Table of Contents
Advertisement
THE TRADITION LS GRILL OWNERS MANUAL
Safety Information
FOR YOUR SAFETY
• IF YOU SMELL GAS:
1. SHUT OFF GAS TO THE APPLIANCE.
2. EXTINGUISH ANY OPEN FLAME.
3. OPEN LID.
4. IF ODOR CONTINUES, IMMEDIATELY CALL YOUR GAS SUPPLIER
OR FIRE DEPARTMENT.
FOR YOUR SAFETY
1. DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS
AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE.
2. AN LP CYLINDER NOT CONNECTED FOR USE SHALL NOT BE
STORED IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE.
(A) DO NOT STORE A SPARE LP-GAS CYLINDER UNDER OR NEAR
THIS APPLIANCE;
(B) NEVER FILL THE CYLINDER BEYOND 80 PERCENT FULL; AND
(C) IF THE INFORMATION IN "-b11(a)" AND "-b11(b)" IS NOT
FOLLOWED EXACTLY, A FIRE CAUSING DEATH OR SERIOUS
INJURY MAY OCCUR.
• THIS GRILL IS NOT INTENDED TO BE INSTALLED IN OR ON
RECREATIONAL VEHICLES AND/OR BOATS.
• THIS GRILL SHALL ONLY BE CONNECTED TO AN LP CYLINDER
WITH AN OVERFILL PROTECTION DEVICE (OPD).
• THE GRILL SHOULD BE LIT AND ALLOWED TO OPERATE FOR AT LEAST
30 MINUTES BEFORE USING FOR THE FIRST TIME TO ALLOW
PRESERVATIVE TO BURN OFF. AFTER SMOKE STOPS COMING OUT OF
STACKS, GRILL IS READY FOR YOUR USE AND ENJOYMENT.
• THIS GRILL IS NOT FOR COMMERCIAL USE
• THIS COOKING APPLIANCE IS FOR OUTDOOR USE ONLY AND SHALL
NOT BE USED IN A BUILDING, GARAGE OR ANY OTHER ENCLOSED AREA.
• EXCESSIVELY WINDY OR COLD CONDITIONS MAY AFFECT GRILL
COOKING PERFORMANCE.
• CHOOSE ONLY A LEVEL LOCATION FOR GRILL OPERATION. THE HOLLAND
GRILL MUST BE SITTING SECURELY ON A LEVEL SURFACE FOR PROPER
OPERATION AND EVEN HEAT DISTRIBUTION.
• YOUR GRILL IS MADE FOR OUTDOOR USE ONLY
• THE VENT STACKS AND THE AIR INTAKE OPENINGS SHOULD NEVER BE
BLOCKED OR CLOSED DURING GRILL OPERATION.
• MINIMUM CLEARANCE FROM SIDES AND BACK OF UNIT TO COM-
BUSTIBLE CONSTRUCTION, 18 INCHES (50CM) FROM SIDES AND 18
INCHES (50CM) FROM BACK.
• DO NOT USE THIS OUTDOOR APPLIANCE UNDER OVERHEAD
COMBUSTIBLE SURFACES.
• DO NOT STORE A SPARE LP GAS CYLINDER UNDER OR NEAR THIS
APPLIANCE.
WARNING: FOLLOW LOCAL CODES
• THE INSTALLATION OF THIS APPLIANCE MUST CONFORM WITH
LOCAL CODES OR IN THE ABSENCE OF LOCAL CODES, CONFORM
TO THE NATIONAL FUEL GAS CODE ANSI Z223.1./NFPA 54
• INSTALLATION SHALL BE IN ACCORDANCE WITH CAN/CGAB149.1
NATURAL GAS AND PROPANE INSTALLATION CODE AND LOCAL
CODES WHERE APPLICABLE.
T-1
Please read carefully.
The Fuel System
Gas grills are used SAFELY by millions of people when following
simple SAFETY precautions.
The items in the fuel system are designed for operation with the
Holland Grill. They must not be replaced with any other brand.
(See parts list for replacement items.)
GAS BURNER: The gas burner is constructed of heavy cast iron
and should not require maintenance other that inspection for
insect nests inside the venturi. If you remove the burner for clean-
ing, it must be reinstalled exactly as removed.
Air shutter: See item 11 in lighting instructions on page T-7 (see
figure 6 for details.)
BURNER VALVE: The burner valve is operated in only two
positions. The Off position is when the knob bar is Horizontal, the
pointer is at the OFF mark. This stops the flow of gas. When the
valve has been set in the OFF position, it is important to also
close the valve on the LP tank or Natural gas supply. The On
position is when the knob bar pointer is straight up, at the
ON/LIGHT position. The burner valve controls the heat allowed
in the grill by means of a plug orifice. This device is set at the
factory and must not be tampered with. See Lighting instructions
on page T-7 for more information. Turn off LP supply at cylinder
when appliance is not in use.
ONLY A FACTORY SUPPLIED VALVE SHOULD BE USED.
(See the parts list for replacement items.)
LP GAS HOSE: The LP gas hose is designed for use with LP
gas only. Use with any other gas is dangerous. The hose is made
of a flexible material to make it easy to install. This material is
subject to considerable twisting and turning during installation. It
is very important that the hose be inspected for cracks, cuts,
abrasions, wear and loose fittings. The visual inspection should
include leak testing the entire length of hose and fittings. (See
final assembly instructions for more information.)
If the hose shows signs of damage or leakage, it must be
replaced prior to the operation of the grill. Only a factory author-
ized replacement part can be used. (See the parts list for
replacement items.) Failure to properly inspect or replace hose
with an authorized replacement may result in accident or injury.
LP GAS REGULATOR: CAUTION: Use only the gas pressure
regulator supplied with this appliance. This regulator is set for an
outlet pressure of 11 inches water column. Substitution of
regulator by any other device or any other manufacturer's
regulator is dangerous and could result in serious injury. (See the
parts list for replacement items.)
PROPANE FUEL: Warning – propane is a flammable gas.
Improper handling may result in an explosion and/or fire and seri-
Advertisement
Table of Contents
