Table of Contents
Advertisement
Storage
To prevent the engine and other equipment from being harmed during long (2 months or more) periods out of
service, it must be conserved. Conservation protects the engine from freezing and corrosion damages.
It is of utmost importance that the conservation is performed correctly, therefore we have compiled a checklist
covering the most important points. Before taking the engine out of service for long periods, Volvo Penta
recommends that the engine is checked by a qualified workshop for possible need for overhaul or repair.
CAUTION!
Read the chapter on Maintenance in the Operator`s Manual before starting work. It contains instructions on how
to carry out maintenance and service operations in a safe and technical correct manner.
WARNING!
Conservations oils can be flammable and dangerous to inhale. Ensure good ventilation. Use a protective face
mask when spraying.
IMPORTANT:
Washing with a power washer: Never aim the water jet at radiators, charge air cooler, seals, rubber hoses or
electrical components.
80
•
For up to 8 month's stoppage:
Change the oil and oil filter on the engine, then run
the engine until warm.
More than 8 month's stoppage:
Conserve the lubrication and fuel systems with
conservation oil. Refer to the section Conservation
of the lubrication and fuel systems for more than 8
months' stoppage.
•
Make sure the coolant has adequate antifreeze
properties. Top up as necessary.
Alternatively, you can drain the coolant (also drain
the coolant filter).
•
Drain any water and contamination from the fuel
filters and fuel tank. Fill the fuel tank completely, to
avoid condensation.
•
Disconnect the battery cables, clean and charge the
batteries. Trickle charge the batteries while the
equipment is in storage. A poorly charged battery
can freeze and burst.
•
Clean the outside of the engine. Do not use a high
pressure washer for engine cleaning. Touch up
paint damage with Volvo Penta original paint.
•
Put a note on the engine with the date, type of
conservation and the conservation oil used.
•
Cover the air filter, exhaust pipe and engine if
necessary.
•
Empty the AdBlue/DEF tank and rinse it with distilled
water.
47711155 06-2021 © AB VOLVO PENTA
Advertisement
Table of Contents
