Driving Safety ................................................................................................................................... 2-1

Fuel and Propane Gas ........................................................................................................................ 2-1

LP Gas Leaks .................................................................................................................................... 2-2

Propane Gas Leak Detector ............................................................................................................... 2-2

Carbon Monoxide Warning ............................................................................................................... 2-3

Carbon Monoxide Alarm .................................................................................................................. 2-3

Smoke Alarm .................................................................................................................................... 2-4

Fire Extinguisher ............................................................................................................................... 2-4

Electrical ........................................................................................................................................... 2-5

Loading ............................................................................................................................................. 2-5

Maintenance ...................................................................................................................................... 2-5

Emergency Exits ............................................................................................................................... 2-5

Formaldehyde Information ................................................................................................................ 2-6

Mold, Moisture, and Your Motor Home ........................................................................................... 2-6

Roadside Emergency ......................................................................................................................... 2-7

Jump Starting .................................................................................................................................... 2-8

Engine Overheat ................................................................................................................................ 2-8

3 - DRIVING YOUR MOTOR HOME

Seats - Driver/Co-Pilot ..................................................................................................................... 3-1

Passenger Footrest ............................................................................................................................. 3-2

Seat Belts ........................................................................................................................................... 3-2

Child Restraints ................................................................................................................................. 3-3

KeyOne™ Lock System .................................................................................................................... 3-4

Power Door Locks ............................................................................................................................. 3-4

Touchpad Entry System .................................................................................................................... 3-5

