Related Manuals for Aarrow Signature Inset 5
Summary of Contents for Aarrow Signature Inset 5
- Page 1 Operating & Installation Manual Signature Inset 5 PLEASE RETAIN THIS GUIDE FOR FUTURE REFERENCE Rev. 06 BK075 October2009 Part No. AFS1397 EN 13240:2001+ Amd. A2:2004...
- Page 2 Should you have any questions about our Signature Inset stoves that are not covered by this manual, please contact The Aarrow retailer in your area, or call our technical support department on 0844 847 5107. All Aarrow Signature Inset stoves are approved to European Standard EN 13240 and CE marked.
-
Page 3: Table Of Contents
Chimney Sweeping Door Glass Outer Finish Summer Storage / Non Usage Adjusting The Door Hinges Fuel Retainer Inspection Fire Door Rope Replacement 18-19 Fire Door Glass Replacement 18-19 Disassemble The Primary Air Control Service Record Aarrow Signature Inset 5 Page 3... -
Page 4: Warning Notice
MUST NOT BE BURNED IN THIS APPLIANCE BITUMINOUS HOUSE COAL SHOULD NEVER BE USED IN YOUR STOVE TO USE THESE FUELS WILL INVALIDATE THE APPLIANCE GUARANTEE. IF IN DOUBT CONTACT THE SOLID FUEL ASSOCIATION TELEPHONE NUMBER 0845 601 4406 www.solidfuel.co.uk Page 4 Aarrow Signature Inset 5... -
Page 5: Introduction
• Avoid upper body/top heavy bending. Do not lean forwards or sideways when Aarrow stoves are also fitted with an ‘air wash’ handling the fire so called because it provides a curtain of high •... -
Page 6: Check List
(not to scale) Inset 5 1. Fuel Retainer 2. Throat Plate 3. Side Liner 4. Back Liner 5. Wood Burning Tray 6. Tertiary Air Bar 7. Ash Pan 8. Operating Tool 9. Instruction Manual Page 6 Aarrow Signature Inset 5... -
Page 7: Data Plate Information
DATA PLATE INFORMATION Data Plate Information Please Note : The Aarrow Signature 5 stove is fitted with a data plate located on the bottom of the right hand leg as shown opposite. The data given is that registered on the HETAS website, stating the output and performance of the stove. -
Page 8: Technical Data
Depth From Fire surround (mm) (Inc. handle) Distance to combustible material surrounding the appliance (mm) Height to shelf above the appliance Weight Nett (kg) Weight Packed (kg) Standard Chair-brick Size Fitting 16” & 18” Page 8 Aarrow Signature Inset 5... -
Page 9: Installation
See page 10 for detailed image ASBESTOS All Aarrow stoves contain no asbestos in there manufacture or construction. If there is a possibility AIR FOR COMBUSTION of disturbing any asbestos in the course of the... -
Page 10: Hearth
Decorative fire surround ( Non-combustible ) Non-combustible sealing rope ( See page 12 ) Insulating infill Fire back To BS 1251:1987 Superimposed hearth Expansion joint Thin straw board or corrugated cardboard etc. Constructional hearth Page 10 Aarrow Signature Inset 5... -
Page 11: Flues & Chimneys
BS British Standards are given in the “ General chimney should be installed in accordance with Precautions” section of these instructions. Building Regulations and BS 7566: Parts 1 to 4. Chimneys should be as straight as possible. Horizontal runs should be avoided. Aarrow Signature Inset 5... -
Page 12: Sealing The Back Of The Signature 5 Stove
Telephone : 0800 0924019 www.nace.org.uk NACS (National Association of Chimney Sweeps) Telephone : 01785 811732 www.chimneyworks.co.uk HETAS (Official Body To Approve Solidfuel Domestic Heating Appliances) Telephone : 0845 6345626 www.hetas.co.uk Detail A Rope Seal Fitted Page 12 Aarrow Signature Inset 5... -
Page 13: Firebox Liner Panels
INSTALLATION FIREBOX LINER PANELS The Aarrow Signature Inset 5 stoves use firebox liner panels to the sides and back. See fig 2 The throat plate sits on top of the sides and rear panels. These should come fitted to your stove, if however they are not, proceed as follows to fit them. -
Page 14: Optional Securing Bolts
INSTALLATION MASONRY FIXING BOLTS FINAL CHECK LIST The Signature Inset 5 is supplied with masonry fixing Before handing over the installation to the bolts to allow the installer to bolt the stove in place, to customer it is requirement under Document J that the back of the chair brick if required. -
Page 15: Building Control Consent Checklist
I/We the undersigned confirm that the above details are correct. In my opinion, these works comply with the relevant requirements in part J of Schedule 1 of the Building regulations. Print name and title…………………………………………………………………Profession……………………………………. Capacity…………………………………………………………………………….Telephone No. ………………………………. Address………………………………………………………………………………………………..Postcode…………………... Signed………………………………………………………………………………..Date…………………………………………. Registered member of.. (e.g. CORGI, OFTEC, HETAS, NACE, NACS)………………………………………………………….. Aarrow Signature Inset 5 Page 15... -
Page 16: Service & Maintenance
It is Note: Use genuine Aarrow touch up spray as some important that the flue ways, flue pipe and chimney paints interact. This could ruin the finish and invalidate the guarantee. -
Page 17: Summer Storage / Non Usage
Lift the fire door up off the hinges. This operation should only be carried out when the appliance is unlit and cold. • Drop one washer 6.35mm ID x 14mm OD on the top and bottom hinge pins. Aarrow Signature Inset 5 Page 17... -
