Testing And Fault Isolation; General; Troubleshooting; Abnormal Operation Troubleshooting Procedures - Superior Vantage Engine O-360 SERIES Maintenance Manual

General

This section provides
procedures. Review all probable causes given.
The engine electrical diagram and engine oil
system schematic should be referenced as an
additional aid in determining probable cause.
Table 72-00-01.1 • Abnormal Operation Troubleshooting Procedures
Engine will not start
Rough Idling
Engine Not Able to Develop Full Power
Rough Engine Operation
Low Power and Engine Runs Rough
Low Oil Pressure On Engine Gage
High Oil Temperature
Excessive Oil Consumption

Testing and Fault Isolation

WARNING: OPERATION OF A DEFECTIVE
ENGINE WITHOUT
EXAMINATION CAN
DAMAGE TO A DISABLED COMPONENT
AND POSSIBLE INJURY TO PERSONNEL.
MAKE SURE THOROUGH INSPECTION AND

TROUBLESHOOTING

ACCOMPLISHED. THIS WILL HELP TO
PREVENT INJURIES
AND/OR DAMAGE TO THE EQUIPMENT.
WARNING: HOT OIL MAY CAUSE BURNS TO
EYES AND SKIN.
GOGGLES, INSULATED
OTHER PROTECTIVE GEAR.
EYE CONTACT, FLUSH WITH WATER FOR
15 MINUTES AND
© March 2006 Superior Air Parts Inc.
Maintenance Manual
O-360 and IO-360 Series Engines
TESTING AND FAULT ISOLATION
the Fault Isolation
Symptom
A PRELIMINARY
CAUSE FURTHER
PROCEDURES ARE
TO PERSONNEL
PUT ON SPLASH
GLOVES, AND
IN CASE OF
SEEK MEDICAL
Electrical testing is limited to continuity checks of
the ignition wiring harness.
•
Special tools and equipment are listed in
Table 01-00-01.1.
•
The Abnormal Operation Troubleshooting
Procedures are listed in Table 72-00-01.2.
ATTENTION. IN CASE OF SKIN CONTACT,
WASH WITH SOAP AND WATER.
WARNING: FUEL
FLAMMABLE. DO NOT BREATH VAPORS.
USE IN A WELL-VENTILATED AREA FREE
FROM SPARKS,
SURFACES. PUT ON SPLASH GOGGLES,
SOLVENT-RESISTANT
OTHER PROTECTIVE GEAR.
EYE CONTACT, FLUSH WITH WATER FOR
15 MINUTES
ATTENTION. IN CASE OF SKIN CONTACT,
WASH WITH SOAP AND WATER.
NOTE: The Fault Isolation sequence is in order
of approximate ease of checking, not
necessarily in order of probability.
1
Table
72-00-01.3
72-00-01.4
72-00-01.5
72-00-01.6
72-00-01.7
72-00-01.8
72-00-01.9
72-00-01.10
IS TOXIC
FLAME, OR
GLOVES,
IN CASE OF
AND SEEK MEDICAL
72-00-01
Testing and Fault Isolation
AND
HOT
AND