Rev. 0918090914

Part No. 161500-09-024

Table of Contents

Summary of Contents for Winnebago Horizon

Page 1: Table Of Contents
Passenger Footrest ..........................3-2 Seat Belts ............................3-2 Child Restraints ..........................3-3 KeyOne™ Lock System ........................3-4 Power Door Locks ..........................3-4 Touchpad Entry System ........................3-5 Rev. 0918090914 Part No. 161500-09-024 Copyright 2008 Winnebago Industries, Inc. All rights reserved.
Page 2 Table Of Contents Mirrors – Power Electric ........................3-6 Rearview Monitor System ........................ 3-7 Electronic Compass and Outside Thermometer ................3-8 Power Sunvisors ..........................3-8 GP-go™ Portable Navigation System ....................3-9 Parking Brake ..........................3-10 Engine Brake System ........................3-10 Pedal Adjustment ..........................
Page 3 Table Of Contents Solar Charger Panel .......................... 4-6 Energy Management System (EMS) ....................4-7 Water Heater - Gas/ Electric ......................4-7 Pressure-Temperature Relief Valve ....................4-8 MotorAid Water Heater ........................4-9 Propane Gas Furnace ........................4-9 Rear Furnace ........................... 4-10 Electronic Thermostat ........................
Page 4 Table Of Contents Full-Coach Water Filtration System ....................7-5 Disinfecting Your Fresh Water System .................... 7-6 Shower Hose Vacuum Breaker ......................7-7 Exterior Shower/Wash Station ......................7-7 Toilet ..............................7-7 Waste Water System ......................... 7-8 Utility Light ............................ 7-10 Waterline Drain Valves ........................7-10 Water Heater Bypass Winterization Valve ..................
Page 5 Table Of Contents Day/Night Pleated Blinds ......................... 9-9 Wood Furniture and Cabinetry ....................... 9-10 10 – SLIDEOUT ROOMS AND LEVELING Slideout Room Travel Locks ......................10-1 Slideout Room KeyLock ........................ 10-1 Slideout Room Operation – Hydraulic ................... 10-2 Slideout Room – Extreme Weather Precaution ................10-4 Slideout Room Troubleshooting –...
Page 6 Table Of Contents Entry Step – Electric ........................12-5 Stepwell Cover ..........................12-6 Windows ............................12-7 Interior Solar/Privacy Screen ......................12-8 Power Roof Ventilator – Galley ..................... 12-9 Power Roof Ventilator – Bath ......................12-9 Tool and Ladder Storage ....................... 12-10 Roof Ladder ..........................
Page 7: Introduction
DANGER indicates a directly hazardous are intended as a guide, and in no way situation which, if not avoided, will result extend the responsibilities of Winnebago in death or serious personal injury. Industries beyond the standard written warranty as presented in this manual.
Page 8: Pre-Delivery Inspection
National Highway Traffic Safety Administration a feature item. (NHTSA) in addition to notifying Winnebago Industries, Inc. PRE-DELIVERY INSPECTION If NHTSA receives similar complaints, it may...
Page 9: Occupant And Cargo Carrying Capacity Label
SECTION 1 – INTRODUCTION OCCUPANT AND CARGO CARRYING CAPACITY LABEL This label is affixed in the driver’s area next to or near the Vehicle Certification Label. It contains vehicle occupant and cargo carrying capacity along with the number of seat belt positions in the vehicle.
Page 10: Vehicle Certification Label
These pressure levels must be maintained to assure proper handling, safety, 2. Chassis manufacture date. and fuel economy. 3. Month and year of manufacture at Winnebago ® 9. Rear Axle Wheel Configuration: Single or Industries Dual as it relates to the inflation.
Page 11: Specifications And Capacities
SECTION 1 – INTRODUCTION SPECIFICATIONS AND CAPACITIES Model 40TD 40WD Length 39' 11" 39' 11" Exterior Height 12' 4" 12' 4" Exterior Width 8' 5" 8' 5" Exterior Storage (cu. ft.) Awning Length Interior Height 7' 2" 7' 2" Interior Width Freshwater Capacity w/Heater (gal.) Holding Tank Capacity...
Page 12 SECTION 1 – INTRODUCTION Specifications and Capacities Notes: ® Freightliner MAXUM Chassis, Cummins ISL 8.9L turbo-charged diesel, 425-hp, rear radiator, Allison® 6-speed electronic 3000 MH transmission, ZF-IFS front air suspension, NeWay® rear air suspension, 160-amp. alternator, 4-wheel ABS, engine compression brake.
Page 13: Owner And Vehicle Information
Motor Home Serial Number __________________________________________________________ Chassis Vehicle Identification No. (VIN) ________________________________________________ Vehicle Mileage at Delivery __________________________________________________________ Selling Dealer Name ________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ ® YOUR WINNEBAGO INDUSTRIES DEALER /SERVICE CENTER Name ____________________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ Contact ____________________________________________Phone ________________________ CHASSIS SERVICE CENTER...
Page 14: 2009 New Vehicle Limited Warranty
ITEMS NOT SUBJECT TO WARRANTY COVERAGE Winnebago Industries, Inc. of Forest City, Iowa, warrants each new Chassis, drivetrain and related components* Winnebago and Itasca motor home to the owner for recreational use Wheels* in the U.S.A. and Canada as follows:...
Page 15 If you are touring or have moved, contact any unresolved warranty disputes for recreational vehicles. This dispute Winnebago Industries motor home dealer in the United States or resolution program reviews eligible product and service related Canada for warranty service.
Page 17: Safety And Precautions
SECTION 2 – SAFETY AND PRECAUTIONS • Use care when accelerating or decelerating on GENERAL WARNINGS a slippery surface. Abrupt speed changes can cause skidding and loss of control. • Only seats equipped with seat belts are to be occupied while the vehicle is moving. •...
Page 18: Lp Gas Leaks
SECTION 2 – SAFETY AND PRECAUTIONS • Never use an open flame to test for LP gas LP GAS LEAKS leaks. Replace all protective covers and caps on LP system after filling. Make sure valve is The following procedures are located in the closed and the door is latched securely.
Page 19: Carbon Monoxide Warning
SECTION 2 – SAFETY AND PRECAUTIONS The best protection against carbon monoxide entry into the vehicle body is a properly WARNING maintained engine exhaust and ventilation system. It is recommended that the exhaust system and body be inspected by a qualified EXPLOSION HAZARD: DO NOT use an motor home service center: open flame to test for gas leaks.
Page 20: Smoke Alarm
InfoCase for further instructions. may not be recommended for RV application. Replacement We recommend obtaining a replacement from ® your Winnebago Industries dealer. When replacing this alarm, we recommend replacing only with a similar model. Other brands Further Information may not be recommended for RV application.
Page 21: Electrical
We recommend obtaining a MAINTENANCE replacement only from your Winnebago ® Industries dealer or a reliable RV parts supplier. •...
Page 22: Formaldehyde Information
SECTION 2 – SAFETY AND PRECAUTIONS have any questions regarding the health effects of formaldehyde, consult your doctor or local health department. MOLD, MOISTURE, AND YOUR MOTOR HOME What is Mold? Molds are part of the natural environment. They are as old as the Earth itself and mold spores are almost everywhere at some level Pull latch outward to slide window open waiting to grow.
Page 23: Roadside Emergency
If Mold Is Present, What Will Just ease back on the accelerator slowly and ® Winnebago Industries gently to continue momentum. The deflated If Winnebago Industries determines that mold tire will slow the vehicle. ® ® is present in the Winnebago...
Page 24: Jump Starting
(wheel lift or frame lift) type towing assembly for Do not attempt to push start this vehicle. safe towing. Damage to the transmission or other ® Winnebago Industries does not assume parts of the vehicle will occur. responsibility for damage incurred while towing this vehicle.
Page 25: Driving Your Motor Home
SECTION 3 – DRIVING YOUR MOTOR HOME The information in this section refers only to features installed or adapted to the dash and driver compartment area by Winnebago ® Industries . It also includes passenger seating in the living area of the coach.
