Page 2
DANGER GRILL INSTALLER - LEAVE THIS INSTRUCTION BOOKLET FOR THE GRILL OWNER. IF YOU SMELL GAS: GRILL OWNER - SAVE THIS INSTRUCTION 1. SHUT OFF GAS TO APPLIANCE. BOOKLET FOR FUTURE REFERENCE. 2. EXTINGUISH ANY OPEN FLAME. 3. OPEN LID. 4.
Page 3
Simply close the lid and cook by time. It’s guaranteed not to flare-up. Thank you for purchasing a Holland Grill. This is truly a grill that you, your family and friends will use and enjoy for many years to come.
GAS BURNER: The gas burner is constructed of heavy cast iron and PERFORMANCE. • CHOOSE ONLY A LEVEL LOCATION FOR GRILL OPERATION. THE HOLLAND GRILL should not require maintenance other than inspection for insect nests MUST BE SITTING SECURELY ON A LEVEL SURFACE FOR PROPER OPERATION inside the venturi.
Page 5
12-3/8" in diameter with an overall height of 18- 1/16". The Holland Grill does not come with an LP gas cylinder. This Keep any electrical supply cord and fuel supply hose away from must be purchased separately and is available at most hardware stores.
Page 6
FIGURE 1 FIGURE 2 SSEMBLY INSTRUCTIONS Step 1. Fasteners Guide On a flat surface (table or carport floor), OPEN AND EMPTY BOTH BOXES. REFER TO THE CONTENTS LIST TO BE SURE NO PARTS ARE MISSING. Tighten all factory installed fasteners that may have 4 each T-Nut #8-32 x 1/2”...
Page 7
FIGURE 3 FIGURE 4a For use with BH 3013 only. For use with BH 3802 Trim Kit. Step 3. Step 5. Refer to Figure 2. Select the following items: For use with BH 3802 Trim Kit. 1. grill bottom assembly Refer to Figure 4a.
Page 8
FIGURE 4b FIGURE 5 Install control knobs. Push black igniter knob Step 8. firmly until it snaps into place, once installed correctly, it should not Refer to Figure 6a. Select the following items: come off easily. Secure silver gas control knob to post by tightening set 1.
Page 9
FIGURE 6b FIGURE 6a Step 9. HOLL ND PEX BODY ONLY GRILL Refer to Figure 6b. Select the following items: INST LL TION INSTRUCTIONS 1. drip pan 4. cooking grid 2. drain pipe 5. drip bucket 3. drain valve W RNING: Install the drain pipe into the female threaded coupling in the right end YOUR ISL ND MUST BE M DE FROM of the drip pan.
Page 10
Will you be serving buffet style? With a little creativity, Holland Grill parts and some help from your local dealer- the sky is the limit. With Holland's body-only Apex grill, trim kit, double doors and Searmate you have all you need to get started on building your outdoor masterpiece.
Page 11
BUILD YOUR OWN ISL ND - CUTOUT DIMENSIONS . Island 28” wide x 36” tall (suggested) B. Grill Body Opening 27.5” wide x 20” deep x 11” tall Trim Kit BH 3802...
There should be no need for re-adjustment for the life of your Holland Grill, but it is wise to check the flame color each time you light your grill. When proper setting is obtained be sure to...
Following these instructions will improve the longevity and quality of cooking. To assure safe operation of your Holland Grill, the area for cooking should always be kept free of combustible materials of any type, such as gasoline or other flammable vapors or liquids.
Page 14
Be sure to check out the Holland Grill recipes, tips and tricks listed on the web site. Why not try to create a few of your own!
Fish 20 minutes total NOTE: Remember, the Holland Grill needs to warm up completely. Temperature will remain about 400 degrees F. All grilling times are approximate depending on size, weight and individual taste preference. Grill needs to remain closed at all times during grilling to be accurate with this time chart. Each time grill is opened during the grilling process, increase grilling time by approximately 10 minutes.
Page 16
C ST IRON BURNER 38. G4-914N T-NUT If you have a question about the warranty or want to order parts or accessories, please contact your local Holland Grill dealer or call 800-880-9766 or visit us on the web at hollandgrill.com...
Page 17
STEP 8 Replace the No. 53 Natural gas orifice with the No. 57 LP (propane) gas orifice. Installation is the reverse. STEP 9 Use only a Holland Grill factory authorized LP (propane) hose and regulator assembly. STEP 10 Attach the regulator hose to the gas valve inlet and then attach big black plastic nut to LP tank.
Page 19
100% of the original purchase price, replace the parts that are causing the flare-ups, or replace your Holland grill with a new Holland grill of the same or comparable model. This no flare-up warranty applies only to flare-ups of edible foodstuffs from the drip pan and does not apply to any fire from flammable, toxic or poisonous substances unfit for human consumption.
(please consult your use & care manual), or failure to follow local codes. Product repair or parts replacement at the option of the Holland Grill Co. is the exclusive remedy under this warranty. The Company shall not be liable for any incidental or consequential damages resulting from the use or transportation of any Holland grill, or for breach of any express or implied warranty on the Holland grill.
Need help?
Do you have a question about the APEX BH421-SS5LPB and is the answer not in the manual?
Questions and answers