAINTENANCE The bathroom lavatory is also a molded plas- tic material and should be cleaned with a mild soap and water solution. Abrasive cleaners or harsh detergents should not be used. For instructions on the care of your fresh wa- ter toilet, refer to the information in your Owner InfoCase.

  • Page 99: Engine Cooling System

    SECTION 9 CARE & MAINTENANCE CAUTION When refilling the coolant system of a vehicle equipped with a rear auxil- iary automotive heater and motoraid water heater, be sure to allow for additional coolant capacity of the heater and its supply and return hoses.
  • Page 100 Replace tire only with one of exactly alternative light truck tires with a lower rating. same type and rating. DO NOT See your authorized Winnebago Industries replace with passenger car tire. See dealer or a Continental brand tire dealer for Operator’s Manual for details.

  • Page 101: Suspension Alignment And Tire Balance

    SECTION 9 CARE & MAINTENANCE Out-of-balance tires will not roll smoothly and WHEEL REPLACEMENT RECOMMEN- DATIONS can lead to annoying vibrations and uneven tread wear such as cupping and flat spots. Tires may Wheels must be replaced if they become dam- aged (i.e.

  • Page 102: Rear Air Springs

    SECTION 9 CARE & MAINTENANCE • Do not wash wheels that are very hot from recent use. • To increase the life of the finish on your Loading the Vehicle wheels, wax them regularly with a soft paste wax. NOTE: Your motor home’s load capacity is des- ignated by weight, not by volume, so you cannot necessarily use all available space when loading your motor home.

  • Page 103: Awning Installation

    See your Volkswagen Owner’s Manual for additional fuse replacement information. AWNING INSTALLATION NOTE: See your Winnebago or Itasca dealer for installation of awnings. Your dealer’s service department has information showing locations of awning bracket supports in the sidewall of the coach.

  • Page 105: Section 10: Storing Your Motor Home

    SECTION 10 STORING YOUR MOTOR HOME Close dump valves and refit the dust cap PREPARING VEHICLE FOR onto the drain outlet. STORAGE 2. Level the motor home and drain the entire Properly preparing your vehicle for storage plumbing system as described in the follow- will lessen the possibility of damage to your ing steps.
  • Page 106 Then use a compressed air hose regulated to 30 psi or less to force air through the system. (A “blow-out” plug can WARNING be purchased at any Winnebago or Itasca dealer. P/N 701705-01-000.) NEVER use automotive antifreeze/ coolant in your RV water system.

  • Page 107: Removal From Storage

    SECTION 10 STORING YOUR MOTOR HOME tainer to determine the correct 26. Fully charge batteries. amount to use for your coach. See 27. Batteries must be kept to at least 80% charge “Water System Winterization Valve” to keep from freezing or sulfating. We rec- in Section 7 for instructions on filling ommend that you connect a battery charger water lines with RV antifreeze.
  • Page 108 SECTION 10 STORING YOUR MOTOR HOME seals tightly. 10. Check around all appliances for obstructions and ensure that all vent openings are clear. 11. Start refrigerator and check for proper cool- ing. 12. Clean paneling and counter surfaces and apply a thin coat of wax. 13.
  • Page 109 INDEX 110-Volt AC System........6- 1 Cable TV-Hook Up........8- 10 110-Volt Circuit Breakers......6- 3 Campsite Set-Up ........... 4- 6 110-Volt Receptacles (Outlets)..... 6- 4 Carbon Monoxide Alarm ......1- 6 12-Volt DC System........6- 7 Carbon Monoxide Warning ......1- 5 12-Volt House Fuses and Circuit Breakers...
  • Page 110 INDEX Engine Cooling System ........ 9- 5 Hood Release Lever........9- 4 Engine Oil Dipstick ........9- 5 House Battery ..........6- 7 Engine Oil Fill Access ........9- 5 How LP Gas Works ........5- 1 Engine Overheat..........3- 4 Humidity and Condensation ......
  • Page 111 INDEX Seat Belts ............2- 5 Occupancy, Maximum........4- 2 Seats .............. 2- 5 Occupancy, Prolonged Effects...... 4- 7 Selecting LP Fuel Types ....... 5- 2 Oil Fill Access ..........9- 5 Service and Assistance........0- 2 Operating Oven Control........ 8- 4 Severe Weather Information......
  • Page 112 INDEX Vinyl Wallboard ........... 9- 3 Vinyl ............. 9- 3 Warranty ............0- 2 Waste Water System (Holding Tanks) ..7- 3 Water and Holding Tank Levels ....8- 5 Water Heater Bypass Valve ......7- 7 Water Heater By-Pass Valve ......8- 7 Water Heater Capacity........
  • Page 113 EMERGENCY INFORMATION Dealer Name _______________________________________________________________________ Address______________________________________________________________________ ____________________________________________________________________________ Phone _______________________________________________________________________ INSURANCE POLICY Company ____________________________________________________________________ Policy Number ________________________________________________________________ Phone _______________________________________________________________________...
  • Page 114 MAINTENANCE RECORD Odometer Date Mileage Description of Service Cost...
  • Page 115 FUEL & OIL RECORD Odometer Fuel Odometer Fuel Date Mileage Gal. Qts. Cost Date Mileage Gals. Qts. Cost...
  • Page 116 FUEL & OIL RECORD Odometer Fuel Odometer Fuel Date Mileage Gal. Qts. Cost Date Mileage Gals. Qts. Cost...

Table of Contents