Page 26: Passenger Footrest
SECTION 3 – DRIVING YOUR MOTOR HOME PASSENGER FOOTREST WARNING - If Equipped The co-pilot seat is equipped with a manual Make sure that there are no people who footrest that provides greater utility to be used as could be harmed due to power seat a lounge chair when rotated for television reclining or position adjustment.
Page 27: Child Restraints
SECTION 3 – DRIVING YOUR MOTOR HOME Unfastening 1- Insert tab into buckle Press the release button in the buckle. Hold slot until it “clicks” and is onto the tongue when you release it from the locked buckle to keep it from retracting too rapidly. When the lap-shoulder belt is in use, the lap belt must ride low across the hip area and the 3- Press to...
Page 28: Keyone Lock System
® floor directly behind the forward facing dinette keys, any Winnebago Industries dealership can seat. order a new key for you.
Page 29: Touchpad Entry System
SECTION 3 – DRIVING YOUR MOTOR HOME Reprogramming Remote When replacing batteries, the remote unit may need to be reprogrammed with a switch on the keyless entry system control box. The entry system control box is located behind the circuit breaker mounting panel in the 12-volt electrical compartment at the front left side of the coach.
Page 30: Mirrors - Power Electric
SECTION 3 – DRIVING YOUR MOTOR HOME Move Selector Switch L or R to select mirror. Center “neutral” position disables arrows to avoid unintentionally moving a mirror Keyless Entry Touchpad Further Information Please read the Keyless Entry System information in your InfoCase for information on Press Arrow Buttons to move features and instructions on how to program your mirror surface in direction indicated...
Page 31: Rearview Monitor System
SECTION 3 – DRIVING YOUR MOTOR HOME Allen Head Set Screw* Carefully pry out plug on underside (Torque screw to 75-100 in./lbs.) of mirror base to access pivot bolt *Set screws may be located on the opposite side of the mirror arm. Passenger and Driver side mirrors are similar.
Page 32: Electronic Compass And Outside Thermometer
SECTION 3 – DRIVING YOUR MOTOR HOME The rearview camera monitor system lets you ELECTRONIC COMPASS AND see what is directly behind your coach for OUTSIDE THERMOMETER maneuvering assistance and safety. Optional sideview cameras* also allow you to see what is beside you before turning or changing lanes.
Page 33: Gp-Go Portable Navigation System
SECTION 3 – DRIVING YOUR MOTOR HOME Driver Side Sunvisor Switches (center visor equipped on 40KD model only) Portable GPS Navigation Docking Station (Located inside Driver’s Side Overhead Compartment) You now will be able to operate your GPS unit via the dash-mounted display and remote control. Passenger Side Sunvisor Switch GP-GO PORTABLE...
Page 34: Parking Brake
SECTION 3 – DRIVING YOUR MOTOR HOME monitor up or down to suit your Never try to drive the vehicle with the parking preference on the navigation voice brake applied. This can cause excessive wear on guidance. the brakes and may damage the transmission. NOTE: It is normal to hear an occasional burst of air pressure from the rear of the vehicle.
Page 35: Pedal Adjustment
SECTION 3 – DRIVING YOUR MOTOR HOME PEDAL ADJUSTMENT Engine Brake Operation • Low – Press for normal braking on level or The accelerator and brake pedals may be shallow grades and in-town and city driving. adjusted forward or rearward for maximum This shuts down three of the six cylinders when comfort and control using the button on the lower engaged and provides about 130-hp of braking...
Page 36: Signal Lever/Headlight Hi/Lo Beam
SECTION 3 – DRIVING YOUR MOTOR HOME Further Information SIGNAL LEVER/HEADLIGHT See your chassis manual in your InfoCase for HI/LO BEAM further information on this switch. The signal lever controls the turn signals and STEERING COLUMN high/low beam changing. ADJUSTMENT The tilt/telescope adjustment pedal is located on the floor to the left of the steering column as shown.
Page 37: Smartwheel Steering Wheel Control System
SECTION 3 – DRIVING YOUR MOTOR HOME Marker Light Courtesy Flash SMARTWHEEL STEERING ™ WHEEL CONTROL SYSTEM –If Equipped The steering wheel control system offers convenient and safe control of the horn, headlight, marker light flash, cruise control, and • Press and release to blink or flash the marker wiper functions all from switch panels mounted (clearance) lights.
Page 38: Wiper Functions
SECTION 3 – DRIVING YOUR MOTOR HOME Res (Resume/Accel) Wiper On - Hi/Lo • Press to return to previous “set” speed after • Press to turn wipers on at Lo speed; braking or reducing speed. • then press again to switch wiper speed back and forth from Lo to Hi speed.
Page 39: Battery Boost Switch
SECTION 3 – DRIVING YOUR MOTOR HOME • On the turn signal lever, move the slide switch to the ON position or press the ON button on the steering wheel. Accelerate to the desired rpm. Press and release the SET/COAST or SET/COAST button on the steering wheel.
Page 40: Defrost Fans
SECTION 3 – DRIVING YOUR MOTOR HOME Satellite Radio DEFROST FANS –If Equipped – If Equipped ® Your coach may be equipped with a Sirius The two-speed auxiliary fans are intended to satellite radio receiver that plays through your assist the automotive windshield defroster radio.
Page 41: Radio Power Switch
SECTION 3 – DRIVING YOUR MOTOR HOME Radio Remote Control (Typical View) Radio Power Switch • Press HOUSE to listen to the radio while An additional hand-held remote allows these parked without the ignition key on. same conveniences for the passenger. The hand- •...
Page 42: Sirius Plug And Play Satellite Radio
SECTION 3 – DRIVING YOUR MOTOR HOME SIRIUS PLUG AND PLAY ® SATELLITE RADIO –If Equipped (Located inside the driver or passenger side overhead compartment) Take Sirius Plug and Play on the go - in your RV, at home, the office, other vehicles, or anywhere else! It is featured with universal Further Information docking capability so you can easily move Sirius...
Page 43: Air Horns
SECTION 3 – DRIVING YOUR MOTOR HOME AIR HORNS FILLING THE FUEL TANK – DIESEL ENGINE –If Equipped Press the Air Horn switch on the dash or –If Equipped driver’s side trim panel to the ON position, then Diesel fuel, especially #2 grade, can foam up use the horn button on the steering wheel to while being pumped into the tank.
Page 44: Engine Block Heater - Diesel Engine
SECTION 3 – DRIVING YOUR MOTOR HOME ENGINE SERVICE ACCESS GRILLE – REAR The diesel engine is located behind the grille panel at the rear of the vehicle. Release the latches near the ends of the grille panel and swing it downward. ENGINE BLOCK HEATER –...
Page 45 SECTION 3 – DRIVING YOUR MOTOR HOME Take precautions to protect carpet and interior furnishings when removing engine covers. The undersides of the engine covers could contain CAUTION deposits of oil and fuel or other engine fluids and substances that could damage fabrics and interior A falling bed board can injure.
Page 46 SECTION 3 – DRIVING YOUR MOTOR HOME Steel Frame Screw Locations Remove two screws attaching bed board (Typical View) frame to step cover - located below panel (Typical View) Propping the Bed Board If your bed is not equipped with storage underneath and the bed board needs to be propped in order to access the engine, in some models you may need to remove the steel frame...
Page 47: Fuel/Water Separator - Diesel
SECTION 3 – DRIVING YOUR MOTOR HOME the bottom of the board is seated firmly against the steel frame on the floor for security. FUEL/WATER SEPARATOR – DIESEL ® Freightliner Chassis Diesel fuel often contains small quantities of water which can damage the engine if not filtered out.
Page 48: Chassis Battery Disconnect Switch
SECTION 3 – DRIVING YOUR MOTOR HOME Further Information Refer to the chassis manual in your InfoCase for information and precautions on filling, servicing, and checking the fluid level. CHASSIS BATTERY DISCONNECT SWITCH • Squeeze both latches The chassis battery disconnect switch disconnects most chassis electrical loads from •...
Page 49: Tires
SECTION 3 – DRIVING YOUR MOTOR HOME 12-Volt Automotive Fuse Panel Fuse Diagram (inside of cover) Further Information 12-Volt Automotive Breaker Panel See your chassis manual in your InfoCase for further information about chassis supplied fuses and relays. TIRES Improper tire pressure can result in tire overloading and abnormal wear and also affects handling, ride characteristics, and fuel economy.
