Recommended Spare Parts; Trouble Shooting - Numatic NX 1K Original Instructions Manual

Part No.
606203 450mm Polyscrub Brush
606204 450mm Nyloscrub Brush
606306 450mm Longlife Brush
900525 400mm NuLoc2 Drive Board
606401 400mm Padloc Drive Board
606028 550MM Polyscrub Brush
606550 550MM Nyloscrub Brush
606551 550MM Longlife Brush
900526 500mm Nuloc2 Drive Board
Part No.
213058 Vac Hose
280019 Floor Tool Hose
280018 Dump Hose - Top Tank
213025 Dump Hose - Bottom Tank
208960 Filler Hose - Bottom Tank
237718 Hose Guide
206111 Dump / Filler Closure - Bottom Tank
For optimum performance Numatic International Ltd recommend the use of the following batteries in the Twintec machines.
Machine
TBL4045 / 4055 / 4055T
Make
NX1K Battery

Trouble Shooting

PROBLEM
Machine will not operate
Vacuum will not operate
Poor water pick-up
No brush / scrub function
Little or no water flow
Machine just 'stops' while
operating
Warning
Do not fit a replacement fuse link having a higher rating than the value stated on the fuse label.
BRUSHES
HOSES
Numatic Recommended Battery
NX1K LFP battery type (Li-ion)
Voltage Capacity/Energy
25.6 V 50Ah / 1280 Wh
CAUSE
Low battery charge
Waste water tank full
Waste water tank full
Clogged / blocked vacuum hose
Loose hose connections
Debris basket filter clogged / blocked
Separator filter clogged / blocked
Poor separator seal
Damaged separator seal
Damaged / split vacuum hose
Damaged floor tool blades
Low battery charge
No brushes fitted
Clean water tank empty
Clean water tank filter blocked / clogged
Water flow not on
Brush deck raised
Too much load on the brush system
Part No.
900521 650 Semi Parabolic Squeegee (4045G)
900522 750 Semi Parabolic Squeegee (4045G)
900518 650 Floor Tool Blades - Green PU
900519 750 Floor Tool Blades - Green PU
206953 Detent Pin
Part No.
208888 Clean Water Filter
208890 Clean Water Filter Clear Bowl
237268 Filler Cap Lid
577839 Seperator
207128 Filler Cap Filter
206265 Barrel Filter
207000 Basket Filter
208830 Clean Water Filter Gasket
208827 Clean Water Filter Body
208889 Clean Water Filter Mesh
Weight
10.8 kg
SOLUTION
Charge batteries (page 13)
Empty waste water tank (page 11)
Empty waste water tank (page 11)
Remove and clean (page 11)
Push tight connections (page 7)
Remove and clean (page 11)
Remove and clean (Page 11)
Clean and refit (page 11)
Renew (contact service dept)
Renew (contact service dept)
Renew (contact service dept)
Re-charge batteries (page 13)
Check and fit (page 6)
Fill clean water tank (page 7)
Remove and clean (page11)
Switch on water flow (page 6)
Lower brush deck (page 6)
Decrease the brush load to best suit the floor type.
23
Spare Parts
SQUEEGEE
FILTERS
Part Number
911948
Size
315mm (L) x 132mm (W) x 185mm (H)