Table of Contents
Advertisement
Quick Links
WARNING: FOLLOW THE INFORMATION IN
THESE INSTRUCTIONS EXACTLY, IF NOT, A FIRE
OR EXPLOSION MAY RESULT CAUSING
PROPERTY DAMAGE, PERSONAL INJURY OR
LOSS OF LIFE.
WARNING: DO NOT STORE OR USE GASOLINE
OR ANY OTHER FLAMMABLE VAPORS AND
LIQUIDS NEAR THIS OR ANY OTHER GAS
APPLIANCE.
WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
Do not touch electrical switches; do not use the phone
in your building.
Immediately call your gas supplier from a phone
outside the structure. Follow your gas supplier's
instructions.
If you cannot reach your gas supplier, call the fire
department or 911.
A qualified installer, service agency, or gas supplier must
perform installation and service of this appliance. In the
Commonwealth of Massachusetts, all installation of gas
lines and gas fittings must be performed by a licensed gas
fitter or licensed plumber.
California Prop 65
WARNING: This product can expose you to
chemicals including glass wool fiber and carbon
monoxide which are known to the State of California to
cause cancer, birth defects or other reproductive harm.
For more information go to www.P65Warnings.ca.gov
Champlain
Gas-Fired Direct Vent Heater
Owner's Manual
Operation & Installation Guide
Read This Owner's Manual
Operate and Maintain This Gas Heater
According to This Instruction Manual.
Save These Instructions!
PFS File #20-639
Tested to:
ANSI Z21.88-2017
CSA 2.33-2017, CSA 2.17-17
AVERTISSEMENT:
SUIVRE LES INSTRUCTIONS DONNÉ DANS CETTE
NOTICE POUR RÉDUIRE AU MINIMUM LE RISQUE
D'INCENDIE OU POUR ÉVITER TOUT DOMMAGE
MATÉERIEL, TOUTE BLESSURE OU LA MORT.
AVERTISSEMENT: NE PAS ENTRESPOSER NI
UTILISER D'ESSENCE NI D'AUTRE VAPERURS OU
LIQUIDES INFLAMMABLES DANS LE VOISINAGE
DE CET APPRAREIL OU DE TOUT AUTRE
APPAREIL.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
Ne pas tenter d'allumer d'appareil.
Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où vous
vous trouvez.
Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qualifié
installer, agence de service ou le fournisseur de gaz.
(Model 8304)
ASSUREZ-VOUS
DE
BIEN
Champlain Model 8304
Manual: 6400-41424
R: 5/31/2022
Advertisement
Table of Contents
Related Manuals for HearthStone Champlain
Summary of Contents for HearthStone Champlain
- Page 1 WARNING: This product can expose you to chemicals including glass wool fiber and carbon monoxide which are known to the State of California to cause cancer, birth defects or other reproductive harm. Champlain Model 8304 For more information go to www.P65Warnings.ca.gov Manual: 6400-41424 R: 5/31/2022...
- Page 2 Intentionally Blank Page 1 of 36...
- Page 3 Date of Installation: Address: Phone: E-mail Website: Gas Supplier: Address: Phone: E-mail Website: Read this Owner’s Manual before installing or operating your Champlain. Retain this manual for future reference. SERVICE RECORD Date Who Performed Work Work Performed Notes: WHAT WHEN Firebox Cleaning.....
-
Page 4: Table Of Contents
Specifications………………………………………………………………………………………4 Introduction………………………………………………………………………………………...5 Safety Information…………………………………………………………………………………5 Installation Preparation………………………………………………………………………….. 7 Codes……………………………………………………………………………………………………………..7 Items Required for Installation………………………………………………………………………………… Packing List………………………………………………………………………………………………………. 8 Unpacking and Inspection……………………………………………………………………………………… 8 Clearances to Combustibles……………………………………………………………………. 9 Hearth Requirement/Floor Protection………………………………………………………………………….. 9 Venting Information……………………………………………………………………………... 10 Venting Connection……………………………………………………………………………………………. 10 Approved Systems……………………………………………………………………………………………. Minimum Venting……………………………………………………………………………………………… Electrical System Information………………………………………………………………….16 Gas Supply &... -
Page 5: Specifications
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN Model 8304 PECIFICATIONS Testing Agency: Intertek Testing Services NA, Inc. Certified for use by: (ITS) Board of State Examiners of Plumbers and Gasfitters Listing Agency: PFS TECO 100 Cambridge Street, Room 1511 Listed: Direct Vent Gas Heater... -
Page 6: Introduction
Never vent the gas Morrisville, VT 05661 heater to other rooms or buildings. www.hearthstonestoves.com inquiry@hearthstonestoves.com Service Caution If you believe your Champlain is not, in any way, performing properly, immediately discontinue operation until the unit is inspected and approved by... - Page 7 Hearthstone Quality Home Heating Products, Inc CHAMPLAIN Model 8304 qualified service personnel. Prior to servicing the unit, Certain exposed surfaces of the Champlain will reach turn the gas to the valve off, and disconnect any high temperatures during normal operation.