Page 50: Lights
SECTION 3 – DRIVING YOUR MOTOR HOME Climbing A Hill Any excessive or abnormal tire wear may indicate worn or misaligned suspension or The transmission will automatically steering, unbalanced tire, or other tire/suspension downshift as needed to climb most hills. If the problem.
Page 51: Appliances And Systems
SECTION 4 – APPLIANCES AND SYSTEMS The appliances installed in your motor home are manufactured by reputable RV appliance makers and have been tested by independent laboratories to meet all applicable standards and codes set for RV appliances. REFRIGERATOR The refrigerator in your coach can operate Bubble must be at least 1/2 inside circle from either of two energy sources available to the motor home:...
Page 52: Ice Maker
SECTION 4 – APPLIANCES AND SYSTEMS operate on 120-VAC household current if the • To enter TIME MODE, keep SET key pressed until figures flash on the display panel. Hours are to the shoreline is connected or the auxiliary left and minutes are to the right. generator is running.
Page 53: Refrigerator Service Access Compartment
SECTION 4 – APPLIANCES AND SYSTEMS REFRIGERATOR SERVICE ACCESS COMPARTMENT (Exterior) The exterior refrigerator service compartment allows access to the rear of the refrigerator for inspection, maintenance, and service. To Open: 1. Use a screwdriver or coin to turn the latch knobs to the vertical position as shown.
Page 54: Microwave Oven/Range Hood
SECTION 4 – APPLIANCES AND SYSTEMS ONEPLACE SYSTEMS ® MONITOR PANEL WARNING The OnePlace Systems Monitor Panel provides a convenient, central location for Portable fuel-burning equipment checking the condition of all utility systems in including wood and charcoal grills and ®...
Page 55: Tank Capacities
SECTION 4 – APPLIANCES AND SYSTEMS Water Level Sensors Generator Switch and Hourmeter Water Tank Generator Hourmeter See Electrical Systems section for generator For example, if the fluid level is 1-2” below hourmeter information. the FULL sensor, the monitor will show the level to be only 2/3 even though the tank is nearly full.
Page 56: Solar Charger Panel
SECTION 4 – APPLIANCES AND SYSTEMS The propane level is registered by a sending unit on the tank. The gauge mounted on the side of the tank will give a more accurate indication of actual tank level if needed. Water Pump Switch When you want to use the self-contained water system, turn on the “Water Pump”...
Page 57: Energy Management System (Ems)
SECTION 4 – APPLIANCES AND SYSTEMS NOTE: The solar battery charger is not intended to make the coach battery system “maintenance free.” The solar panel will not completely compensate for continuous low amperage draw from components such as the propane gas leak detector, the clock in the dash radio and the radio station memory circuitry, for example.
Page 58: Pressure-Temperature Relief Valve
SECTION 4 – APPLIANCES AND SYSTEMS For Propane Gas Operation For Quick Recovery Operation (Dual Heating) Press the Water Heater switch on the Monitor Panel. The “Pilot Out” light will glow for about Turn On both Water Heater switches; the gas 10-15 seconds, then it will go out.
Page 59: Motoraid Water Heater
SECTION 4 – APPLIANCES AND SYSTEMS MOTORAID WATER HEATER CAUTION –If Equipped The Motoraid uses heat from the chassis engine cooling system to heat water in the water Operate this valve only when the water heater while driving. Hoses are routed from the heater and engine cooling system are engine to a heat exchanger surrounding the water cold.
Page 60: Rear Furnace
SECTION 4 – APPLIANCES AND SYSTEMS and periodic maintenance. See the Coach Maintenance Schedule for recommended intervals. NOTE: If the furnace burner has any residuals of metal protectant or lubricants used during manufacture of the furnace, it may smoke slightly when the furnace is used for the first time and may set off your smoke alarm.
Page 61: Electronic Thermostat
SECTION 4 – APPLIANCES AND SYSTEMS 4. After about 30 seconds, the furnace burner ELECTRONIC THERMOSTAT should light. (Central Heat/Air Conditioning System) 5. The furnace should now cycle off and on automatically as the thermostat demands just ® The thermostat, located on the OnePlace like a household furnace.
Page 62 SECTION 4 – APPLIANCES AND SYSTEMS Changing Temperature Setpoints To set the temperature to a new temperature, simply press the Temperature Selector button up or down until the temperature you want appears in the display. The word “SET” will also appear at the left side of the display while you are changing the temperature setpoint.
Page 63: Furnace-A/C Thermostat Operation Chart
SECTION 4 – APPLIANCES AND SYSTEMS FURNACE-A/C THERMOSTAT OPERATION CHART The following chart shows the system functions with the “Heat/Cool” thermostat. Disregard references to heat functions when using the “Cool Only” thermostat in the rear bedroom. X = Switch Position O = Switch position does not matter or is inactive for this feature FAN MODE FAN SPEED...
Page 64: Central Air Conditioner
SECTION 4 – APPLIANCES AND SYSTEMS temperatures begin to reduce the efficiency of the The cooled air is forced through ducts in the heat pump. The heat pump will not operate when ceiling of the coach. Inside air returns to the air the outside temperature falls below 36 degrees F.
Page 65: Washer/Dryer
SECTION 4 – APPLIANCES AND SYSTEMS WASHER/DRYER –If Equipped A/C Filter Size: 14” x 20” x 1” Filter must be installed with airflow markings (arrows) pointing downward. NOTE:Do not block the filter in any way, such as by setting packages or newspapers, etc. in front of the return air grill on the front of the cabinet.
Page 66: Dishwasher
SECTION 4 – APPLIANCES AND SYSTEMS Lock Feature for up to 2 minutes after the cycle ends. DO NOT attempt to open the door unless the “STATUS/ The Dish Drawer must be programmed to the DOOR LOCK” LED is BLINKING SLOWLY! “Closed Drawer”...
Page 67 SECTION 4 – APPLIANCES AND SYSTEMS The vacuum cleaner operates on 120-volt household current, so the shoreline must be connected to provide power. To Use The Vacuum Plug the hose into the hose outlet. The vacuum cleaner will start automatically. When you remove the hose, the vacuum will stop.
Page 69: Propane Gas
SECTION 5 – PROPANE GAS PROPANE GAS SUPPLY WARNING The propane gas system supplies fuel for the gas range/oven, water heater, furnace, and refrigerator (while in gas mode). When used and Do not alter or remove propane tank handled properly, this system is safe and gauge at any time.
Page 70: Safe Use Of The Propane Gas System
SECTION 5 – PROPANE GAS phone directory yellow pages for locations of local propane gas refilling stations or bulk DAN GE R dealerships. NOTE: If you travel outside the U.S. with your DO NOT FILL CONTAINER TO MORE motor home, you may find butane or THAN 80 PERCENT OF CAPACITY.
Page 71: Propane Gas Warnings And Precautions
SECTION 5 – PROPANE GAS • Exercise caution at all times. Be familiar with PROPANE GAS WARNINGS the distinctive odor of propane gas. If a leak is AND PRECAUTIONS suspected, turn off the supply valve immediately. Have the propane gas system It is illegal for vehicles equipped with propane checked by your dealer or other qualified tanks to travel on certain roadways or through...
Page 72: Propane Gas Pressure Regulator
SECTION 5 – PROPANE GAS WARNING WARNING Propane cylinders shall not be placed or Visually inspect the pressure regulator stored inside the vehicle. vent periodically for blockage by Propane cylinders are equipped with accumulated debris or insect nests, etc. safety devices that relieve pressure by Vent obstruction could result in excessive discharging propane to the atmosphere.
Page 73: Propane Vaporization In Cold Weather
SECTION 5 – PROPANE GAS This means that in extremely cold weather when a large volume of gas is being used by the furnace for heating, it is possible to experience a loss of gas pressure. At first, this problem may appear to be caused by an empty tank or a regulator freeze-up, but is actually caused by failure of the liquid gas to vaporize as fast as it is needed by the furnace.
Page 75: Electrical
SECTION 6 – ELECTRICAL Your coach is equipped with an electrical the power converter automatically changes a system consisting of two separate voltages: portion of the 120-volt current to 12-volt DC current. All equipment in the motor home that is •...
Page 76: Connecting The Power Cord
