Winnebago Chalet Operator's Manual

Hide thumbs Also See for Chalet:

Manual (122 pages)

100

101

102

103

104

105

106

107

108

109

110

111

112

113

114

115

116

117

118

119

120

121

122

123

124

Table of Contents

Quick Links

Need help?

Do you have a question about the Chalet and is the answer not in the manual?

Questions and answers

Summary of Contents for Winnebago Chalet

Page 1: Table Of Contents
3 – DRIVING YOUR MOTOR HOME Seats – Driver/Co-Pilot ........................3-1 Fold-Down Dinette Seat ........................3-1 Seat Belts ............................3-1 Child Restraints ..........................3-2 Keys ..............................3-3 Rev. 1102100125 Part No. 161500-011-023 Copyright 2010 Winnebago Industries, Inc. All rights reserved.
Page 2 Table Of Contents Hazard Warning Flashers ........................3-3 Mirrors – Power Sideview Exterior ....................3-3 Mirrors – Power Sideview Exterior ....................3-4 Battery Boost Switch ........................3-5 Air Conditioner/Heater – Automotive (Dash) .................. 3-5 Radio In-Dash/Rearview Monitor System ..................3-5 Radio –...
Page 3 Table Of Contents Battery Access ..........................6-6 Battery Care ............................6-7 Circuit Breakers and Fuses – House 12-Volt DC ................6-8 7 – PLUMBING Fresh Water System .......................... 7-1 Water Pump ............................7-2 Disinfecting Your Fresh Water System .................... 7-3 Shower Hose Vacuum Breaker ......................
Page 4 11 – MAINTENANCE AND STORAGE Sealants – Inspection and General Information ................11-1 Roof ..............................11-1 Undercarriage ..........................11-1 Exterior Finish ..........................11-2 Care of Appliques and Decals ......................11-3 Plastic Parts – Cleaning ........................11-3 Exterior Lights ..........................11-4 Interior Softgoods ...........................
Page 5: Introduction
DANGER indicates a hazardous situation are intended as a guide, and in no way which, if not avoided, will result in death or extend the responsibilities of Winnebago serious personal injury. Industries beyond the standard written warranty as presented in this manual.
Page 6: Pre-Delivery Inspection
National Highway Traffic Safety Administration (NHTSA) in addition to notifying Winnebago PRE-DELIVERY INSPECTION Industries, Inc. If NHTSA receives similar complaints, it may...
Page 7: Occupant And Cargo Carrying Capacity Label
SECTION 1 – INTRODUCTION You can also obtain other information about motor vehicle safety from the NHTSA website at http://www.safercar.gov OCCUPANT AND CARGO CARRYING CAPACITY LABEL This label is affixed in the driver’s area next to or near the Vehicle Certification Label. It contains vehicle occupant and cargo carrying capacity along with the number of seat belt positions in the vehicle.
Page 8: Vehicle Certification Label
These pressure levels must be maintained to assure proper handling, safety, 2. Chassis manufacture date. and fuel economy. 3. Month and year of manufacture at Winnebago ® 9. Rear Axle Wheel Configuration: Single or Industries Dual as it relates to the inflation.
Page 9: Specifications And Capacities
SECTION 1 – INTRODUCTION SPECIFICATIONS AND CAPACITIES 24VR 29TR 31CR 31JR Standard Optional ® ® ® Chalet Ford E450 Ford E450 Ford E450 ® ® Ford E350 Ford E450 Chassis Chassis Chassis Chassis Chassis Feature Number Length 30' 5" 31' 8"...
Page 10: Owner And Vehicle Information
Motor Home Serial Number __________________________________________________________ Chassis Vehicle Identification No. (VIN) ________________________________________________ Vehicle Mileage at Delivery __________________________________________________________ Selling Dealer Name ________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ ® YOUR WINNEBAGO INDUSTRIES DEALER /SERVICE CENTER Name ____________________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ Contact ____________________________________________Phone ________________________ CHASSIS SERVICE CENTER...
Page 11: 2011 New Vehicle Limited Warranty
Chassis, drivetrain and related components* Winnebago Industries, Inc. of Forest City, Iowa, warrants each new Wheels* Winnebago and Itasca motor home to the owner for recreational use Tires* in the U.S.A. and Canada as follows: Any other part or component covered by a written warranty issued by...
Page 12 If you are touring or have moved, contact any unresolved warranty disputes for recreational vehicles. This dispute Winnebago Industries motor home dealer in the United States or resolution program reviews eligible product and service related Canada for warranty service.
Page 13: Safety And Precautions
