Table of Contents
Advertisement
Quick Links
See also:
Owner's Manual
WARNING: FOLLOW THE INFORMATION IN THESE
INSTRUCTIONS EXACTLY, IF NOT, A FIRE OR
EXPLOSION MAY RESULT CAUSING PROPERTY
DAMAGE, PERSONAL INJURY OR LOSS OF LIFE.
WARNING: DO NOT STORE OR USE GASOLINE
OR ANY OTHER FLAMMABLE VAPORS AND
LIQUIDS NEAR THIS OR ANY OTHER GAS
APPLIANCE.
WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
Do not touch electrical switches; do not use the phone
in your building.
Immediately call your gas supplier from a phone
outside the structure. Follow your gas supplier's
instructions.
If you cannot reach your gas supplier, call the fire
department or 911.
A qualified installer, service agency, or gas supplier must
perform installation and service of this appliance. In the
Commonwealth of Massachusetts, all installation of gas
lines and gas fittings must be performed by a licensed gas
fitter or licensed plumber.
(Model 8140)
Gas Fired Direct-Vent Heater
OWNER'S MANUAL
INSTALLATION AND
OPERATING INSTRUCTIONS
PLEASE READ THIS ENTIRE OWNER'S MANUAL
BEFORE YOU INSTALL AND USE YOUR NEW
MODENA GAS HEATER. SAVE THIS DOCUMENT
FOR FUTURE REFERENCE.
AVERTISSEMENT:
SUIVRE LES INSTRUCTIONS DONNÉ DANS CETTE
NOTICE POUR RÉDUIRE AU MINIMUM LE RISQUE
D'INCENDIE OU POUR ÉVITER TOUT DOMMAGE
MATÉERIEL, TOUTE BLESSURE OU LA MORT.
AVERTISSEMENT: NE PAS ENTRESPOSER NI
UTILISER D'ESSENCE NI D'AUTRE VAPERURS OU
LIQUIDES INFLAMMABLES DANS LE VOISINAGE
DE CET APPRAREIL OU DE TOUT AUTRE
APPAREIL.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
Ne pas tenter d'allumer d'appareil.
Ne touchez à aucun interrupteur. Ne pas vous servir
des téléphones se trouvant dans le batiment où vous
vous trouvez.
Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du
fournisseur.
Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service dos incendies.
L'installation et service doit être exécuté par un qualifié
installer, agence de service ou le fournisseur de gaz.
ASSUREZ-VOUS
DE
hase - Modena Model 8140
Manual # 6400-40458
R: 3 - 7/27/2011
BIEN
Advertisement
Table of Contents
Related Manuals for HearthStone Hase-Modena 8140
Summary of Contents for HearthStone Hase-Modena 8140
- Page 1 L’installation et service doit être exécuté par un qualifié fitter or licensed plumber. installer, agence de service ou le fournisseur de gaz. hase - Modena Model 8140 Manual # 6400-40458 R: 3 - 7/27/2011...
- Page 2 Use this page to record all relevant information concerning the purchase, installation, and maintenance of your Modena Model 8140 Direct -Vent heater. This information will facilitate servicing, purchase of replacement parts, and warranty claims (if necessary). Keep your original receipt in a safe place as proof of purchase.
