Maintenance And Storage - Gizmow Formula Operator's Manual

• Before dumping the grass catcher.
1.4.13 Before stopping the engine, place the throttle control midway between the slow
and fast positions. Allow the engine to run a minimum of 15 seconds; then stop the
engine.
1.4.14 The fuel system is provided with a shut-off valve. The fuel shut-off valve is used
to shut off the fuel:
• When the machine will not be used for a few days.
• During transport on the trailer, to and from the job site.
• Whenever parked inside a building.
1.4.15 This mower was designed for use by one operator only. Keep all others away from
mower during operation.
1.4.16 Do Not mow with the discharge deflector raised, removed, or altered unless
there is a grass collection system or mulch kit in place and working properly.
1.4.17 Be aware of the mower discharge and direct discharge away from others.
1.4.18 Do Not operate the mower under the influence of alcohol or drugs.
1.4.19 Use extra care when approaching blind corners, shrubs, trees, or other objects
that may obscure vision.
1.4.20 If jump starting is required:
a. Connect the positive (+) power cable from the positive post on the booster
battery to the positive terminal post on the starter solenoid switch (this post
has the positive battery cable attached to it).
b. Connect the negative or ground cable (-) from the negative post on the
booster battery to any engine deck ground, preferably the engine block as far
away from the battery as possible.
c. Start the machine.
d. Disconnect battery cables in the reverse order after starting.
1.1

MAINTENANCE AND STORAGE

1.1.1 For engine maintenance, follow the engine manufacturers recommendations
precisely as stated in the engine manual.
1.1.2 Disconnect the battery cable from the negative battery post when the unit will be
allowed to sit for more than 30 days without use.
1.1.3 Allowing batteries to stand for an extended period of time without recharging
them will result in reduced performance and service life. To preserve optimum battery
performance and life, recharge batteries in storage when the open circuit voltage drops to
12.4 volts. Note: To prevent damage due to freezing, battery should be fully charged
before putting away for winter storage.
1.1.4 Keep engine, engine area, and hydraulic pump area free from accumulation of
grass, leaves, excessive grease or oil, and other debris which can accumulate in these
areas. These materials can become combustible and may result in a fire.
1.1.5 Store fuel in a container specifically designed for this purpose in a cool, dry place.
1.1.6 Keep the mower and fuel container in locked storage to prevent children from
playing or tampering with them.
1.1.7 Gasoline powered equipment or fuel containers should not be stored in a
basement or any enclosed area where open pilot lights or heat appliances are present.
1.1.8 Maximum mowing results and safety can only be achieved if the mower is
Formula - 20071
Introduction
9