Table of Contents
Advertisement
HERITAGE PLUS GRILL OWNERS MANUAL
Safety Information
FOR YOUR SAFETY
• IF YOU SMELL GAS:
1. SHUT OFF GAS TO THE APPLIANCE.
2. EXTINGUISH ANY OPEN FLAME.
3. OPEN LID.
4. IF ODOR CONTINUES, IMMEDIATELY CALL YOUR GAS SUPPLIER
OR FIRE DEPARTMENT.
FOR YOUR SAFETY
1. DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS
AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE.
2. AN LP CYLINDER NOT CONNECTED FOR USE SHALL NOT BE
STORED IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE.
(A) DO NOT STORE A SPARE LP-GAS CYLINDER UNDER OR NEAR
THIS APPLIANCE;
(B) NEVER FILL THE CYLINDER BEYOND 80 PERCENT FULL; AND
(C) IF THE INFORMATION IN "(A)" AND "(B)" IS NOT
FOLLOWED EXACTLY, A FIRE CAUSING DEATH OR SERIOUS
INJURY MAY OCCUR.
• THIS GRILL IS NOT INTENDED TO BE INSTALLED IN OR ON RECREATIONAL
VEHICLES AND/OR BOATS.
• KEEP OUTDOOR COOKING GAS APPLIANCE AREA CLEAR AND FREE FROM
COMBUSTIBLE MATERIALS, GASOLINE AND OTHER FLAMMABLE VAPORS
AND LIQUIDS
• THIS GRILL SHALL ONLY BE CONNECTED TO AN LP CYLINDER WITH AN OVERFILL
PROTECTION DEVICE (OPD).
• THE GRILL SHOULD BE LIT AND ALLOWED TO OPERATE FOR AT LEAST 30
MINUTES BEFORE USING FOR THE FIRST TIME TO ALLOW PRESERVATIVE TO
BURN OFF. AFTER SMOKE STOPS COMING OUT OF STACKS, GRILL IS READY
FOR YOUR USE AND ENJOYMENT.
• THIS GRILL IS NOT FOR COMMERCIAL USE
• THIS COOKING APPLIANCE IS FOR OUTDOOR USE ONLY AND SHALL NOT BE USED
IN A BUILDING, GARAGE OR ANY OTHER ENCLOSED AREA.
• EXCESSIVELY WINDY OR COLD CONDITIONS MAY AFFECT GRILL COOKING
PERFORMANCE.
• CHOOSE ONLY A LEVEL LOCATION FOR GRILL OPERATION. THE HOLLAND GRILL
MUST BE SITTING SECURELY ON A LEVEL SURFACE FOR PROPER OPERATION
AND EVEN HEAT DISTRIBUTION.
• YOUR GRILL IS MADE FOR OUTDOOR USE ONLY
• THE VENT STACKS AND THE AIR INTAKE OPENINGS SHOULD NEVER BE
BLOCKED OR CLOSED DURING GRILL OPERATION.
• MINIMUM CLEARANCE FROM SIDES AND BACK TO COMBUSTIBLE
CONSTRUCTION, 18 INCHES (50CM) FROM SIDES AND 18 INCHES (50CM) FROM
BACK. IT IS VERY IMPORTANT TO OBSERVE AND MAINTAIN THE PROPER
CLEARANCES FROM COMBUSTIBLE CONSTRUCTION.
• DO NOT USE THIS OUTDOOR APPLIANCE UNDER OVERHEAD COMBUSTIBLE
SURFACES.
• DO NOT STORE A SPARE LP GAS CYLINDER UNDER OR NEAR THIS APPLIANCE.
WARNING: FOLLOW LOCAL CODES
• THE INSTALLATION OF THIS APPLIANCE MUST CONFORM WITH EITHER
THE NATIONAL FUEL GAS CODE ANSI STANDARD REFERENCED WITH
THE FOLLOWING: ANSI Z223.1/ NFPA 54, NATURAL GAS AND PROPANE
INSTALLATION CODE; CSA B149.1, OR PROPANE STORAGE AND
HANDLING CODE, B149.2, OR THE STANDARD FOR RECREATIONAL
VEHICLES, ANSI A 119.2/NFPA 1192, AND CSA Z240 RV SERIES,
RECREATIONAL VEHICLE CODE, AS APPLICABLE".
• INSTALLATION SHALL BE IN ACCORDANCE WITH CAN/CGAB149.1
NATURAL GAS AND PROPANE INSTALLATION CODE AND LOCAL
CODES WHERE APPLICABLE.
H-1
Please read carefully.
The Fuel System
Gas grills are used SAFELY by millions of people when following
simple SAFETY precautions.
The items in the fuel system are designed for operation with the
Holland Grill. They must not be replaced with any other brand.
(See parts list for replacement items.)
GAS BURNER: The gas burner is constructed of heavy cast iron
and should not require maintenance other than inspection for insect
nests inside the venturi. If you remove the burner for
cleaning, it must be reinstalled exactly as removed.
AIR SHUTTER: See item 11 in lighting instructions (see figure 6 for
details.)
BURNER VALVE: The burner valve is operated in only two
positions. The Off position is when the handle is across (perpendicu-
lar to) the burner, which stops the flow of gas. When the valve has
been set in the Off position, it is important to close the valve at the
LP gas cylinder. The LP gas cylinder is the primary valve and must
be closed when the grill is not in use. The On position is when the
handle is in line with the burner (see figure 6 for details. See lighting
instructions for more information.) The burner valve controls the heat
allowed in the grill by means of a plug orifice. This device is set at
the factory and must not be tampered with or replaced. Turn off LP
supply at cylinder when appliance is not in use.
ONLY A FACTORY SUPPLIED VALVE SHOULD BE USED. (See
the parts list for replacement items.)
LP GAS HOSE: The LP gas hose is designed for use with LP gas
only. Use with any other gas is dangerous. The hose is made of a
flexible material to make it easy to install. This material is subject to
considerable twisting and turning during installation. It is very impor-
tant that the hose be inspected for cracks, cuts, abrasions, wear and
loose fittings. The visual inspection should include leak testing the
entire length of hose and fittings. (See final assembly instructions for
more information.)
If the hose shows signs of damage or leakage, it must be replaced
prior to the operation of the grill. Only a factory authorized replace-
ment part can be used. (See the parts list for replacement items.)
Failure to properly inspect or replace hose with an authorized
replacement may result in accident or injury.
LP GAS REGULATOR: CAUTION: Use only the gas pressure regu-
lator and hose supplied with this appliance. This regulator and hose
is set for an outlet pressure of 11 inches water column. Substitution
of regulator and hose by any other device or any other manufactur-
er's regulator and hose is dangerous and could result in serious
injury. (See the parts list for replacement items.)
IMPORTANT LP CYLINDER INFORMATION: Failure to follow these
DANGER statements exactly may result in a fire causing death or
serious injury.
The Holland Co. Inc. recommends the use of cylinder manufactur-
er's Manchester and Worthington, Wolfdale with a 47.6 lb water
capacity. Other cylinders may be acceptable for use with the appli-
Hide quick links:
Advertisement
Table of Contents