-
Page 3: Table Of Contents
Hearthstone Quality Home Heating Products, Inc. Modena Model #8140 Table of Contents Odors and Impurities........... 18 INTRODUCTION ..........4 Pilot Light ..............18 Do Not Light Pilot or Burner By Hand ......18 Read this Owner’s Manual ..........4 Prepare For Lighting ........... 18 Never Burn Paper, Wood or Other Materials ....4... -
Page 4: Introduction
Hearthstone Quality Home Heating Products, Inc. Modena Model #8140 NTRODUCTION Congratulations on your purchase of Hearthstone’s EVER APER OOD OR THER Modena Gas-Fired Direct Vent heater. The Modena ATERIALS incorporates the latest in balanced vent gas This gas heater is designed to burn natural gas, or technology, which will provide you with clean, when converted, liquid propane (LP). -
Page 5: Specifications
Tested to: ANSI Z21.88b-2005/CSA 2.33b- 100 Cambridge Street, Room 1511 2005, CGA 2.17-M91 Boston, Massachusetts 02202 Report No. 310939-T4 " " Figure 1: Modena DV Model 8140 Dimensions FUEL TYPE: INPUT RATING (Btu/hr) 0-2000 ft 26,500 26,500 INPUT RATING (Btu/hr) 2000-4000 ft 26,500... -
Page 6: Owner's Information
Ensure the unit is cool prior to servicing and cleaning. The Modena is easily operated by the homeowner Use of any components not supplied by Hearthstone once installed and adjusted by qualified service on the stove voids all warranties. Do not substitute personnel. -
Page 7: Installer's Information
Hearthstone Quality Home Heating Products, Inc. Modena Model #8140 ’ NSTALLER NFORMATION components specified by Hearthstone will void ODES your warranty and could result in inefficient or Adhere to all local codes or, in their absence, the unsafe operating conditions. -
Page 8: Installation Preparation
Hearthstone Quality Home Heating Products, Inc. Modena Model #8140 NSTALLATION REPARATION Caution: These clearances represent EARTH EQUIREMENT LOOR ROTECTION minimum distances in all cases, which, You can install the Modena directly on a non- through testing in an independent laboratory combustible surface or wood flooring. - Page 9 Hearthstone Quality Home Heating Products, Inc. Modena Model #8140 2” minimum vent pipe clearance to combustibles. Figure 3: Minimum Vent Configuration and Clearances...
-
Page 10: Acceptable Direct-Vent Termination Cap Locations
Hearthstone Quality Home Heating Products, Inc. Modena Model #8140 CCEPTABLE IRECT ERMINATION AP LOCATIONS Figure 4: Termination Location & Clearances... -
Page 11: Venting Information
Hearthstone Quality Home Heating Products, Inc. Modena Model #8140 ENTING NFORMATION characteristics and efficiency for the wide variety of ONNECTION vent configurations. Controlling the draft also changes the aesthetics of the flame. The restriction 1. The Modena Direct Vent is approved for... - Page 12 Hearthstone Quality Home Heating Products, Inc. Modena Model #8140 NOTE: These positions are based on lab results, and can have some variance. Figure 7: Venting Configurations & Restriction Settings...
-
Page 13: Venting Components
Hearthstone Quality Home Heating Products, Inc. Modena Model #8140 & C ENTING OMPONENTS ONFIGURATION Do not vent the Modena jointly with any other HIMNEY INER YSTEM appliance. Vent the Modena directly to the outside of Direct-Vent Chimney Liner Termination Kit... - Page 14 Hearthstone Quality Home Heating Products, Inc. Modena Model #8140 outside of the house, run a bead of non- horizontal vent cap a minimum of 1-1/4”. Secure hardening mastic around its’ outside edges to the vent using the straps from the horizontal vent ensure a good seal between it and the wall.
-
Page 15: Electrical Connections
EMOTE ONTROL HERMOSTAT heating system, or a nearby sunny or drafty window. The Modena 8140 comes equipped with a Do not place the thermostat transmitter directly programmable ON/OFF/Thermostat remote control. behind or too close to the unit, otherwise heat from... -
Page 16: Gas Supply & Connections
54) OR CAN/CGA B149 INSTALLATION CODE. Once connected to the gas supply, the supply line NFPA Code and Hearthstone require the use of a and manifold gas pressures must be tested. The dedicated sediment trap just upstream of the unit. -
Page 17: Fire Stone Placement
Hearthstone Quality Home Heating Products, Inc. MODENA 8140 Gas-Fired Direct-Vent TONE LACEMENT CAUTION: Fragile! Handle fire stone set with care. Always wear gloves and safety goggles while handling the stone set. Place only the Fire stone set supplied with the Modena in the firebox. -
Page 18: Lighting The Unit For The First Time
Hearthstone Quality Home Heating Products, Inc. MODENA 8140 Gas-Fired Direct-Vent IGHTING THE NIT FOR THE IRST WARNING: IF YOU DO NOT FOLLOW THESE REPARE IGHTING INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION Prepare for the lighting procedure by adjusting the MAY RESULT CAUSING PROPERTY DAMAGE, thermostat (if equipped) to its lowest setting or OFF PERSONAL INJURY OR LOSS OF LIFE. -
Page 19: Lighting Instructions
Hearthstone Quality Home Heating Products, Inc. MODENA 8140 Gas-Fired Direct-Vent maximized for the colder winter months. This Remote position was selected, the main burner is adjustment can be made by the homeowner as cycled on and off by the thermostat or the “on/off”... -
Page 20: Air Shutter Adjustments
Hearthstone Quality Home Heating Products, Inc. MODENA 8140 Gas-Fired Direct-Vent To determine if the air shutter needs adjustment, it is ILOT DJUSTMENT necessary to view the flame pattern with the variable The pilot light is preset by the manufacturer and output control knob at its highest setting. - Page 21 Hearthstone Quality Home Heating Products, Inc. MODENA 8140 Gas-Fired Direct-Vent determine if the burner flame needs adjustment, it is necessary to view the flame pattern with the variable output control knob at its highest setting (turn fully clockwise). Allow the unit to operate for 10 minutes - enabling the entire unit to reach temperature and for the flame pattern to stabilize.
