Cleaning - Groen TDB/6 Operator's And Service Manual

OM-TDB/6
1. Suggested Tools:
a. Cleaner, such as Klenzade HC-10 or HC-32
from ECOLAB, Inc.
b. Kettle brushes in good condition.
Sanitizer such as Klenzade XY-12.
c.
d. Film remover such as Klenzade LC-30.
2. Precautions
Before cleaning, shut off the kettle by turning the
thermostat dial to "OFF." Shut off electric power
to the unit at a remote switch, such as the circuit
breaker.
WARNING
KEEP WATER AND SOLUTIONS AWAY FROM
CONTROLS AND ELECTRICAL EQUIPMENT.
NEVER SP RAY SUPPORT
ELECTRICAL CONNECTIONS.
CAUTION
MOST CLEANERS ARE HARMFUL TO THE
SKIN, EYES, MUCOUS
C L O T HING. PRECAUT IONS
TAKEN. WEAR RUBBER GLOVES, GOGGLES
O R F AC E S HIELD,
CLOT HING. READ
FOLLOW THE DIRECTIONS ON THE LABEL
OF THE CLEANER CAREFULLY.
3. Procedure
a. Clean food-contact surfaces as soon as
possible after use. If the unit is in continuous
use, thoroughly clean and sanitize the interior
and exterior at least once every 12 hours.
WARNING
AVOID ANY DIRECT CONTACT WIT H HOT
SURFACES. DIRECT SKIN CONTACT COULD
RESULT IN SEVERE BURNS.
b. Scrape and flush out food residues. Be
careful not to scratch the kettle with metal
implements.

Cleaning

HOUSING &
MEMBRANES, AND
SHOULD BE
AND PROT E C T IV E
T HE WARNINGS AND
Prepare a hot solution of the detergent/
c.
cleaning compound as instructed by the
supplier. Clean the unit thoroughly. A cloth
moistened with cleaning solution can be
used to clean controls, housings, and
electrical conduits.
d. Rinse the kettle thoroughly with hot water,
then drain completely.
e. As part of the daily cleaning program,
clean soiled external and internal surfaces.
Remember to check the sides of the unit
and control housing.
To remove stuck materials, use a brush,
f.
sponge, cloth, plastic or rubber scraper,
or plastic wool with the cleaning solution.
To reduce effort required in washing, let
the detergent solution sit in the kettle and
soak into the residue. Do NOT use
abrasive materials or metal tools that
might scratch the surface. Scratches
Use a sponge, cloth or plastic brush to clean
the kettle.
Scrapers or steel wool can harm the kettle
surface.
10