SECTION 2 – SAFETY AND PRECAUTIONS • Use care when accelerating or decelerating on GENERAL WARNINGS a slippery surface. Abrupt speed changes can cause skidding and loss of control. • Only seats equipped with seat belts are to be occupied while the vehicle is moving. •...
Page 14: Lp Gas Leaks
SECTION 2 – SAFETY AND PRECAUTIONS • All pilot lights must be extinguished and asphyxiation is greater when the appliance is appliances turned off while refilling the fuel used for long periods of time. Failure to comply tank or LP gas tank. could result in death or serious injury.
Page 15: Carbon Monoxide Warning
SECTION 2 – SAFETY AND PRECAUTIONS The best protection against carbon monoxide entry into the vehicle body is a properly maintained engine exhaust and ventilation WARNING system. It is recommended that the exhaust system and body be inspected by a qualified EXPLOSION HAZARD: DO NOT use an motor home service center: open flame to test for gas leaks.
Page 16: Smoke Alarm
RV application. We recommend obtaining a replacement from your ® Winnebago Industries dealer. Further Information Please refer to the manufacturer’s user manual provided in your InfoCase for complete operating instructions and safety precautions.
Page 17: Fire Extinguisher
We recommend obtaining a that is also listed for RV application. We replacement only from your Winnebago recommend obtaining a replacement from your ® ®...
Page 18: Loading
SECTION 2 – SAFETY AND PRECAUTIONS LOADING • Store or secure all loose items inside the motor home before traveling. Possible overlooked items such as canned goods or small appliances on the countertop, cooking pans on the range, or free-standing furniture items can become dangerous projectiles during a sudden stop.
Page 19: Slideout Rooms
SECTION 2 – SAFETY AND PRECAUTIONS To open, pull on the red plastic strap at the bottom of the window to remove the rubber cord that holds the window in place. Pull on the rubber WARNING cord until it is completely removed. This allows the window to be pushed out.
Page 20: Mold, Moisture, And Your Motor Home
If Mold Is Present, What Will natural for a motor home to be introduced into an ® Winnebago Industries environment with mold spores. If Winnebago Industries determines that mold Mold is a plant and requires its own special ® ® is present in the Winnebago...
Page 21: Roadside Emergency
SECTION 2 – SAFETY AND PRECAUTIONS The ladder on your motor home is provided ROADSIDE EMERGENCY for limited access to the roof. Walking or working on the roof should be left Because of the size and weight of this vehicle to qualified service personnel using proper safety and its tires, and the possible complications equipment in a safe environment.
Page 22: Jump Starting
(wheel lift or frame lift) type towing assembly for safe towing. ENGINE OVERHEAT ® Winnebago Industries does not assume If you see or hear steam escaping from the responsibility for damage incurred while towing engine compartment or have any other reason to this vehicle.
Page 23 SECTION 2 – SAFETY AND PRECAUTIONS NOTICE Operating a vehicle under a severe overheating condition can result in damage to the vehicle. For information on what to do in case of overheating, consult your chassis manual. 2-11...
Page 25: Driving Your Motor Home
SECTION 3 – DRIVING YOUR MOTOR HOME The information in this section refers only to features installed or adapted to the dash and driver compartment area by Winnebago ® Industries . It also includes passenger seating in the living area of the coach.
Page 26: Child Restraints
SECTION 3 – DRIVING YOUR MOTOR HOME Lap/Shoulder Belts protection of the safety belt, never let more than one person use the same safety belt at any one See your chassis manual for instructions on time, and do not let the safety belts become proper fastening, adjustment, and releasing of damaged by pinching them in the doors or in the lap/shoulder belts.
Page 27: Keys
SECTION 3 – DRIVING YOUR MOTOR HOME Further Information 3. Be certain that it is appropriate for the child's height, weight, and development. The See the child seat manufacturer’s specific instructions and/or the regulation label instructions for proper attachment and attached to the restraint typically provides this adjustment of the tether and seat belts.
Page 28 SECTION 3 – DRIVING YOUR MOTOR HOME Mirror Heat Switch Mirror Adjustment Control Mirror Pivot Lock • Mirror surface tilts in direction Unscrew protective cap and of arrow button pressed. loosen Allen head set screw • Middle switch selects L or R mirror to adjust.
Page 29: Battery Boost Switch
SECTION 3 – DRIVING YOUR MOTOR HOME Press and Hold the Battery Boost switch in the ON position while turning ignition key for Mirror Heat emergency starting power. Switch NOTE: The House/Coach Battery Disconnect switch near the entrance door must be ON and house batteries must be sufficiently charged for this feature to work.
Page 30: Radio Remote Controls