SECTION 6 – ELECTRICAL Connecting The Power Cord To connect to an external source, remove the cord from the utility compartment and plug it into a suitable 50-amp power receptacle to provide external power to the coach and converter/ charger system. NOTE: Some parks do not have 50-amp service available, so you will need to connect to a standard 30-amp service pole using an...
Page 77: Power Cord Reel
SECTION 6 – ELECTRICAL Park Fuses or Breakers INVERTER/CHARGER UNIT – Most campgrounds are equipped with a fuse 2000W or circuit breaker at the receptacle. This protects –If Equipped the park’s wiring, as well as the power cord on your vehicle, from electrical damage. If electrical The inverter/charger unit is located on the wall power fails, contact the park attendants and have of the utility compartment on the left side of the...
Page 78: Charging Section
SECTION 6 – ELECTRICAL Inverter/Charger Control Panel: –If Equipped CAUTION The inverter/charger has a wall mounted monitor/control panel that can be programmed for several charging options. It will also display Do not store items too closely around the inverter unit in the storage compartment. warnings for overload conditions or other The inverter generates heat while operating failure conditions.
Page 79: Circuit Breakers - House 120-Volt Ac
SECTION 6 – ELECTRICAL CIRCUIT BREAKERS – HOUSE ELECTRICAL OUTLETS – 120-VOLT AC HOUSE 120-VOLT AC The breaker panels protect all 120-volt A number of standard household electrical components in the motor home from either an outlets are provided throughout the coach for overload on the circuit or a short in the wiring or connecting small appliances such as televisions, component itself.
Page 80: Electrical Generator
SECTION 6 – ELECTRICAL Power Transfer Switch WARNING The GFCI will not completely eliminate the risk of electrical shock. Small children and persons with heart conditions or other disabilities which make them especially sensitive to electrical shock may still be injured by a 120-volt receptacles even though protected by a Ground Fault Circuit Interrupter.
Page 81: Operation Warnings And Cautions
SECTION 6 – ELECTRICAL Generator Basic Operation Operation Warnings and Cautions To Start the Generator Press and Hold the Generator switch in WARNING START position until you hear the generator running smoothly, then release. The exhaust of all internal combustion engines contains carbon monoxide (CO).
Page 82: Electrical Generator Slideout Service Tray
SECTION 6 – ELECTRICAL ELECTRICAL GENERATOR WARNING SLIDEOUT SERVICE TRAY The generator service tray can be extended Make sure travel pin is in place to secure and retracted on a slideout frame mechanism. generator before driving after generator To Extend Generator Frame For service or maintenance.
Page 83: Battery Information
SECTION 6 – ELECTRICAL House Batteries and will withstand the frequent drain-and- recharge cycles that occur under the demanding The house batteries supply current to 12-volt conditions of a camping outing. equipment located in the living area of the coach. The house batteries supply power to 12-volt This includes interior lights, range exhaust fan, equipment located in the living area of the motor...
Page 84: Battery Care
SECTION 6 – ELECTRICAL Lift the retainer catches that hold the battery inside the battery. This condition is called tray and slide it outward for service. “sulfating” and prevents the battery from either releasing or accepting a charge. If this condition occurs, the battery must be replaced.
Page 85: Circuit Breakers - House 12-Volt
SECTION 6 – ELECTRICAL To ensure that the battery will always accept and hold a charge, follow these simple WARNING maintenance practices: • Make sure the batteries always remain securely clamped in the battery tray. To prevent wiring damage, it is essential when replacing the cables on the battery, •...
Page 86 SECTION 6 – ELECTRICAL panel location may vary according to model floorplan. Breakers are labeled on panel according to appliance and equipment options. 6-12...
Page 87: Plumbing
SECTION 7 – PLUMBING FRESH WATER SYSTEM The fresh water system provides water to the galley sink, shower, bathroom lavatory, toilet and water heater. Water may be supplied by either of two sources: • a fresh water tank located within the motor home •...
Page 88: Water Pump
SECTION 7 – PLUMBING 2. Open a faucet on the coach (such as exterior wash station) to relieve water line pressure. 3. Disconnect the hose from the city water faucet and store hose (retract the hose into the hose reel- if equipped). Be sure to replace the protective cap on the hose end to avoid entrance by debris or insects.
Page 89: Water Pump Switch
SECTION 7 – PLUMBING demand pump is designed to run only when you • Twist the inlet cap (bowl) counter-clockwise are using water. When you open a faucet, the to unscrew from the strainer assembly. waterline pressure drops and the pump begins to •...
Page 90: Filtered Water Faucet
SECTION 7 – PLUMBING Water Pump Switch ® (Located on OnePlace Monitor Panel) Water Filter Assembly (Located below Galley Sink) Replacing the Water Filter Cartridge Replace the filter cartridge when water flow from the faucet is too slow for convenience. •...
Page 91: Full-Coach Water Filtration System
SECTION 7 – PLUMBING • See Winterization Procedure at the end of this section. Also see filter manufacturer’s information in your InfoCase for further instructions or precautions. • When removing the coach from storage, always disinfect and flush the water system thoroughly before installing a new filter.
Page 92: Disinfecting Your Fresh Water System
SECTION 7 – PLUMBING • Turn the Fresh Water Valve to Normal 5. Open each faucet in the coach and run the position, next open a faucet inside the coach or water until a distinct odor of chlorine can be the exterior shower, then turn city water on detected in the water discharged.
Page 93: Shower Hose Vacuum Breaker
SECTION 7 – PLUMBING 3. Hold the “city end” of the water hose upright and allows water remaining in the hose to drain and use a funnel to pour 1 1/2 cups of down. This is a normal function of the shower household chlorine bleach (sodium valve assembly and is not a leak or defect.
Page 94: Waste Water System
SECTION 7 – PLUMBING See Specifications in Section 1–Introduction for tank capacities for your model. Dumping Holding Tanks The waste drain (sewer) hose features a convenient handle and valve nozzle for sanitary handling and improved waste disposal. 1. Remove the dust cap from the drain outlet and Important “Don’ts”...
Page 95 SECTION 7 – PLUMBING 6. Close hose valve by pulling handle up until Do not open holding tank valves until the lock snaps into place. hose end valve is open. If you open the 7. Rinse end of sewer hose thoroughly with dump valve before the hose valve, the water and stow.
Page 96: Utility Light
SECTION 7 – PLUMBING Holding Tank Level Indicators See Systems Monitor Panel in Section 4– Appliances for further information on the monitor panel and checking tank levels. See Specifications in Section 1–Introduction for tank capacities for your model. UTILITY LIGHT A light is located up on the left sidewall to illuminate the utility hook-up area when needed.
Page 97: Water Heater Bypass Winterization Valve
SECTION 7 – PLUMBING To Drain Waterlines The waterline drain caps are located in the water service center or in other compartments, depending on model. Remove the drain caps to drain water from hot and cold waterlines. Water Heater Drain Plug The water heater drain plug is located on the outside of the coach behind the water heater service panel.
Page 98: Winterizing Procedures
SECTION 7 – PLUMBING press the backflow valve “button” in the center of the inlet to drain any water trapped in the inlet line. CAUTION Using Exterior Shower to drain waterline Leave bypass valve handle in NORMAL (Typical View- appearance on your coach may differ) FLOW position if draining water and blowing out waterlines.
Page 99 A blow-out plug can be purchased If not, proceed to the next step. ® ® at any Winnebago or Itasca dealer. 9. Drain Water Heater. Turn off the water heater power switch before draining the water...
Page 100 SECTION 7 – PLUMBING 13. Turn air pressure off. Disconnect water 21. Close dump valves and refit the dust cap onto purge adapters. Recap the city water inlet to the drain outlet. avoid contamination by dirt or insects. This will inhibit rust formation on valve shafts and prevent entry and contamination by After Disconnecting Air Pressure airborne debris, insects, and rodents.
