Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Ugolini ARCTIC COMPACT
Summary of Contents for Ugolini ARCTIC COMPACT
- Page 1 ARCTIC COMPACT ARCTIC DELUXE SERVICE MANUAL...
- Page 2 ARCTIC COMPACT & DELUXE...
- Page 3 SERVICE MANUAL USER MANUAL TROUBLE SHOOTING...
- Page 4 Arctic Compact 5-8/1 are equipped with one thermostat to control the themperature of the bowl. Arctic Compact 5-8/2 are equipped only with one thermostat to control the temperature of the bowl at the right. Arctic Compact 5-8/3 are equipped only with one thermostat to control the temperature of the central bowl.
- Page 5 PART BOWLS CAPACITY NUMBER [litres] Arctic Compact series dispensers are equipped with 22900-00202 submerged pumps. On double machines the pumps are driven by only one motor through a transmission belt and three pulleys. 22900-00203 This motor also works as a fan. On triple machines two pumps...
- Page 6 On Arctic Compact with multiple bowls it is necessary also to remove the transmission belt from the pulleys and power on the unit. If the noise is still present the cause can be the electric motor once again.
- Page 7 side of the copper tubing since the refrigerant gas is heavier figure 8) than air. Where copper tubing is protected by an insulating jacket, check for leaks at both ends of each jacket section. figure 7 figure 8 Referring to the diagram (see figure 7), perform the following steps: 6.
- Page 8 (A). To clean the condenser it is necessary to remove the back panel. On Arctic Compact dispensers the condenser is always located on the back of the unit but air flow if from sides to back (B).
- Page 10 ARCTIC COMPACT & DELUXE The following key operation procedures, extracted from the Operator’s Manual, are quoted here too so that service personnel may help end users to achieve the best performances and results. IMPORTANT 1 TECHNICAL CHARACTERISTICS Read electrical ratings written on the data plate of the individual units;...
- Page 11 On arctic Compact series this 10 Do not use water-jets to clean the unit. p o s i t i o n o p e r a t e s a l l t h e 11 This unit can work in a room temperature range between funtions of the dispenser.
-
Page 12: Cleaning And Sanitizing
ARCTIC COMPACT & DELUXE 5. 2 OPERATION HELPFUL HINTS take the pinch tube off from its seat (2) (see figure 3). 1 The length of time for cooling down the product is governed by many variables, such as ambient temperature and beverage initial temperature. - Page 13 its gasket (see figure 6). not provide adequate cleaning. IMPORTANT In order to prevent any damages to the dispenser, use only a detergent suitable with plastic parts. 2 Using a brush, suitable for the purpose, thoroughly clean all disassembled parts in the cleaning solution. ATTENTION figure 6 4 Fit the bowl gasket to the evaporator.
- Page 14 ARCTIC COMPACT & DELUXE 6 ROUTINE MAINTENANCE 1 Replacement of lighted top cover bulbs (see figure 9) : Remove the fixing screws placed in the upper part of the top cover, remove the lower part and replace the bulbs (using a 24- 28V 21W max bulbs).
- Page 16 The following Spare Parts List, extracted from the Operator’s Manual, are quoted here too for general reference only. To order spare parts please make refernece to the Spare Part List included in the Operator’s Manual supplied with each dispenser. SPARE PARTS LIST ARCTIC COMPACT 5/8 LT MODEL...
- Page 17 22900-03211 22900-03212 22900-03213 22900-00403 22900-00401 22900-00401 22900-00401 22900-03110 22900-03111 22900-03112 22900-03113 22800-00500 22800-00510 22800-00510 22800-00510 22800-00602 22800-00611 22800-00611 22800-00611 WIRING DIAGRAM ARCTIC COMPACT 5/8 LT MODEL 1/5-8 - 2/5-8 - 3/5-8 Switch Thermostat Pump/mixer Compressor 4/5-8 Switch Thermostat Pump/mixer Compressor...
- Page 18 The following Spare Parts List, extracted from the Operator’s Manual, are quoted here too for general reference only. To order spare parts please make refernece to the Spare Part List included in the Operator’s Manual supplied with each dispenser. SPARE PARTS LIST ARCTIC COMPACT 12/20 LT MODEL...
- Page 19 1/.. 2/.. 3/.. 4/.. 22900-00400 22900-00402 22900-00402 22900-00402 22900-03200 22900-03201 22900-03202 22900-03203 22900-03100 22900-03101 22900-03102 22900-03103 WIRING DIAGRAM ARCTIC COMPACT 12/20 LT MODEL 1/12-20 - 2/12-20 - 3/12-20 Switch 2-3-4 Thermostat Pump/mixer Compressor 4/12-20 Switch 3-4-5-6 Thermostat Pump/mixer 8-10 Compressor...
- Page 20 ARCTIC COMPACT & DELUXE The following Spare Parts List, extracted from the Operator’s Manual, are quoted here too for general reference only. To order spare parts please make refernece to the Spare Part List included in the Operator’s Manual supplied with each dispenser.
- Page 21 22900-00100 20 It bowl cover 22900-05600 Driving shaft 12lt 22900-00100 12 It bowl cover 22900-05601 Driving shaft 20lt 22800-17200 Bowl gasket 22900-05400 Stirrer 12lt 22900-00700 Plastic I-beam for connection 22900-05401 Stirrer 20lt 22900-00600 Central pivot 22900-05500 Central shaft 12lt 22040-00000 Central pivot OR 22900-05501 Central shaft 20lt...
- Page 22 ARCTIC COMPACT & DELUXE WIRING DIAGRAM ARCTIC DELUXE 12/20 LT MODEL Switch 3-4-5-6 Thermostat 7-8-9-10 Pump/mixer switch 11-12-13-14 Pump/mixer 15-16 Fan Motor 17-18 Compressor 19-20 Transformer 21-22-23-24 Top light...
- Page 23 NOTES:...
- Page 24 ARCTIC COMPACT & DELUXE NOTES:...
- Page 25 NOTES:...
- Page 26 Replace pump motor Drive magnet binds on evaporator Verify planarity of pump motor bracket assebly Broken transmission belt (Arctic Compact Replace transmission belt series with multiple bowls only) Leak from bowls B o w l f a s t e n i n g h o o k n o t p r o p e r l y...
- Page 27 Noisy fan or pump motor Replace noisy motor Magnetic lock decoupling (chattering) Verify planarity of pump motor bracket Noisy ball bearings (Arctic Compact Replace magnetic pulley assembly series with multiple bowls only) No magnetic slow mixer rotation Defective drive motor...
- Page 28 Ugolini spa Via dei Pioppi, 33 - 20090 Opera - (MI) Tel. 02.530059.1 - Fax. 02.530059260 www.ugolinispa.com E-Mail: sales@ugolinispa.com 2428_02 V0.2 09C09...