HearthStone Santa Fe Owner's Manual & Installation Manual

HearthStone Santa Fe Owner's Manual & Installation Manual

Hearthstone santa fe gas-fired direct vent heater
Hide thumbs Also See for Santa Fe:

Advertisement

Owner's Manual & Installation Guide
Santa Fe
for the
FIRED DIRECT VENT HEATER
WARNING: If the information in these instructions
is not followed exactly, a fire or explosion may result
causing property damage, personal injury or loss of
life.
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
Do not touch electrical switches; do not use
the phone in your building.
Immediately call your gas supplier from a
neighbors phone. Follow your gas suppliers
instructions.
If you cannot reach your gas supplier, call the fire
department.
A qualified installer, service agency or gas supplier
must perform installation and service.
317 Stafford Avenue,
Morrisville, Vermont 05661
E-Mail: Inquiry@HearthStoneStoves.com
GAS-
(8760)
From:
READ THIS OWNER'S
MANUAL
Operate and maintain this gas heater
according to this instruction manual.
Read This Manual In Its Entirety.
AVERTISSEMENT: Assurez-vous de bien suivre les
instructions donné dans cette notice pour réduire au
minimum le risque d'incendie ou pour éviter tout
dommage matéeriel, toute blessure ou la mort.
Ne pas entresposer ni utiliser d'essence ni d'autre
vaperurs ou liquides inflammables dans le voisinage
de cet apprareil ou de tout autre appareil.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR
DE GAZ:
Ne pas tenter d'allumer d'appareil.
Ne touchez à aucun interrupteur. Ne pas vous
servir des téléphones se trouvant dans le
batiment où vous vous trouvez.
Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions
du fournisseur.
Si vous ne pouvez rejoindre le fournisseur de
gaz, appelez le service dos incendies.
L'installation et service doit être exécuté par un
qualifié
installer,
agence
fournisseur de gaz.
de
service
ou
le
6400-40437 05-01-02
Model # 8760

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Santa Fe and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for HearthStone Santa Fe

  • Page 1 Owner’s Manual & Installation Guide READ THIS OWNER’S MANUAL Operate and maintain this gas heater according to this instruction manual. Read This Manual In Its Entirety. Santa Fe for the GAS- (8760) FIRED DIRECT VENT HEATER From: AVERTISSEMENT: Assurez-vous de bien suivre les WARNING: If the information in these instructions instructions donné...
  • Page 2: Information Sheet

    Phone: Date of Purchase: Installed by: Phone: Date of Installation: Gas Supplier: Phone: Read this Owner’s Manual before installing or operating the SANTA FE heater. Retain this manual for future reference. SERVICE RECORD Date Who Performed Work Work Performed Notes:...
  • Page 3: Table Of Contents

    & C TOVE IMENSIONS LEARANCES TO depressurization. The combination of natural ........5 OMBUSTIBLES stones with cast iron give the Santa Fe a pleasing ......7 look, which can be maintained with minimum ENTING NFORMATION care........14 ONNECTIONS The Santa Fe will provide you with years of practical and convenient service.
  • Page 4: Owner ' S Information

    National Fuel Gas Code, ANSI The Santa Fe should be located out of traffic and Z223.1 (NFPA 54) or CAN/CGA B149 away from furniture, draperies, clothing, and Installation Code.
  • Page 5: Lighting Instructions

    “PILOT”. AILY PERATIONS 6. Push in control knob all the way and hold in. The homeowner easily operates the Santa Fe Immediately light the pilot with the gas gas-fired heater. The unit comes standard lighter (push in and “click” the piezoelectric with a thermostat, while a remote or wall spark ignitor button several times until lit).
  • Page 6: Installer

    The decorative ceramic fiber logs supplied accordance with local codes or, in the absence of with the Santa Fe are located in the firebox. local codes, with the current NFPA 70-National Always use great care when handling the Electrical Code or CSA C22.1-Canadian Electric decorative ceramic logs, as they are fragile Code.
  • Page 7: Stove Dimensions & C

    H earthS ton e EARTH EQUIREMENT LOOR ROTECTION The Santa Fe may be placed on a non- Figure 2 combustible surface or wood floor. For placement of the Santa Fe on carpeting, vinyl tile or other combustible materials, the appliance...
  • Page 8 SANTA FE Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc LEARANCE TO OMBUSTIBLES 17" max. 2" MIN. 14" MIN. 2" MIN. 1" MIN. 4" MIN. Figure 3 Figure 4 TOP clearances (not to scale) SPECIFICATIONS: ISTED IRECT EATER...
  • Page 9: Enting Nformation