Page 101 SECTION 7 – PLUMBING next numbered step.) After removing filter, remount the empty WARNING canister onto the filter assembly and continue the antifreeze fill procedure. NEVER use automotive antifreeze/ Set Up Winterization Valves coolant in your RV water system. Auto 3.
Page 102 SECTION 7 – PLUMBING Water Heater Drain Plug Remove with socket RV Antifreeze Siphon Tube • Also open the Pressure-Temperature relief in water center or near water pump valve at the top right portion of the tank to (insert into container of RV water system antifreeze) prevent air locking in the tank while draining.
Page 103: Winterizing Optional Appliances
SECTION 7 – PLUMBING 15. Pour about one cup of RV antifreeze down each drain for the galley sink, lavatory sink, and shower/tub. This fills the drain trap pipes to prevent holding tank odors from entering the coach during storage. Dump and Clean Holding Tanks 16.
Page 104 SECTION 7 – PLUMBING To use Washer/Dryer again: 4. Press ON/OFF Button (OUT). Unplug the washer/dryer from the electrical outlet (or Flush antifreeze from the waterlines, then disconnect power). 1. Reconnect the water inlet hoses to the 5. Turn the water supply faucets OFF. corresponding HOT/COLD faucets.
Page 105: Water System Drain Valve Locations
SECTION 7 – PLUMBING To use Dishwasher again: 2. Set the controls to the end of the Rinse cycle Flush antifreeze from the waterlines, then and allow the machine to run through the complete cycle to clean out any remaining 1.
Page 107: Entertainment
SECTION 8 – ENTERTAINMENT The TV will display the DVD logo when the HIGH DEFINITION VIDEO correct input is selected. SELECTION SYSTEM To Watch Satellite TV (Dish) –If Equipped -If Equipped • Connect satellite receiver to accessory connection cables (provided in the prep area). High Definition Video Selection Box The video selection system allows you to watch standard or high definition video from...
Page 108: Front Tv Ignition Switch Interlock
SECTION 8 – ENTERTAINMENT AUDIO-VIDEO SYSTEM BASIC OPERATION NOTE: For your convenience, we have also included a handy, tear-out version of this “A/V System Basic Operation” guide in Section 8 of your Operator’s Manual Supplement. See your InfoCase for specific operating guides for audio and video components.
Page 109: Cd/Dvd Player - Bedroom
SECTION 8 – ENTERTAINMENT • Press INPUT button on the • Press FUNCTION button on DVD player or remote or front of TV and remote to set DVD player to “TV/VIDEO”. select the DVD input • Use the TV Menu button to set TV audio channel on the TV.
Page 110: Cd/Dvd Player
SECTION 8 – ENTERTAINMENT Set TV Video Input CD/DVD PLAYER • Turn TV and DVD player On. (& Stereo Radio Alarm Clock) • Press the SOURCE or INPUT button on the Exterior Entertainment Center TV or TV remote to select “INPUT 1” or –If Equipped “AV1”.
Page 111: Cd/Dvd Player
SECTION 8 – ENTERTAINMENT • The DVD may load directly to the main title/ The exterior entertainment center TV is menu screen or it may begin to play previews. connected to the exterior DVD player, video You may be able to skip previews if desired by selection box, the rooftop antenna, and the park pressing the NEXT button until you see the cable input.
Page 112: Compact Disc Changer
SECTION 8 – ENTERTAINMENT Cable (Park cable input located in power cord compartment) • Turn Off antenna booster inside coach. See above photo. • Turn On TV and tune to desired channel. Video Programming from the Video Selection Box • Turn On video Further Information selection box and...
Page 113: Tv Signal Amplifier
SECTION 8 – ENTERTAINMENT TV SIGNAL AMPLIFIER The TV signal amplifier is built into the antenna and can be turned on or off with a power switch located on a switchplate below or inside the front overhead entertainment center cabinet. Rotating Antenna for Best Picture An indicator light will glow when the switch is on and the signal amplifier is active.
Page 114 SECTION 8 – ENTERTAINMENT Rotating Antenna for Best Picture signal amplifier designed to strengthen signals, is controlled by a power switch built into the video 1. Press and hold the “Rotate” counter- selector panel. clockwise button to rotate antenna towards See the antenna manufacturer’s operation, signal.
Page 115: Tv Digital Satellite System - Automatic
SECTION 8 – ENTERTAINMENT Further Information TV DIGITAL SATELLITE See the Automatic Satellite System owner’s SYSTEM – AUTOMATIC manual in your InfoCase for for complete description of features and instructions. –If Equipped The Automatic Digital Satellite Television System allows you to receive TV programs directly from satellite to your coach.
Page 116: Portable Satellite Dish And Cable Tv Hook-Ups (Input)
Satellite seeking time can be reduced by (if equipped.) setting the region code for your current ® See your authorized Winnebago Industries location. Codes are shown in the dealer for proper installation and sealing of roof manufacturer’s operating information. mounted components.
Page 117: Bedroom Radio/Cd/Dvd Player
SECTION 8 – ENTERTAINMENT Further Information BEDROOM RADIO/CD/DVD Please read the manufacturer’s operating PLAYER information in your InfoCase for operation of Radio/CD player. –If Equipped The available bedroom radio/CD/DVD EXTERIOR ENTERTAINMENT player/alarm clock is located on the bedroom CENTER nightstand (if equipped). The radio cabinet also contains the AC and a 12-volt electrical outlets –If Equipped for convenience.
Page 118: Exterior Entertainment Center
SECTION 8 – ENTERTAINMENT EXTERIOR ENTERTAINMENT CENTER (Pull-Out/Pivot Mechanism) –If Equipped (Typical View) Setting up Exterior Entertainment Center: 1. Turn compartment door latches counter- clockwise to unlatch. 4. Slowly lift TV upward until it is seated in the vertical position. 2.
Page 119 SECTION 8 – ENTERTAINMENT Storing Exterior Entertainment Center: • Repeat all steps in reverse order to store TV away. NOTE: Be sure exterior entertainment center slide mechanism is push in completely and the side latch is fully engaged. 8-13...
Page 121: Furniture And Softgoods
SECTION 9 – FURNITURE AND SOFTGOODS LOUNGE CHAIR BASE CLAMP TABLE AND CHAIRS –If Equipped While the vehicle is in motion, the base of the lounge chair must be fastened into position with Dinette Chairs a clamp on the floor as shown. The dinette chairs are free-standing to allow greater freedom of movement than typical booth style dinettes or pedestal seats.
Page 122: Sleeping Facilities
SECTION 9 – FURNITURE AND SOFTGOODS Buffet Chairs WARNING Be sure all free-standing chairs and furniture items, and all other loose items are secured or stored properly while the vehicle is in motion. Possible overlooked items such as canned goods or small appliances on the countertop, cooking pans on the range can also become dangerous projectiles during a sudden...
Page 123: Booth Dinette - 40Wd Models
SECTION 9 – FURNITURE AND SOFTGOODS Wall Support Table Bracket 2. Remove the table from the wall support bracket by lifting the end of the table. Then 2. Make sure that the table leg is secured into the lower the table to rest on the cleats attached to floor support bracket and the leg brace is each dinette bench.
Page 124: Sofa/Sleeper
SECTION 9 – FURNITURE AND SOFTGOODS • The dinette table may be adjusted to the SOFA/SLEEPER position that best suits your needs by moving the table slide mechanism forward or back. –If Equipped (Typical view – your coach may differ) Sofa to Bed 1.
Page 125: Sofa/Bed Conversion
SECTION 9 – FURNITURE AND SOFTGOODS 2. Slide armests into place at each end of the SOFA/BED CONVERSION sofa. (with Removable Armrests) –If Equipped REST EASY MULTI-POSITION ® LOUNGE Couch to Bed –If Equipped 1. Remove the armrests from both ends of the couch by lifting upward.
Page 126 SECTION 9 – FURNITURE AND SOFTGOODS NOTE: The footrest “drawer” will latch when pulled out completely and must be unlatched to push back in when stowing the footrest. To Extend Pull-Out Footrest Section 1. Squeeze latch behind opening at top of lounge face panel and pull footrest trundle section out until it locks in the fully extended position.
Page 127: Theater Seating/Bed Conversion
SECTION 9 – FURNITURE AND SOFTGOODS THEATER SEATING/BED CONVERSION –If Equipped CAUTION Do not recline the lounge completely flat unless the footrest trundle section is CAUTION extended. Do not occupy the lounge when elevating the seat back from the flat bed position to upright lounge position.