-
Page 8: Installation Preparation
NFPA 70-National Electrical Code or CSA If the decorative ceramic log or burner material supplied with the Champlain is damaged or parts are C22.1-Canadian Electric Code. missing, they must be replaced with the same, or approved Hearthstone replacement parts. -
Page 9: Items Required For Installation
2. Release the front panel by lifting up and off of the Inspect the Champlain for visible or concealed stove body. Set aside on a soft surface. damage. The unit should be square and true. The... -
Page 10: Clearances To Combustibles
WALLS AND FLOORING. Hearth Requirement/Floor Protection You can place the Champlain directly on any non- combustible surface or on a wood floor. When placing the Stowe on any other type of combustible surface you must install a panel made of metal, wood, stone, or glass under the appliance. -
Page 11: Venting Information
Figure 6 – Minimum Snorkel Wall Clearances Venting Components & Configuration Do not vent the Champlain jointly with any other solid fuel or gas appliance. Vent the stove directly to the outside of the building using a proper termination as listed in this manual. -
Page 12: Approved Systems
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN Model 8304 American Metal Products (AmeriVent) 8601 Hacks Cross Rd. Approved Venting System Components Olive Branch, MS 38654 800-423-4270 (The following are components that are available, BUT NOT necessary for all installations) Selkirk Corporation... -
Page 13: Minimum Venting
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN Model 8304 where it touches the wall. Use the center of this circle III. Vertical Termination Venting as the center point of the 10” x 10” square wall pass Configurations through. Cut and frame the wall for the vent pipe. Install the -40' maximum system height (without offset) horizontal vent termination on the outside of the wall. - Page 14 Hearthstone Quality Home Heating Products, Inc CHAMPLAIN Model 8304 Figure 12: Approved DV Venting Alternate Configurations for Vertical Termination...
- Page 15 Hearthstone Quality Home Heating Products, Inc CHAMPLAIN Model 8304 Figure 13: Venting Configuration and Restrictor Settings* * To adjust your restrictor for optimum flame appearance, follow the instructions in Restrictor Plate, p.23...
- Page 16 Hearthstone Quality Home Heating Products, Inc CHAMPLAIN Model 8304 Figure 14 - Acceptable Direct Vent Terminal Vent Cap Locations A = Clearance above grade, veranda, porch, deck, H = *Not to be installed within 15 feet (4.5m) above or balcony: 12 inches (30cm) minimum.
-
Page 17: Electrical System Information
(ATTENTION: AU MOMENT DE L’ENTRETIEN DES COMMANDES, ÉTIQUETEZ TOUS LES FILS AVANT LE DÉBRANCHEMENT. DES ERREURS DE CÂBLAGE PEUVENT ENTRAÎUN FONCTIONNEMENT INADEQUATE ET DANGEREUX.) The proper location of wire connections is shown in the following figure. Figure 15 – Champlain 8304 Wiring Diagram... -
Page 18: Gas Supply & Connections
NFPA Code and Hearthstone require the use of a The Champlain is factory equipped to use natural gas dedicated sediment trap just upstream of the unit. (NG) and requires conversion for use with propane Damage to the valve, or other components due to (LP). -
Page 19: Initial Leak Check
Hearthstone Quality Home Heating Products, Inc. CHAMPLAIN Model 8304 proper thread length and to gauge. Thread WARNINGS that IS cut too long can cause distortion or • Fire or Explosion Hazard. Can cause property malfunction if inserted too deeply. damage, severe injury, or death. Do NOT bend 3. -
Page 20: Firebox/Log Set Placement
Hearthstone Quality Home Heating Products, Inc. CHAMPLAIN Model 8304 WARNING set when unpacking. Observe the 5 mounting “posts”, A, B, C, D, and E. Absolutely no leakage should occur, otherwise there is a danger of fire or explosion depending upon conditions. -
Page 21: Removal
Hearthstone Quality Home Heating Products, Inc. CHAMPLAIN Model 8304 5. Gently slide the shortest of the “half” logs (3) onto pin B as shown below. 9. Spread the Charcoal Embers evenly across the front portion of the Pan Burner, one layer high. -
Page 22: Initial Lighting Instructions
MOKE AND UMES ARNING When lit for the first time, the Champlain will emit some smoke and odors. This is normal “off-gassing” of the paints and oils used in the manufacturing, and assembly of the unit. Open windows to vent the room if necessary. -
Page 23: Air Shutter/Restrictor
To meet many regional efficiency regulations, the qualified service technician or gas supplier. Champlain 8304 is equipped with a gas valve which will extinguish the pilot light after 7 days of inactivity 7. Turn gas control knob counterclockwise to “ON”. - Page 24 Hearthstone Quality Home Heating Products, Inc. CHAMPLAIN Model 8304 The air shutter is adjustable while the stove is installation or adjustment of this unit unless burning. Loosen the lock nut on the adjusting bolt technically qualified to do so. located in the lower rear center of the stove. Move...