SECTION 3 – DRIVING YOUR MOTOR HOME Satellite Radio –If Equipped ® Your coach may be equipped with a Sirius satellite radio receiver that plays through your radio. See the receiver manufacturer’s information in your InfoCase for programming and operating instructions.
Page 31: Radio - In-Dash
SECTION 3 – DRIVING YOUR MOTOR HOME Radio Sound through Deluxe Sound Speakers –If Equipped To Listen to the Dash Radio through the Deluxe Sound Speakers: • Press the Speaker Selector Switch to RADIO position to connect the dash radio to the deluxe sound speakers.
Page 32: Radio Power Switch
SECTION 3 – DRIVING YOUR MOTOR HOME Satellite Radio –If Equipped ® Your coach may be equipped with a Sirius satellite radio receiver that plays through your radio. See the receiver manufacturer’s information in your InfoCase for programming and operating instructions.
Page 33: Engine Access - Interior
SECTION 3 – DRIVING YOUR MOTOR HOME ENGINE ACCESS – INTERIOR TIRES Front Engine Cover Improper tire pressure can result in tire overloading and abnormal wear and also affects • To remove cover, unlatch the two clips handling, ride characteristics, and fuel economy. (located on the upper left and right sides of the engine cover) and unlatch the two clips (located on each side of the bottom of the...
Page 34: Lights
SECTION 3 – DRIVING YOUR MOTOR HOME Further Information See the chassis manual in your InfoCase for further information. LIGHTS All exterior lights should be checked for proper operation each time the vehicle is prepared for a trip. Any bulbs which fail to light should be checked and replaced, when necessary, with a new bulb of the same size.
Page 35: Appliances And Systems
SECTION 4 – APPLIANCES AND SYSTEMS The appliances installed in your motor home are manufactured by reputable RV appliance makers and have been tested by independent laboratories to meet all applicable standards and codes set for RV appliances. See Section 2 - Safety and Precautions of this manual for any safety and precautions you need to take regarding the operation of your appliances.
Page 36: Refrigerator Service Access Compartment
SECTION 4 – APPLIANCES AND SYSTEMS To Open 1. Use a screwdriver or coin to turn the latch knobs to the vertical position as shown. Refrigerator Access Door Latches • Gas- Refrigerator will operate on gas from the propane tank if the main valve is open and the 2.
Page 37: Avoiding Asphyxiation
SECTION 4 – APPLIANCES AND SYSTEMS To Light Range Top Burners Unlike homes, the amount of oxygen supply is •Turn the desired burner knob to HI LITE position limited due to the size of the recreational vehicle, •Immediately spin the IGNITOR knob clockwise and proper ventilation when using the cooking at least one full turn to light the burner appliances avoids dangers of asphyxiation.
Page 38: Range Hood
SECTION 4 – APPLIANCES AND SYSTEMS RANGE HOOD -If Equipped The range hood vent draws cooking odors and airborne grease particles into the filtration grid and either recirculates the air or vents it to the outside of the coach, depending on model. A light on the underside of the hood provides illumination for cooking and food preparation.
Page 39: Water Heater - Gas/ Electric
SECTION 4 – APPLIANCES AND SYSTEMS The propane level is registered by a sending NOTE: Some models may be equipped with a unit on the tank. The gauge mounted on the side Water Pump switch in the water service of the tank will give a more accurate indication of center on the outside of the coach or actual tank level if needed.
Page 40: Pressure-Temperature Relief Valve
SECTION 4 – APPLIANCES AND SYSTEMS Further Information Read the operating and safety information provided in the Water Heater Operation Manual in your InfoCase. PRESSURE-TEMPERATURE RELIEF VALVE On occasion, water may be seen seeping from the water heater pressure temperature relief valve.
Page 41: Propane Gas Furnace
SECTION 4 – APPLIANCES AND SYSTEMS 2. Open a faucet in the motor home to relieve water pressure. 3. Pull the handle of the P-T valve straight out and allow water to flow until it stops. Thermostat/Switch Room Temperature •Move from OFF to Thermometer desired temperature •Lift handle straight out to open P-T valve...
Page 42 SECTION 4 – APPLIANCES AND SYSTEMS and periodic maintenance. See the Coach 5. The furnace should now cycle off and on Maintenance Schedule for recommended automatically as the thermostat demands just intervals. like a household furnace. NOTE: If the furnace burner has any residuals NOTE: If heat does not come out of the heat of metal protectant or lubricants used ducts after a minute or so the burner is...
Page 43: Furnace-A/C Thermostat Operation Chart
SECTION 4 – APPLIANCES AND SYSTEMS FURNACE-A/C THERMOSTAT OPERATION CHART The following chart shows the system functions with the “Heat/Cool” thermostat. Disregard references to heat functions when using the “Cool Only” thermostat in the rear bedroom. X = Switch Position O = Switch position does not matter or is inactive for this feature FAN MODE FAN SPEED...