Page 18: Fire Door Rope Replacement
Refit the door assembly back onto the stove; the appliance. carefully lift the door over the hinge and slot into place. Rope Gasket Joint Fig. 8. Rope Replacement Fig. 9. Lining Up Gasket Rope Page 18 Aarrow Signature Inset 5... -
Page 19: Disassemble The Primary Air Control
See Fig 12 Rear Of Oval Fig. 11. Tightening The Glass Clip Please Note—This should be carried out when Slider the fire is cold and unlit. Fig. 12. Rear Of Oval / Slider Assembly Aarrow Signature Inset 5 Page 19... -
Page 20: Service Record
Company Details Work Carried Out Signature Should you have any questions about your Aarrow Signature Inset stove that are not covered in this manual please contact your Aarrow dealer. Please keep all repair receipts safely. Please ensure you have this manual available when an engineer visits so they can complete the service record chart. -
Page 21: Operating Instruction
ALWAYS WEAR SUITABLE PROTECTIVE FIRE WARNING : NEVER BURN LIQUID FUELS IN GLOVES WHEN REFUELLING YOUR STOVE. YOUR STOVE. PLEASE CONTACT : The Manufacturer For Further Details & Advice On The Use Of Other Fuels. Aarrow Signature Inset 5 Page 21... -
Page 22: Burning Wood
When wood is burnt slowly in a closed appliance, it produces moisture and tar, which will create con- densation and deposits in the chimney. This effect can be minimised by burning hard for a short period, 15 to 20 minutes, twice a day. Page 22 Aarrow Signature Inset 5... -
Page 23: Over Firing & Chimney Fires
When burning wood, it is acceptable to maintain an ash bed on top of the wood tray of approximately 20mm (3/4”) without any un-due effect. Aarrow Signature Inset 5 Page 23... -
Page 24: Air Inlet Controls
OPERATING INSTRUCTIONS AIR INLET CONTROLS AIR WASH SYSTEM The Aarrow Signature 5 stoves have two air inlet The air wash has an internal sliding plate with slots, controls. housed in a cover plate, and is located above the The primary air inlet providing under draught to the fire door. -
Page 25: Fuel Retainer
Lower the fuel retainer bar so as to engage the lower lugs into the mounting slots in the stove body as shown Step 3, Ensure the fuel retainer is sat fully down onto the front landing as shown Step 2 Aarrow Signature Inset 5 Page 25... -
Page 26: Multi Purpose Operating Tool
OPERATING INSTRUCTIONS MULTI PURPOSE OPERATING TOOL Your Aarrow stove is supplied with a multi purpose operating tool, used for adjusting the air inlet control and the removal of the ash pan. (See Fig 18) TO EMPTY THE ASH PAN The Signature 5 stoves are supplied with a unique ash pan. -
Page 27: Main Fire Door Handle
OPERATING INSTRUCTIONS MAIN FIRE DOOR HANDLE A stove mitten is supplied with your Aarrow Signature 5 stove, this is provided for the operation of the fire door handle whilst the stove is in use. Care must be taken when opening and closing the fire door as any surrounding areas of the stove will be very hot. -
Page 28: Optional Extra / Accessories
( Not to Scale ) Aerosol Touch Up Paint AFS 101 Gothic Door Tracery SEB15 TRACEG Lattice Door Tracery SEB15 TRACEL Flue Gather Kit 5 INSET GATHER (Includes Fixings) Multi Fuel Upgrade Kit MFKITINSET5 (includes Fixings) Page 28 Aarrow Signature Inset 5... -
Page 29: Spare Parts List
(Includes Washer) Replacement Hot Glove AFS1285 Throat Plate AFS1402 Ash Pan AFS1395 Rear Liner AFS1410 Side Liner AFS1409 Complete Liner set AFS1408 Fuel Retainer AFS1378 Operating Tool AFS008 Rear of Body Face AFS1407 Rope Seal Aarrow Signature Inset 5 Page 29... - Page 30 Complete Fire Door handle Assembly AFS1385 Wood Burning Tray AFS1401 Tertiary Air Top AFS1403 (Includes Fixings) Wood Cover Plates AFS1404 (Includes Fixings) Replacement Primary Air AFS1369 Slider Stove Fixing Bolts AFS1434 (M10 x 75mm) Page 30 Aarrow Signature Inset 5...
-
Page 31: Guarantee
Aarrow Signature 5 Inset stove. replace it FREE OF CHARGE as long as the stove has been installed according to this When you buy an Aarrow stove, you are not manuals instructions and the Final only buying a first class appliance you are... -
Page 32: Guarantee
This guarantee specifically does not cover accidental damage, misuse, general wear & tear. The use of non Aarrow replacement parts will invalidate your warranty. For full details, contact your local Aarrow retailer. All guarantees are in addition to your statutory rights. -
Page 33: General Dimensions
GENERAL DIMENSIONS Maximum width in front of fireplace (210mm) Requires a 225mm hearth totalling 435mm Aarrow Signature Inset Page 33... -
Page 34: Factory Check List
Masonry Fixing Screws Date of Purchase……………………………….. Name and Address of Supplier…….……………………………………………………………. ………………………………………………………………………………………………………. ………………………………………………………………………………………………………. ………………………………………………………………………………………………………. Arada Ltd The Fire Works Millway Industrial Estate Axminster Devon EX13 5HU United Kingdom Tel: +44(0)1297 35596 Fax: +44(0)1297 35900 www.arada.uk.com Aarrow Signature Inset 5 BK075...
Need help?
Do you have a question about the Signature Inset 5 and is the answer not in the manual?
Questions and answers