    Following pages for the venting installation that works best for you. Note: Vent terminals shall not be recessed into walls or siding ONNECTION 1. The Santa Fe Direct Vent is approved for installation only with the vent connecting components listed on this page and Simpson Dura-Vent Direct Vent GS, AmeriVent Direct, or Secure Vent systems.
  • Page 10 SANTA FE Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc Possible Vent TERMINATION locations.
  • Page 11 SANTA FE Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc clockwise until the two sections are fully locked. Install the 90Ε elbow in similar fashion. Note: The Standard Horizontal Vent Kit does not require a restrictor. E SURE THERE IS NO...
  • Page 12 SANTA FE Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc RESTRICTOR To adjust your restrictor for maximum flame appearance, loosen the Phillips head screw and spin the locator, found on the rear left side of the stove. (Refer to figure 8) Figure 8 II.
  • Page 13 SANTA FE Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc Figure 9 III. Vertical Termination Venting Configurations -40' maximum system height (without offsets) The Authority Having Jurisdiction must be consulted prior to proceeding with these installation methods.
  • Page 14 SANTA FE Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc Figure 11 IV. Horizontal Termination Venting -Use a vinyl siding Stand off when installing against vinyl siding. Configurations -Horizontal sections require a 1/4" rise every 12" -A minimum of 24" rise is required (with or w/o of horizontal run.
  • Page 15 Ne pas l’utiliser avec d’autres gas sauf si un kit is used, available through your local HearthStone kitde conversion certifié est installé dealer.
  • Page 16: Gas Connections

    The gas supply line connection is made to the the gas supply and leak test the unit before it is Santa Fe’s gas control valve under the unit on approved for use. Consult all local codes. The the left side using a 3/8" NPT fitting. It should...
  • Page 17: Log Placement

    SANTA FE Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc EPLACING THE LASS To replace the front glass, shut the pilot light off. Exact positioning of the log set is required in Remove the front screw, using the 1/8” hex order to obtain a pleasing flame pattern and wrench provided.
  • Page 18: Installation Of The Log

    SANTA FE Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc the underside of the Top Log. The “leg” on the NSTALLATION OF THE Top Log points towards the rear of the firebox. (Refer to figures 14 & 15) 1) Using a 1/8”...
  • Page 19: Removal Of The Log Set

    If you smell gas, check for IRST leaks. Use only your hand to turn the gas control knob. Never use tools. MOKE AND UMES ARNING When lit for the first time, the Santa Fe will emit some smoke and fumes. This is normal “off-...
  • Page 20: Initial Adjustments

    Gas Conversions located on the U-burner tube on the right rear of All Santa Fe stoves have been built for use with the unit under the air deflector. The air shutter is Natural Gas. These units however, can be easily used to regulate the air-to-gas combustion converted for use with LP, and visa versa.
  • Page 21: Routine

    SANTA FE Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc vacuum the ports (holes) along the top of the burner tubes. OUTINE AINTENANCE With the decorative ceramic fiber logs out of the firebox, fasten the door shut and light the unit...
  • Page 22 SANTA FE Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc Wiring Diagram - Santa Fe Wiring Color KEY: 50 60 70 80 90 Hearthstone NHC, Inc. 50 70 90 NOTE: Numbers on switch are shown on opposite side.
  • Page 23: Parts Lists

    SANTA FE Gas-Fired Direct Vent heater HearthStone Quality Home Heating Products Inc ARTS ISTS Part # Description Part # Description 27x0-655 Door Handle 5300-085 Pilot Shield 27x0-650 Front Door 5701-925H Starter Collar 2710-810 Top Grill 7211-310 Valve (NG) 27x0-660 Front Grill...
  • Page 24 31. For propane when equipped with No.49 drill size orifice. Fonctionneau gaz propane quand l’appareil est muni d’un injecteur de diame’tre 49. MANUFACTURED BY HearthStone, Quality Home Heating Products, Inc. Morrisville, VERMONT 05661 Date of Manufacture 2000 2001 2002 Jan Feb Mar Apr May Jun Jul Aug Sep Oct Nov Dec €...
  • Page 25 TROUBLESHOOTING GUIDE Symptom Possible Cause Corrective Action 1. Pilot will not A. Insufficient gas pressure, A. Using the piezo sparker, try to light the light. air in the pilot line, or dirty or pilot. If it will not light, check the inlet gas kinked gas line.
  • Page 26 Symptom Possible Cause Corrective Action 3. Pilot burning, no A. Thermostat switch or A. Check thermostat/wiring for proper gas to main burner, wires defective. connections. Place jumper wire across valve knob in the terminals at thermostat. If burner comes on, "ON"...
  • Page 27 8. Floating flames, A. Potentially dangerous A. Check the appliance input rate and reduce lazy ill-defined, incomplete combustion due if necessary. The air intake/exhaust flow quiet flames, which to incorrect air to fuel ratio system may be too restrictive or blocked (the roll around, (lack of combustion air or rate at which the exhaust leaves [draft]...
  • Page 28 Original Purchaser (referred to as the “Stove” for simplicity) against any of the occurrences listed in this document that result from defects in material or workmanship. All obligations of HearthStone under this document commence on the date the Original Purchaser purchases the Stove (the “Purchase Date”).
  • Page 29 9. A defect in any part of the Stove if the Original Purchaser fails to comply with HearthStone’s or a Dealer’s request to ship the part or the Stove to HearthStone or a Dealer, as the case may be.
  • Page 30: Warranty Registration

    Purchaser to either return the defective part, or the entire Stove (if needed), with shipping prepaid, to HearthStone or a Dealer or allow a Dealer to make a service call at the place where the Stove is located. In the event the Original Purchaser refuses to allow a Dealer to make a service call, HearthStone or a Dealer, as the case may be, will request that the Original Owner return the defective part, or the entire Stove (if needed), with shipping prepaid, to HearthStone or a Dealer.

This manual is also suitable for:

Santa fe 8760

Table of Contents