Page 44: Air Conditioner Filter
SECTION 4 – APPLIANCES AND SYSTEMS AIR CONDITIONER FILTER The washable foam filter should be checked monthly for dirt build-up and cleaned or replaced as needed. It is located in the ceiling mounted return A/C grille in the lounge area. 4-10...
Page 45: Propane Gas
SECTION 5 – PROPANE GAS PROPANE GAS SUPPLY The propane gas system supplies fuel for the gas range/oven, water heater, furnace, and refrigerator (while in gas mode). When used and handled properly, this system is safe and economical and provides modern living conveniences wherever you travel.
Page 46: Safe Use Of The Propane Gas System
SECTION 5 – PROPANE GAS phone directory yellow pages for locations of local propane gas refilling stations or bulk dealerships. DAN G E R NOTE: If you travel outside the U.S. with your motor home, you may find butane or DO NOT FILL CONTAINER TO MORE propane/butane mixtures available in THAN 80 PERCENT OF CAPACITY.
Page 47: Propane Gas Leaks
SECTION 5 – PROPANE GAS • Exercise caution at all times. Be familiar with PROPANE GAS WARNINGS the distinctive odor of propane gas. If a leak is AND PRECAUTIONS suspected, turn off the supply valve immediately. Have the propane gas system It is illegal for vehicles equipped with propane checked by your dealer or other qualified tanks to travel on certain roadways or through...
Page 48: Propane Gas Pressure Regulator
SECTION 5 – PROPANE GAS WARNING WARNING Propane cylinders shall not be placed or Visually inspect the pressure regulator stored inside the vehicle. Propane vent periodically for blockage by cylinders are equipped with safety accumulated debris or insect nests, etc. devices that relieve pressure by Vent obstruction could result in excessive discharging propane to the atmosphere.
Page 49: Propane Vaporization In Cold Weather
SECTION 5 – PROPANE GAS This means that in extremely cold weather when a large volume of gas is being used by the furnace for heating, it is possible to experience a loss of gas pressure. At first, this problem may appear to be caused by an empty tank or a regulator freeze-up, but is actually caused by failure of the liquid gas to vaporize as fast as it is needed by the furnace.
Page 51: Electrical
SECTION 6 – ELECTRICAL Your coach is equipped with an electrical the power converter automatically changes a system consisting of two separate voltages: portion of the 120-volt current to 12-volt DC current. All equipment in the motor home that is •...
Page 52: Power Center
SECTION 6 – ELECTRICAL The three-prong power cord is designed to ground the electrical system through the receptacle. It is also designed to carry the amperage output of most campground outlets. 30 Amp Receptacle • Route power cord through passage and close door while shoreline is If the electrical receptacle to be used is connected to outlet.
Page 53: Charging Section
SECTION 6 – ELECTRICAL condition of the battery. If it is below “full 12-Volt 120-Volt charge”, the Charging Section will start charging House Fuses Circuit Breakers the batteries. If the house batteries have been extremely discharged, they will accept charge at a relatively high amperage rate.
Page 54: Electrical Outlets - House 120-Volt Ac
SECTION 6 – ELECTRICAL “Off” and back to “On”. If the breaker is If the GFCI keeps tripping, have the electrical continually tripped and no overload is evident, system checked and repaired, if necessary, before have the system checked for a short in the wiring using again.
Page 55: Operation Warnings And Cautions
SECTION 6 – ELECTRICAL To use the 120-volt generator, plug the power Refer to the hourmeter to determine when cord into the generator receptacle within the periodic maintenance is due and to record utility compartment before starting the generator. services which have been performed. Operation Warnings and Cautions WARNING The exhaust of all internal combustion...
Page 56: House/Coach Battery Disconnect Switch
SECTION 6 – ELECTRICAL Converter Always leave this switch ON while using the coach. See “Power Center.” NOTE: Some electronic displays and memory Chassis Battery functions may need to be reset after The chassis battery is used to operate the power has been reconnected.
Page 57: Battery Care
SECTION 6 – ELECTRICAL The two best defenses against sulfating and insufficient charge are to: 1. Turn off the House/Coach Battery Disconnect switch to avoid parasitic discharge (the trickle House Batteries discharge caused by directly connected components like propane gas detectors or digital clock displays, etc.) 2.
Page 58: Circuit Breakers And Fuses - House 12-Volt Dc
