Table of Contents
Advertisement
4. You are responsible for initiating the warranty process. The ARB & US EPA suggests that you present
your off-road & Marine engine to a Kohler Co. dealer as soon as a problem exists. The warranty repairs
should be completed by the dealer as expeditiously as possible.
5. COVERAGE
Kohler Co. will repair or replace emission control system parts, components and sub-assemblies found to be
defective with respect to materials or workmanship at no cost to you including engine exhaust system related
diagnosis, labor and parts, provided that no un-authorized modification of any kind has been executed on the
engine, and its parts, components and sub-assemblies.
The choice and responsibility of the decision to repair or replace an emission control system defect will be solely
that of Kohler Co. Emission control system parts/ components covered by the Federal and California Emission
Control Systems Limited Warranty are listed below
engine is defective, the part will be repaired or replaced by Kohler Co.
Fuel injector(s)
Injection pump(s)
Exhaust manifold
Intake manifold
Exhaust gas recirculation (EGR) tube
Crankcase ventilation valve
Parts/components that are scheduled to be replaced as part of the required maintenance schedule will be
covered under the warranty provisions for a period of time up to the first scheduled replacement point for the
subject parts/ components. Subsequent damage to other engine components as a direct result of a warrantable
failure an exhaust emission part/ component will be covered under the warranty provisions described herein.
6. MAINTENANCE AND REPAIR REQUIREMENTS
The owner is responsible for the proper use and maintenance of the engine. Kohler Co. recommends that all
receipts and records covering the performance of regular maintenance be retained in case questions arise. If the
engine is resold during the warranty period, the maintenance records should be transferred to each subsequent
owner. Kohler Co. may not deny warranty repairs solely because of the lack of repair, maintenance or failure to
keep maintenance records.
Normal maintenance, replacement or repair of emission control devices and systems may be performed by any
repair establishment or individual; however, warranty repairs must be performed by a Kohler authorized service
center.
7. CALIFORNIA AND FEDERAL EMISSION CONTROLWARRANTY STATEMENT, OFF-ROAD & MARINE
DIESEL ENGINES (USA ONLY)
The California air resources board (carb), U.S. environmental protection agency (EPA), and Kohler Co. are pleased
to explain the emission control system warranty on your [current model year – {2+ current model year}] off-road
compression ignition and marine (diesel) engine. In California ("the state") and US EPA regulated region, new
heavy-duty off-road & marine engines must be designed, built and equipped to meet the state's and US EPA anti-
smog standards. The warranty period shall begin on the date the engine or equipment is delivered to an ultimate
purchaser. Kohler Co. must warrant the emission control system on your engine for the periods of time listed in
the section below, provided there has been no abuse, neglect or improper maintenance of your engine.
Your emission control system may include parts such as the fuel injection system and the air-induction system.
Also included maybe hoses, belts, connectors and other emission related assemblies.
When a warrantable condition exists, Kohler Co. will repair your heavy-duty off-road & marine engine at no cost to
you including diagnosis, parts and labor.
Internal Communication: For internal & partner use only.
INFORMATION ABOUT WARRANTY
Aftertreatment Systems if equipped and other components when present
Electronic control unit (ECU) if equipped
Sensors associated with ECU operation
Emission control information labels
Turbocharger (if equipped)
Fuel limiting device
8
47
EN
Advertisement
Table of Contents