-
Page 25: Routine Maintenance And Care
For replacement parts, or for information about parts firebox exhaust port behind baffle plate. Depending or service, contact your local Hearthstone dealer. on your vent configuration, you may need to adjust Any safety screen or guard removed for servicing the restrictor plate position to reduce draft. - Page 26 19-20. Reattach the glass and front panel to seal the 1. Allow the Champlain to cool completely. If the firebox. Turn on the gas, light the unit and check for glass is severely broken, first pull the broken proper operation.
- Page 27 Hearthstone Quality Home Heating Products, Inc. CHAMPLAIN Model 8304 1. Remove the existing gasket from the glass by Periodic inspection of the venting system should be grasping one end and pulling firmly. Clean off as performed by a qualified service person or agency at much of the hanging fiber “hairs”...
-
Page 28: Parts List
REMOTE CONTROL KIT # 90-56914 WARNING! DO NOT SUBSTITUTE MATERIALS. For replacement parts, or for information about parts or service, contact your authorized Hearthstone retailer. For the name of the authorized retailer nearest to you, visit our website at www.hearthstonestoves.com. -
Page 29: Troubleshooting
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN Model 8304 ROUBLESHOOTING Symptom Possible Cause Corrective Action 1. Pilot will not A. Using the piezo sparker, try to light the pilot. If it will not A. Insufficient gas pressure, light. light, check the inlet gas pressure. - Page 30 Hearthstone Quality Home Heating Products, Inc CHAMPLAIN Model 8304 Symptom Possible Cause Corrective Action 3. Pilot burning, no A. Thermostat switch or A. Check thermostat/wiring for proper connections. Place gas to main burner, wires defective. jumper wire across terminals at thermostat. If burner comes valve knob in the on, replace defective thermostat.
- Page 31 Hearthstone Quality Home Heating Products, Inc CHAMPLAIN Model 8304 8. Floating flames, A. Potentially dangerous A. Check the appliance input rate and reduce if necessary. lazy ill-defined, incomplete combustion due The air intake/exhaust flow system may be too restrictive or...
-
Page 32: Rating Label
Hearthstone Quality Home Heating Products, Inc CHAMPLAIN Model 8304 ATING ABEL 07044-2... -
Page 33: Warranty
) year after the Purchase Date, Hearthstone will pay for warranty labor performed by an authorized Dealer at Hearthstone’s published labor rates in effect at the time the labor is performed only if the appliance is installed by an authorized dealer or their designated representative. Otherwise or thereafter, the Original Purchaser is responsible for the cost of labor. - Page 34 Hearthstone or an authorized Dealer, as the case may be. Notwithstanding any other provision of this document, in no event will Hearthstone pay for any Dealer fees or other fees for pick up or delivery of the appliance returned for repair; the Original Purchaser shall be responsible for any such fees.
- Page 35 Dealer on behalf of Hearthstone, as the case may be, will instruct the Original Purchaser to either return the defective part, or the entire appliance (if requested), to the Dealer or Hearthstone or allow a Dealer to make a service call at the place where the appliance is located. Hearthstone may require that a digital picture be provided to support the claim.
- Page 36 Hearthstone Quality Home Heating Products, Inc CHAMPLAIN Model 8304 07044-2...