SECTION 6 – ELECTRICAL • Make sure battery cable clamps are tight on the terminal posts and are free of corrosion. WARNING • Neutralize corrosion buildup or acid film on top of battery by washing with a baking soda/ water solution. Rinse with clear water. To prevent wiring damage, it is essential when replacing the cables on the battery, NOTE: Make sure vent caps are on securely to...
Page 59: Volt Fuse Panel
SECTION 6 – ELECTRICAL 12-Volt Fuse Panel 12-Volt House Fuses 12V Fuse Panel (Located on the right-hand side of the power converter) -Typical View The fuse panel accepts only blade type plug-in fuses. Always replace fuses with those of the same amperage rating.
Page 61: Plumbing
SECTION 7 – PLUMBING 2. Attach an RV city water hose from the FRESH WATER SYSTEM external water source to the city water connection typically located in the water The fresh water system provides water to the service compartment or on the left sidewall of galley sink, shower, bathroom lavatory, toilet and your vehicle.
Page 62: Water Pump
SECTION 7 – PLUMBING Water pressure regulators are commonly available at most RV dealerships and many large retail discount or home supply centers. WATER PUMP When your coach is not connected to a city water supply, water is supplied from the fresh water tank by a water system demand pump.
Page 63: Disinfecting Your Fresh Water System
SECTION 7 – PLUMBING 2. Turn water pump switch to “OFF” position. 3. Fill water tank. 4. Open all faucets, hot and cold. WARNING 5. Turn on water pump switch. 6. Close each faucet as it begins to deliver a Chlorine is poisonous.
Page 64: Shower Hose Vacuum Breaker
SECTION 7 – PLUMBING • Chlorine may be removed from drinking • Don’t dispose of sanitary napkins or other water by the cold water filter at the galley non-dissolving items in the toilet. faucet (if equipped) or by installing an •...
Page 65: Dumping Holding Tanks
SECTION 7 – PLUMBING Dumping Holding Tanks Sewage Drain Outlet/Dust Cap Holding Tank Dump Valves (Located in mid-driver side access compartment) 1st - Pull Black 2nd - Pull Gray -Typical View Waste Tank Drain Waste Tank Drain valve to drain valve to drain 1.
Page 66: Holding Tank Level Indicators
SECTION 7 – PLUMBING 7. Rinse sewage drain hose thoroughly with water and stow. NOTE: We recommend that you dump all holding tanks before traveling to avoid carrying unnecessary weight. Using On-Site Sewer Hook-Ups The sewage drain hose may remain attached to the dump outlet and be routed out the bottom of the compartment while the motor home is parked Holding Tank Heater Switch...
Page 67 SECTION 7 – PLUMBING D R A I N D R A I N C L O S E C L O S E L I N E - E N D V A L V E I N - L I N E V A L V E Waterline Drain Valves (Typical)
Page 68 SECTION 7 – PLUMBING 5. Drain Toilet. Press the toilet flush pedal and WINTERIZING PROCEDURE hold until water stops flowing in the toilet. Then turn water pump switch off. You can winterize the water and plumbing system of your coach using one of the following 6.
Page 69 NOTE: It is not necessary to add antifreeze to the system. A “blow-out” plug can be the toilet since the flush valve will be ® ® purchased at any Winnebago or Itasca closed. dealer. Do not add automotive antifreeze or...
Page 70 SECTION 7 – PLUMBING water system antifreeze through the plumbing system. Siphon Tube This product is available from your (insert into dealer and from most RV supply stores container of and national retail outlets. RV water Follow directions on the container to system determine the correct amount to use for antifreeze)
Page 71 SECTION 7 – PLUMBING 10. Replace the protective cap onto the end of the 13. Pour about one cup of RV antifreeze down antifreeze siphon tube to keep out insects or each drain for the galley sink, lavatory sink, debris when not in use. and shower/tub.
Page 72: Water Heater Bypass Valve
SECTION 7 – PLUMBING 24VR Waterlines: • Two (2) valves beneath shower. Access through removable panel on lower front of shower cabinet. • Two (2) valves beneath the bed mattress. Lift mattress to access. Water Tank: One (1) valve beneath the bed mattress. Lift mattress to expose access hole.
Page 73: Entertainment
SECTION 8 – ENTERTAINMENT VIDEO SELECTION SYSTEM –If Equipped The video selection system allows you to • The Video Selection System allows you to switch the antenna, AUX/VCR, cable TV, watch DVD’s from either the lounge area satellite TV, or DVD signal to any TV set (main TV), bedroom, or the exterior location in the coach.
Page 74: Front Tv Ignition Switch Interlock
SECTION 8 – ENTERTAINMENT FRONT TV IGNITION SWITCH INTERLOCK –If Equipped If your coach is equipped with a front overhead TV, it is plugged into a special electrical outlet with a built-in ignition switch interlock. The device allows the front overhead TV to operate only when the ignition key is in the Off or Accessory positions.
Page 75: Dvd Player