Page 128 SECTION 9 – FURNITURE AND SOFTGOODS To Extend Pull-Out Footrest Section 1. Squeeze latch behind opening at top of lounge face panel and pull footrest trundle section out until it locks in the fully extended position. Tip for “power users” •...
Page 129: Sleep Number® Bed
SECTION 9 – FURNITURE AND SOFTGOODS NOTE: The Sleep Number bed operates on 120- volt AC household current only, so you CAUTION must have the shoreline plugged in or the generator running to adjust the air pressure settings in this bed. Do not recline the lounge completely flat unless the footrest trundle section is Further Information...
Page 130: Wood Furniture And Cabinetry
CABINETRY –If Equipped People are drawn to the natural beauty of ® wood. At Winnebago Industries , our craftsmen work with the art found in each piece of wood to create cabinets of superior quality, backed by the Winnebago Industries warranty.
Page 131 SECTION 9 – FURNITURE AND SOFTGOODS light. Color differences or changes in wood can also be caused by exposure to harsh chemicals, extreme heat, or other contributing external conditions. Any color change that occurs in both the finish and the wood is considered part of the natural aging process and is not to be considered defect or damage.
Page 133: Slideout Rooms And Leveling
SECTION 10 – SLIDEOUT ROOMS AND LEVELING NOTE: Be sure locks are fully released before SLIDEOUT ROOM TRAVEL attempting to extend or retract room. LOCKS If the latch mechanisms are protruding more than 1/4”, the room will not extend –If Equipped or retract and the slideout hydraulic Some models are equipped with electric pump will run in idle/bypass mode.
Page 134: Slideout Room Operation - Hydraulic
SECTION 10 – SLIDEOUT ROOMS AND LEVELING To Extend Slideout Room SLIDEOUT ROOM OPERATION – HYDRAULIC WARNING WARNING Keep all persons clear of the slideout room and moving parts while extending or retracting. Do not occupy the slideout Your motor home may have more than room while it is being extended or one slideout room.
Page 135 SECTION 10 – SLIDEOUT ROOMS AND LEVELING Extend Procedure: Before Retracting! See “Before Extending!” before proceeding. • Be sure the coach is level and the Parking Brake is set. An interlock relay system will • Start the engine so the alternator can provide then provide power to the slideout control maximum power for proper operation of switches.
Page 136: Slideout Room - Extreme Weather Precaution
SECTION 10 – SLIDEOUT ROOMS AND LEVELING • After the room is fully retracted, deactivate the slideout switch with the Safety Lock key, then engage Slideout Locks (if equipped). See information at the beginning of this section. NOTE: Visually confirm that the slideout lock has engaged by observing the room from outside of the coach and noting whether the top of the room is being held tightly...
Page 137: Slideout Emergency Retraction Procedures
SECTION 10 – SLIDEOUT ROOMS AND LEVELING alternator can provide maximum power to SLIDEOUT EMERGENCY properly operate the slideout mechanisms. RETRACTION PROCEDURES If battery charge is sufficient, go to next step. • A fuse may be blown in the hydraulic system Front Slideout Rooms - Emergency control box on the pump, which can be viewed Crank-In Procedure...
Page 138 SECTION 10 – SLIDEOUT ROOMS AND LEVELING The large solenoid valves control the leveling jacks. The small valves contol the slideout rooms. Use 1/4” nut driver built into end of dipstick on pump reservoir cap to open slideout solenoid valves. •...
Page 139 SECTION 10 – SLIDEOUT ROOMS AND LEVELING Loosen Stop Bolt CAUTION The retract bolts must be ‘backed out’ to their original positions immediately after the crank-in procedure to avoid damaging the retract bolts and slideout mechanism the next time the room is extended. Step 3: Secure Travel Locks and Close Hydraulic Line Valves •...
Page 140: General Slideout Care
• When the room is snug against the coach wall, close the solenoid valves to prevent “creep out” during transit. See your Authorized Winnebago Indus- ® tries Dealer for service of the slideout system before using again.
Page 141: Leveling System
SECTION 10 – SLIDEOUT ROOMS AND LEVELING LEVELING SYSTEM The leveling system makes selecting a parking site easier and faster by reducing the effect of uneven ground. Hydraulic jacks raise the affected low corners of the coach to make leveling “set up” faster and easier for you.
Page 142 SECTION 10 – SLIDEOUT ROOMS AND LEVELING These switches allow you to extend or retract your jacks and observe them at the same time. It also allows you to stop them suddenly, if needed, without having to climb in and out of the coach. The remote switches are located just inside the entrance door and in the service center.
Page 143: Checking Hydraulic Oil Level
SECTION 10 – SLIDEOUT ROOMS AND LEVELING 4. See the Leveling System Operator’s Manual supplied in your InfoCase for troubleshooting instructions or operating the leveling system if jacks fail to retract or any other functions fail. CHECKING HYDRAULIC OIL LEVEL See the Leveling System/Room Extension Operator’s Manual in your InfoCase for complete maintenance instructions and information.
Page 145: Maintenance And Storage
• Have the sealant replaced if you notice any of attention. Delaying these repairs may allow water the above. Your local Winnebago Industries leakage and result in damage to interior ceiling dealer has the correct and necessary parts and and body panels, upholstery, etc., which is not experience to help you maintain your sealants.
Page 146: Exterior Automotive Paint Finish
SECTION 11 – MAINTENANCE AND STORAGE weight to the vehicle. This, in effect, reduces the initial 60-day cure stage, a coat of wax or amount of cargo you can carry and remain within polish can help protect the surface from these GVWR and GAWR limits.
Page 147 SECTION 11 – MAINTENANCE AND STORAGE Bug Removal to clean heavy road films on semi trailers and are often dirty. They are not • Rinse the loose debris off with water and designed for custom painted RV’s and allow the remaining residues to soak and they will scratch the clearcoat finish.
Page 148: Care Of Appliques And Decals
LIGHTS They should be treated like any painted surface on your vehicle. Exterior Light Lenses ® Most Winnebago Industries vehicles have Here are a few helpful hints on caring for decals: polycarbonate lenses on exterior lamps, which • Wash appliques and decals with plain soap are very sensitive to a variety of chemical and water or any retail car wash soap.
Page 149: Plastic Parts - Cleaning
SECTION 11 – MAINTENANCE AND STORAGE • Do not use a pressure washer to clean Here is a list of mild cleaners that may be used headlights. safely: • Inspect and operate the lights regularly to • Car washing soap and water confirm proper operation and mounting •...
Page 150: Tile And Grout Care
SECTION 11 – MAINTENANCE AND STORAGE hidden area of fabric before using on visible • For stubborn stains, use cleaner-degreaser. areas. For best results, fabric cleaning should be referred to a professional carpet and upholstery UltraLeather Cleaning Chart cleaner. Detergent/ Cleaner/ NOTE: To minimize fading of upholstery, carpets Type of Stain...
Page 151: Care And Maintenance
SECTION 11 – MAINTENANCE AND STORAGE To maintain grout appearance, apply a If the stain is not water-base or oil-base porous stone protector or grout sealer after the material, you may need to gently remove it using grout has been cleaned and is thoroughly dry a plastic scraper (disposable plastic knife for (usually about 24 hours after cleaning).
Page 152: Galley Sink
SECTION 11 – MAINTENANCE AND STORAGE Tub and Shower Walls GALLEY SINK The tub and shower walls in the bathroom Stainless Steel should be cleaned with mild soap and warm water. Do not use an abrasive cleaner on the Care and Cleaning Instructions shower walls and tub, as scratching and The stainless steel sink can usually be cleaned discoloration may occur.
Page 153: Vehicle Storage - Preparation
SECTION 11 – MAINTENANCE AND STORAGE Use care when removing ice or frost from the maintenance especially in cold weather. windows. Always use a plastic ice scraper, never See “Battery Care” in the Electrical one made of metal. Use care when removing ice section.
Page 154: Chassis Service And Maintenance
