Maintenance And Tune-Up Procedures; Fuel Hose; Engine Idle Speed - Suzuki VL1500K5 Supplementary Service Manual

8 VL1500K5 ('05-MODEL)
MAINTENANCE AND TUNE-UP PRO-
CEDURES
This section describes the servicing procedures for each Peri-
odic Maintenance item which differ from those of the VL1500K4
('04-MODEL).
For details other than the following items, refer to the VL1500
Service Manual.

FUEL HOSE

Inspect every 6 000 km (4 000 miles, 12 months).
Replace every 4 years.
• Remove the seats 1. (!Page 121)
• Remove the speedometer and fuel inlet cover 2.
(!VL1500 Service Manual 6-3)
• Remove the left frame head cover 3 and left frame upper
cover 4. (!VL1500 Service Manual 6-3)
Inspect the fuel feed hose A for damage and fuel leakage. If
any defect is found, the fuel feed hose must be replaced.

ENGINE IDLE SPEED

Inspect initially at 1 000 km (600 miles, 2 months) and
every 6 000 km (4 000 miles, 12 months).
NOTE:
Warm up the engine before adjusting the engine idle speed.
• Adjust the throttle cable play.(!Page 9)
• Remove the left frame upper cover.
(!VL1500 Service Manual 6-3)
• Start the engine, turn the throttle stop screw 1 and set the
engine idle speed as follows.
• Connect the multi-circuit tester to the high-tension cord.
" Engine idle speed: 1 000 ± 100 r/min
# 09900-25008: Multi-circuit tester set