SECTION 8 – ENTERTAINMENT • Press INPUT/SOURCE NOTE: Turn the volume level up significantly on button on front of TV or the DVD player when using the home remote and select theater as an amp for the TV through the “VIDEO 1”...
Page 76 SECTION 8 – ENTERTAINMENT • The TV screen will display • Turn on 12-volt master power switch (located the DVD player logo when on the underside of the video cabinet). the correct input is selected. NOTE: When TV or DVD are not in use, power switch should be Play DVD turned off to avoid drain on...
Page 77: Flip-Down Screen Video Players
SECTION 8 – ENTERTAINMENT 12-Volt Master Power FLIP-DOWN SCREEN VIDEO • The Video Players operate on PLAYERS 12-volt DC current. Turn on the (Rear Bunk models only) 12-volt master power (TV) switch shown, located on the –If Equipped backwall of the top bunk. The flip-down LCD screen DVD Video NOTE: To avoid drain on the 12-volt house Players are mounted overhead in each of the bunk...
Page 78: Tv Antenna
SECTION 8 – ENTERTAINMENT Raising Antenna to Operating • Insert the CD label side down (facing you) into the slot on the side of the player. The Position player will automatically switch to proper Turn elevating crank clockwise in “UP” mode to play audio or video CD.
Page 79: Tv Signal Amplifier
TV Signal Amplifier Switch on are located in the entertainment center cabinet. Video Selection System ® See your authorized Winnebago Industries dealer for proper installation and sealing of roof Checking Amplifier Performance mounted components. The TV signals available to an RV are entirely dependent on its location in relation to the transmitter (tower).
Page 80 SECTION 8 – ENTERTAINMENT High Definition Accessory Connection Cables (Located in cabinet near TV)
Page 81: Furniture And Softgoods
SECTION 9 – FURNITURE AND SOFTGOODS SLEEPING FACILITIES WARNING Do not exceed 225 lbs. maximum weight capacity. Misuse of ladder could result in death or serious injury. See Operators Manual before using ladder. WARNING • Maximum Capacity: 225 lbs. Sleeping facilities are not intended for use while vehicle is in motion.
Page 82: Sofa/Bed Conversion
SECTION 9 – FURNITURE AND SOFTGOODS DINETTE/BED CONVERSION –If Equipped (Typical view – your coach may differ) Dinette to Bed •Lower ladder to floor. •Make sure top of ladder ladder is properly engaged onto retainer brackets and ladder is resting firmly on floor before using.
Page 83: Comfort Sofa Sleeper
SECTION 9 – FURNITURE AND SOFTGOODS 3. Arrange dinette cushions to cover bed area. COMFORT SOFA SLEEPER –If Equipped (Typical View) Sofa to Bed 1. Remove sofa back cushions. Bed to Dinette 1. Reattach the table onto the wall support and lower the table leg.
Page 84 SECTION 9 – FURNITURE AND SOFTGOODS 3. Rotate the lever lock (located on the bottom right-hand side of the sofa air bed) clockwise to release the locking mechanism (which is required to unfold the bottom section of the sofa air bed). 6.
Page 85 SECTION 9 – FURNITURE AND SOFTGOODS Adjusting the Left and Right Chambers for 2. Fold in the bottom section of the air mattress. Individual Firmness Left Right Chamber Chamber 3. Lift up the bottom section of the sofa air bed and bring all the way up.
Page 86: Pleated Blinds
SECTION 9 – FURNITURE AND SOFTGOODS Tension Adjustment 4. Rotate the lever lock counter-clockwise, securing back to the locked position. The tension of the pleated blinds can be adjusted if they become loose and will not stay up when raised, or they are too tight and are difficult to raise and lower.
Page 87: Wood Furniture And Cabinetry
People are drawn to the natural beauty of and the wood is considered part of the natural ® wood. At Winnebago Industries , our craftsmen aging process and is not to be considered defect work with the art found in each piece of wood to or damage.
Page 89: Slideout Rooms
SECTION 10 – SLIDEOUT ROOMS SLIDEOUT ROOM TRAVEL LOCK –If Equipped Some models are equipped with an expandable prop-lock rod device to restrict movement of the slideout room while the vehicle is in motion. The Lock Rod must be released before extending the room or damage to the coach will result.
Page 90 SECTION 10 – SLIDEOUT ROOMS • Unhook the strap end peg from the mooring bracket on the floor and wall edge. Store strap in location of your choice. Slideout Room Keylock The key to turn the master keylock “off” is attached to the lock rod.
Page 91: Slideout Room Operation - Electric
SECTION 10 – SLIDEOUT ROOMS NOTE: We recommend that you KEEP THE SLIDEOUT ROOM OPERATION ENGINE RUNNING WHILE – ELECTRIC EXTENDING OR RETRACTING SLIDEOUT ROOMS so the engine alternator can provide maximum power for proper operation of the slideout WARNING mechanisms.
Page 92: Slideout Room - Extreme Weather Precaution
SECTION 10 – SLIDEOUT ROOMS Extend Procedure: If it has rained recently before you retract the slideout room, we recommend using the See “Before Extending!” before proceeding. hydraulic leveling system (if equipped) to lean • Start the engine so the alternator can provide the coach and drain off any excess water possibly maximum power for proper operation of remaining on the roof before retracting.