SECTION 11 – MAINTENANCE AND STORAGE 5. Close all faucets and drain valves that are compounds are available from your dealer. open. See Sealants – Recommended Application page at the end of this section. 6. Add a few gallons of water to the fresh water Also inspect weather seals around doors, etc., tank and turn on the water pump to check for and if necessary, have a dealer replace...
Page 155 SECTION 11 – MAINTENANCE AND STORAGE Remove 3 screws at the front edge of the grille and 2 screws on the underside of the rear edge of the grille. Swing the grill upward and support while servicing. Automotive Fuses (cover removed) Remove 3 screws from front edge of Fuse Diagram (inside of cover) condenser grille panel in locations shown.
Page 156: Chassis Diagnostic Connectors
SECTION 11 – MAINTENANCE AND STORAGE Towing package fuses are on this fuse block. See chassis manufacturer’s information on inside of cover. Diagnostic plug on rear engine compartment shroud -Typical View CHASSIS DIAGNOSTIC CONNECTORS The chassis diagnostic connectors are located in on the steering column support plate beneath the dash and in the rear engine compartment as shown in the following photos.
Page 157: Coach Maintenance Chart
SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System Have propane gas system checked for leaks.
Page 158 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items Headlights, Taillights and Marker Lights Turn Signals...
Page 159 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants Inspect (see “Sealants”...
Page 160: Sealants - Recommended Application
SECTION 11 – MAINTENANCE AND STORAGE SEALANTS – RECOMMENDED APPLICATION 11-16...
Page 161: Miscellaneous
SECTION 12 – MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motor home’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available CAUTION space when loading your motor home.
Page 162 SECTION 12 – MISCELLANEOUS Corner Weighing (Side-to-Side) You will first drive only your front wheels onto the scale pad, then drive ahead so that the The most accurate method of weighing a whole vehicle is on the scale, then finally pull off motor home is to weigh each “corner”...
Page 163: Car Or Trailer Towing
SECTION 12 – MISCELLANEOUS axle is 12,000 lbs., then the load on each rear dual unacceptable overall vehicle performance. set (left rear duals or right rear duals) should not Maximum safety and satisfaction when towing exceed 6,000 lbs. depends on proper use of correct equipment. Tires must be filled to the recommended air When towing a vehicle behind your motor pressure for the highest loaded tire set on that...
Page 164: Trailer Wiring Connector
SECTION 12 – MISCELLANEOUS The following diagram shows proper connection of trailer or tow vehicle wiring to the coach light system. The “pigtail” assembly with the (car/trailer end) connector plug should be wired by a qualified technician. Provision for an electric brake controller is located near the steering column.
Page 165: Entry Step - Electric
SECTION 12 – MISCELLANEOUS transmission, drive line, drive axle, and others. equipped with a Class IV hitch have a The tow vehicle brakes may be rated for label limiting vertical tongue load to 500 operation at GVWR, not GCWR. lbs. On a 228" wheelbase, a 500-lb. load on a hitch 11' from the rear axle will NOTE: State or provincial laws/regulations may apply about 800 lbs.
Page 166: Stepwell Cover
SECTION 12 – MISCELLANEOUS Stationary Extended Mode - Step Switch OFF (Step Remains Extended) With the Step power switch in the OFF position, the step will extend when the screen door is opened and will stay extended whether the door is opened or closed. NOTE: The step switch is “locked”...
Page 167: Windows
SECTION 12 – MISCELLANEOUS Emergency Retract Feature The step cover is equipped with an Emergency Retract function in event of an emergency exit situation and/or the step cover fails to retract while in the extended position. CAUTION Do not use Emergency Retract feature unless necessary for emergency.
Page 168: Interior Solar/Privacy Screen
SECTION 12 – MISCELLANEOUS Horizontal Slider Windows The interior installation not only improves the exterior appearance of your coach, but it also Swing the latch handle straight out from the eliminates direct exposure of the screen to the window. Grasp the sliding window edge frame elements, which preserves the appearance and and slide the window to the side.
Page 169: Power Roof Ventilator - Galley
SECTION 12 – MISCELLANEOUS NOTE: For best results, close all other roof POWER ROOF VENTILATOR – vents, windows, and doors, then open GALLEY one (1) window the farthest distance from the roof ventilator. The fan speed –If Equipped selector on the ventilator allows you to The 3-speed turbine vent is controlled by a control the amount of circulation you switch on the wall to raise or lower the dome.
Page 170: Tool And Ladder Storage
SECTION 12 – MISCELLANEOUS The turbine fan will start automatically as the NOTE:In event of power failure, the ventilator vent is raised, and stop as the vent is lowered. dome may be opened or closed manually using the Dome Crank knob. Fan Power Fan Speed Fuse...
Page 171: Roof Ladder
SECTION 12 – MISCELLANEOUS Before Using the Ladder • Inspect the ladder to make sure it is not damaged. Never use a damaged ladder. • Keep the rungs of the ladder clean and dry while in use. Never use the ladder when it is raining, snowing or icy.
Page 172: Storage Compartment Doors
SECTION 12 – MISCELLANEOUS To Use the Ladder Extension: • Lower the extension into place and pull downward to ‘seat’ the retainers onto the ladder rung. • Make sure retainer brackets are properly engaged onto ladder rung before using ladder. •...
Page 173 SECTION 12 – MISCELLANEOUS NOTE: The Windsensor Auto-Retract system is On when the power is On and is Off when the Power Switch is set to Off. If the power is shut off while the awning is extended, the awning is not protected by the Auto-Retract system.
Page 174: 110-Volt Power Awning
SECTION 12 – MISCELLANEOUS Using the Key FOB Remote Control NOTE: As a safety feature, the awning will not extend if the ignition key is on. Further Information For complete operating instructions, refer to the manufacturer’s information provided in your Function InfoCase.
Page 175: Power Awning (Over The Door)
SECTION 12 – MISCELLANEOUS Further Information For complete operating instructions, refer to the manufacturer’s information provided in your InfoCase. POWER AWNING (OVER THE DOOR) –If Equipped To Open the Awning Press and hold the Door Awning Switch “Out” until the awning is in the desired position, then release.
Page 176: Air Hose And Connector
SECTION 12 – MISCELLANEOUS Humidity and Condensation AIR HOSE AND CONNECTOR Moisture condensing on the inside of –If Equipped windows is a visible indication that there is too much humidity inside the coach. Excessive For convenience, your coach is supplied with moisture can cause water stains or mildew, which a 50-foot quick-connect air hose that you can use can damage interior items such as upholstery and...
Page 177 INDEX 110-Volt Power Awning ......12-14 Defrost Fans ..........3-16 2009 New Vehicle Limited Warranty ..1-8 Dinette/Bed Conversion ....... 9-2 About this Manual ........1-1 Dishwasher ..........4-16 Air Conditioner Filter ........ 4-14 Disinfecting Your Fresh Water System ..7-6 Air Conditioner/Heater –...
Page 178 Index Fuel and Propane Gas ........2-1 Power Cord Reel .......... 6-3 Fuel Selection – Diesel Engine ....3-19 Power Door Locks ........3-4 Fuel/Water Separator – Diesel ....3-23 Power Roof Ventilator – Bath ....12-9 Full-Coach Water Filtration System .... 7-5 Power Roof Ventilator –...
Page 179 Index Slideout Room Troubleshooting – Winterizing Optional Appliances ....7-17 Hydraulic ..........10-4 Winterizing Procedures ......7-12 SmartWheel™ Steering Wheel Control Wood Furniture and Cabinetry ....9-10 System ............ 3-13 Smoke Alarm ..........2-4 Sofa/Bed Conversion ........9-5 Sofa/Sleeper ..........9-4 Solar Charger Panel ........

This manual is also suitable for:

2009 ellipse Vectra 2008

Winnebago Horizon User Manual

Introduction

Safety and Precautions

Driving Your Motor Home

Appliances and Systems

Propane Gas

Electrical

Plumbing

Entertainment

Furniture and Softgoods

Slideout Rooms and Leveling

Maintenance and Storage

Miscellaneous

Quick Links

TABLE OF CONTENTS

Related Manuals for Winnebago Horizon

Summary of Contents for Winnebago Horizon