Page 1
TECHNICAL MANUAL DOOR TYPE DISHWASHING MACHINE Commander 18-5 Commander 18-5C Commander 18-5H Commander 18-5CH Installation, Operation, and Maintenance Instructions Insinger Machine Company 6245 State Road Philadelphia, PA 19135-2996 800.344.4802 Fax 215.624.6966 www.insingermachine.com...
Page 2
Operating Instructions information available. Operation and Cleaning Instructions Maintenance and Repair Procedures Each piece of equipment at Insinger is carefully Basic Service Guide tested before shipment for proper operation. If the need for service should arise please contact your Part 4 local Authorized Insinger Service Company.
Page 3
Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 4
Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 5
Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 6
Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 7
WARNING indicates potential physical danger. or from your local Insinger Authorized Service Agency. You can speak to the Insinger Technical CAUTION indicates potential equipment damage. Services Department, 800/344-4802, or e-mail us NOTE indicates helpful operating hints or tips.
Page 8
PART 1 TECHNICAL INFORMATION Door Type Dishwashing Machine Safety Summary The following are general safety precautions that are not related to any specific procedures. These are recommended precautions that personnel must understand and apply during many phases of op- eration and maintenance. Keep Away From Live Circuits Operating personnel must at all times observe all safety regulations.
Page 9
15 months from the date of corrosive detergents, acids, lye or other chemicals shipment from Insinger or 1 year (12 months) from used in the washing and or cleaning process. the date of installation, that said Insinger product...
Page 10
(as set out in the instruction booklet). your copy of invoice or shipping document. Insinger is not responsible nor liable for any condi- This limited warranty shall be limited to the tions of erosion or corrosion caused by corrosive...
PART 2 INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS A single-point electrical connection is provided for the pumps, control circuit, and wash tank heater. Commander 18-5 Series & CS Series If an electric booster is provided, connect power Placement directly to the booster.
Page 12
Do not reduce the size of lines as specified in installation the operation procedure and general cleaning pro- drawings. All Lines are sized to facilitate necessary cedures your Insinger dishwasher will give you flows, pressures, etc. years of trouble free service.
Page 13
PART 2 INSTALLATION INSTRUCTIONS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 14
PART 2 INSTALLATION INSTRUCTIONS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 15
PART 2 INSTALLATION INSTRUCTIONS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 16
PART 2 INSTALLATION INSTRUCTIONS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
By following these operating procedures your An interlock is provided to stop the wash/ Insinger dishwasher will give you years of trouble rinse cycle if the doors are opened but hot free service.
Page 18
PART 3 OPERATION & CLEANING INSTRUCTIONS PRESSURE ADJUSTMENT CLEANING PROCEDURES (CONTINUED) Pressure in the final rinse must be maintained at 20 5. Clean suction strainers of build-up. ± 2 psi. Adjustment of the pressure is made with the adjusting screw on the pressure reducing valve. þ...
Page 19
PART 3 MAINTENANCE & REPAIR PROCEDURES The following is a basic guide for the repair and 2. Remove cap on top of the coil. Remove the replacement of common dishwasher parts. Refer to coil. the Basic Services Guide for troubleshooting tips. 3.
PART 3 MAINTENANCE & REPAIR PROCEDURES Pump Disassembly (Continued) 2. Remove the pump motor and impeller by removing the 4 hex bolts attaching them to the pump housing. 3. Repair or replace the pump parts as required. 4. Reassemble in reverse of disassembly. Immersion Heater Replacement See dwg.
PART 3 MAINTENANCE & REPAIR PROCEDURES Motor Overloads Level System All motors used on Insinger Machines are provided The level control system consists of one overfill with motor overloads. Motor overloads are adjusted timer (P/N DE7-35) and one level float (P/N DEF- when the machines are factory tested.
Page 22
PART 3 MAINTENANCE & REPAIR PROCEDURES Cycle Timers The board labeled with a ‘W” is for the wash cycle, If your machine is controlled by timing boards instead the ‘R’ represents the rinse cycle, and the ‘L’ of a PLC, timing boards are used to determine wash time, rinse time and dwell time.
Page 23
PART 3 MAINTENANCE & REPAIR PROCEDURES Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 24
PART 3 MAINTENANCE & REPAIR PROCEDURES Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 25
PART 3 MAINTENANCE & REPAIR PROCEDURES Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 26
PART 3 MAINTENANCE & REPAIR PROCEDURES Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 27
PART 4 ELECTRICAL SCHEMATICS & REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 28
PART 4 ELECTRICAL SCHEMATICS & REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 29
PART 4 ELECTRICAL SCHEMATICS & REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 30
PART 4 ELECTRICAL SCHEMATICS & REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 31
PART 4 ELECTRICAL SCHEMATICS & REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 32
PART 4 ELECTRICAL SCHEMATICS & REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 33
PART 4 ELECTRICAL SCHEMATICS & REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 34
PART 4 ELECTRICAL SCHEMATICS & REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 35
PART 4 ELECTRICAL SCHEMATICS & REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 36
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 37
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 38
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 39
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 40
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 41
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 42
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 43
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 44
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 45
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 46
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 47
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 48
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 49
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 50
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 51
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 52
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 53
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 54
PART 5 REPLACEMENT PARTS Door Type Series DOC COM 1.0 06 www.insingermachine.com 800-344-4802...
Page 55
6245 State Road Philadelphia, PA 19135-2996 800.344.4802 Fax 215.624.6966 www.insingermachine.com...