Page 93: Slideout Room Troubleshooting - Electric
SECTION 10 – SLIDEOUT ROOMS Problems Retracting the Room slideout room cover-awning (if equipped) or reduce effectiveness of the slideout room weather • Set the Park Brake if the Engage Park Brake seals. light flashes while pressing the Retract (IN) button.
Page 94 SECTION 10 – SLIDEOUT ROOMS Problems Extending the Room retraction method or the fully manual method. Both methods listed below are intended as a • Set the Park Brake if the Engage Park Brake means to retract the room to prepare the coach for light flashes while pressing the Extend (OUT) travel to the nearest authorized service center.
Page 95: Slideout Emergency Retraction - Electric
SECTION 10 – SLIDEOUT ROOMS Further Information See the slideout room operating guide included in your InfoCase for further instructions and troubleshooting information. SLIDEOUT EMERGENCY RETRACTION – ELECTRIC (Front Slideout Room) Crank-In Mode If the room mechanism is malfunctioning and will not retract using the buttons, you will need to manually crank the room in to the travel position.
Page 96: Slideout Emergency Retraction - Bedroom
SECTION 10 – SLIDEOUT ROOMS NOTICE Never crank one side more than 2 inches (50 mm) ahead of the other while retracting or extending. • Crank the room in until it is just “snugged up”. Do not overcrank or you could damage the crank or gear assembly.
Page 97: General Slideout Care
SECTION 10 – SLIDEOUT ROOMS the shaft. When this happens, you must raise the bed, remove the access cover to access the gear endshaft, and continue using the wrench and hex shaft only as shown. • Attach the shaft extension to hex-end shaft and place the ratchet wrench onto the hex end shaft, then insert into the hole in the bed base as shown.
Page 99: Maintenance And Storage
• Have the sealant replaced if you notice any of attention. Delaying these repairs may allow water the above. Your local Winnebago Industries leakage and result in damage to interior ceiling dealer has the correct and necessary parts and and body panels, upholstery, etc., which is not experience to help you maintain your sealants.
Page 100: Exterior Finish
SECTION 11 – MAINTENANCE AND STORAGE weight to the vehicle. This, in effect, reduces the • Wash with cool water out of direct sunlight amount of cargo you can carry and remain within using a mild liquid soap (any “no-tears” baby GVWR and GAWR limits.
Page 101: Care Of Appliques And Decals
SECTION 11 – MAINTENANCE AND STORAGE If the finish begins to look dull or discolored, CARE OF APPLIQUES AND it may need to be cleaned with a polishing or DECALS cleaning compound formulated for gel-coated fiberglass finishes. The pressure-sensitive appliques and decals on your coach require very little maintenance.
Page 102: Exterior Lights
SECTION 11 – MAINTENANCE AND STORAGE EXTERIOR LIGHTS ® Most Winnebago Industries vehicles have NOTICE polycarbonate lenses on exterior lamps, which are very sensitive to a variety of chemical Do not use citrus-based cleaners on solvents and cleaners. polycarbonate finishes. Citric compounds...
Page 103: Vinyl Fabrics
SECTION 11 – MAINTENANCE AND STORAGE shades should be closed when the motor home is parked for an extended period of time. WARNING When cleaning upholstery and fabric, do not use lacquer thinner, nail polish remover, laundry soaps, or bleach. Never use carbon tetrachloride, gasoline, or naphthalene for any cleaning purpose.
Page 104: Ceiling Fabric Care
SECTION 11 – MAINTENANCE AND STORAGE Most commercially available carpet and CEILING FABRIC CARE upholstery cleaners will do an excellent job removing stains. From time to time, additional While using your coach, your ceiling fabric cleaning methods may need to be used to remove may become soiled and require spot cleaning stubborn or difficult stains.
Page 105: Cabinetry - Cleaning
SECTION 11 – MAINTENANCE AND STORAGE You may have to repeat this procedure more than once to achieve desired results. Finish up with clean water, using the same method, and blot dry. Steam cleaning is also an option. Again, take care not to over-saturate the material.
Page 106: Range And Refrigerator
SECTION 11 – MAINTENANCE AND STORAGE Clean and Prep Coach for Storage RANGE AND REFRIGERATOR 1. Turn off the propane gas tank. For care and appearance maintenance of the 2. Turn the Electronic Thermostat switch OFF. range and refrigerator, refer to the appliance 3.
Page 107: Vehicle Storage - Removal
SECTION 11 – MAINTENANCE AND STORAGE 9. Inspect all seams and seals around doors, 9. After flushing fresh waterlines, install a new windows, vents, and any other joints. Replace water filter cartridge on the galley sink water or repair any that are damaged. Sealing filter and/or full-coach water filteration materials and compounds can be purchased system (if equipped).
