Check Spark Plug; Change Fuel Filter; Change Hydraulic System Filter - Gizmow Formula Operator's Manual

Maintenance & Adjustment
Service Interval: 80 hrs.
a. Stop engine, wait for all moving parts to stop, and remove key.
b. Inspect the intake air-cooling screen for the engine. Clean any debris from the
screen. If debris is present behind the screen, you will have to remove it and
clean. Also clean dust, dirt and oil from external surfaces of engine, which can
cause improper cooling.
c. Make sure the intake air-cooling screen is properly reinstalled. Operating the
engine without this will cause engine damage due to overheating.

5.1.22 Check spark plug

Service Interval: 160 hrs.
a. Remove spark plug, check condition and reset gap, or replace with new plug.
See Engine Owners Manual.

5.1.23 Change fuel filter

Service Interval: As Required
a. A fuel filter is installed between the
fuel tanks and the engine. Replace
when necessary. For Kohler engines
use Kohler P/N 2405002.

5.1.24 Change hydraulic system filter

Service Interval: After First 25 hrs.
Then every 400 hours or yearly whichever comes
first.
NOTE: Use only Gizmow Part No. H18118
a. Stop engine, wait for all moving parts
to stop, and remove key.
b. Locate filter under right side of the
frame.
c. Carefully clean area around filter. It is
very important
contamination enter the hydraulic system.
d. Unscrew filter to remove and allow oil to drain from reservoir.
IMPORTANT: Before reinstalling new filter, fill it with Mobil 1 15W-50 and apply a thin
coat of oil on the surface of the rubber seal.
e. Turn the filter clockwise until rubber seal contacts the filter adapter then
tighten the filter an additional 2/3 to 3/4 turn.
f. Fill reservoir as stated in Section 6.1.10.
g. Raise the rear of machine up and support with jack stands (or equivalent
support) just high enough to allow drive wheels to turn freely.
h. Start the engine and move throttle control ahead to full throttle position.
Depress the forward pedal to full speed and run for several minutes. Shut
down machine and re check oil level. Add as needed.
34
that no dirt or
Formula - 20071