Page 108: Chassis Service And Maintenance
SECTION 11 – MAINTENANCE AND STORAGE CHASSIS SERVICE AND MAINTENANCE Consult the appropriate sections in your chassis manual for specific information regarding operating safety, service recommendations, and maintenance schedules for the chassis section of your motor home. 11-10...
Page 109: Coach Maintenance Chart
SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System Have propane gas system checked for leaks Pressure Regulator - inspect and adjust if needed Check propane tank condition, mounting, and fittings...
Page 110 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items: Headlights, Taillights, and Marker Lights Turn Signals...
Page 111 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants Inspect (see “Sealants”...
Page 113: Miscellaneous
SECTION 12 – MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motor home’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available space when loading your motor home.
Page 114 SECTION 12 – MISCELLANEOUS Corner Weighing (Side-to-Side) You will first drive only your front wheels onto the scale pad, then drive ahead so that the The most accurate method of weighing a whole vehicle is on the scale, then finally pull off motor home is to weigh each “corner”...
Page 115: Car Or Trailer Towing
SECTION 12 – MISCELLANEOUS axle is 12,000 lbs., then the load on each rear dual listed Gross Weight Ratings. See “Vehicle set (left rear duals or right rear duals) should not Certification Label” in the Introduction section exceed 6,000 lbs. for information on gross weight ratings.
Page 116: Trailer Wiring Connector
SECTION 12 – MISCELLANEOUS Before descending a steep or long grade when TRAILER WIRING towing a trailer, reduce speed and shift into a CONNECTOR lower gear to control vehicle speed. Avoid prolonged or frequent application of brakes, Your coach is pre-wired for trailer or car which could cause overheating and brake failure.
Page 117: Entry Step - Manual
350 vehicle drive train: engine and cooling systems, lbs. All Winnebago Industries models transmission, drive line, drive axle, and others. equipped with a Class IV hitch have a...
Page 118: Entry Step - Electric
SECTION 12 – MISCELLANEOUS ENTRY STEP – ELECTRIC –If Equipped WARNING Do not use step unless fully extended. Do NOT stand on step when vehicle ignition switch is turned to either the “On” or “Start” position. The step will automatically retract, which may cause personal injury.
Page 119: Manual Awning
SECTION 12 – MISCELLANEOUS The ladder on your vehicle is provided for MANUAL AWNING limited access to the roof. –If Equipped Walking or working on the roof should be left to qualified service personnel using proper safety equipment in a safe environment. You should Further Information only walk or work on the roof if you are qualified For complete operating instructions, refer to...
Page 120: Windows
SECTION 12 – MISCELLANEOUS Horizontal Slider Windows WINDOWS Swing the latch handle straight out or up (depending on the style of window). Grasp the Crank-Out Windows sliding window edge frame and slide the window • Turn the crank-out handle from the horizontal to the side.
Page 121: Effects Of Prolonged Occupancy
SECTION 12 – MISCELLANEOUS Further Information Dome Crank Fan Speed Fuse See the power ventilator manufacturer’s Knob Selector operating instructions supplied in your InfoCase for further instructions, care, and cleaning information. EFFECTS OF PROLONGED OCCUPANCY Your motor home was designed primarily for recreational use and short-term occupancy.
Page 123 INDEX 2011 New Vehicle Limited Warranty ..1-7 Entry Step – Manual ........12-5 About this Manual ........1-1 Exterior Finish ........... 11-2 Air Conditioner Filter ........ 4-10 Exterior Lights ........... 11-4 Air Conditioner/Heater – External Power Cord ........6-1 Automotive (Dash) ........
Page 124 Index Pressure-Temperature Relief Valve ..... 4-6 Tires ............. 3-9 Propane Gas Furnace ........4-7 Toilet ............7-4 Propane Gas Furnace ........4-8 Tool and Ladder Storage ......12-7 Propane Gas Leak Detector ......2-2 Towing Guidelines ........12-4 Propane Gas Pressure Regulator ....5-4 Trailer Wiring Connector ......

This manual is also suitable for:

2010 impulse

Winnebago Chalet Operator's Manual

1 Introduction

2 Safety and Precautions

3 Driving Your Motor Home

4 Appliances and Systems

5 Propane Gas

6 Electrical

7 Plumbing

8 Entertainment

9 Furniture and Softgoods

10 Slideout Rooms

11 Maintenance and Storage

12 Miscellaneous

Quick Links

TABLE OF CONTENTS

Need help?

Questions and answers

Related Manuals for Winnebago Chalet

Summary of Contents for Winnebago Chalet

This manual is also suitable for:

Table of Contents