-
Page 22: Routine Maintenance And Care
Hearthstone Quality Home Heating Products, Inc. MODENA 8140 Gas-Fired Direct-Vent OUTINE AINTENANCE AND The Modena requires minimal routine maintenance Check and clean any burner ports that are not and care. Ensure the Modena is cool and off when burning, or not burning properly. Clean burner ports being cleaned, or serviced. -
Page 23: Glass Replacement Procedures
Hearthstone Quality Home Heating Products, Inc. MODENA 8140 Gas-Fired Direct-Vent 12. Place the glass frame back on the firebox, using You do not the 12 screws to mount it in place. need to completely 13. After 5 or 6 fires, check the glass retainer screws, remove the 4 and retighten if necessary. -
Page 24: Parts List
Hearthstone Quality Home Heating Products, Inc. MODENA 8140 Gas-Fired Direct-Vent ARTS Part # Part Name 7211-252 BURNER PAN 7211-263 MODENA BURNER TOP PLATE 7211-250 VENTURI TUBE 5800-240 SHUTTER: PRIMARY AIR 3160-181 GASKET: FIREBOX BOTTOM WARNING: DO NOT SUBSTITUTE MATERIALS. FOR REPLACEMENT PARTS,... -
Page 25: Bolting Your Modena To Apermanent Structure
Hearthstone Quality Home Heating Products, Inc. MODENA 8140 Gas-Fired Direct-Vent OLTING YOUR ODENA TO A ERMANENT TRUCTURE When installing the Modena in a mobile home it is required that you attach it to the structure. To do this, we have provided a rear attachment kit with the unit. -
Page 26: Troubleshooting
Hearthstone Quality Home Heating Products, Inc. MODENA 8140 Gas-Fired Direct-Vent ROUBLESHOOTING Symptom Possible Cause Corrective Action 1. Pilot will not light. A. Insufficient gas pressure, air in A. Using the piezo sparker, try to light the pilot. If it the pilot line, or dirty or kinked will not light, check the inlet gas pressure. - Page 27 Hearthstone Quality Home Heating Products, Inc. MODENA 8140 Gas-Fired Direct-Vent Symptom Possible Cause Corrective Action 3. Pilot burning, no gas A. Thermostat switch or wires A. Check thermostat/wiring for proper connections. to main burner, valve defective. Place jumper wire across terminals at thermostat. If knob in the "ON"...
- Page 28 Hearthstone Quality Home Heating Products, Inc. MODENA 8140 Gas-Fired Direct-Vent Symptom Possible Cause Corrective Action 8. Floating flames, lazy A. Potentially dangerous A. Check the appliance input rate and reduce if ill-defined, quiet incomplete combustion due to necessary. The air intake/exhaust flow system may...
-
Page 29: Rating Label
This appliance must be properl y connected to a venting system in acc ordance with the manu facturer’s installation instr uct ions. VENTED GA S FIR EPLA CE HEATER - N OT FOR USE W ITH SOL ID FU EL. MANUFA CTURED BY: HearthStone, MORR ISVILL E, VERMONT 0 5661 Date of Manufactu re 2008... - Page 30 Hearthstone Quality Home Heating Products, Inc. MODENA 8140 Gas-Fired Direct-Vent Notes:...
-
Page 31: Door & Glass Frame Removal Procedure
– F UICK EFERENCE IREBOX CCESS & G LASS RAME EMOVAL ROCEDURE To access the firebox, open the front door. Once the door is opened; you have access to the glass frame. Loosen, but do not remove the 4 left most mounting screws. Remove the 8 remaining mounting screws (see figure 16) that attach the frame and glass to the firebox.(Be careful as you remove the last screws, as the frame will be loose and will want to fall) Once the frame is loose, set it on a soft material until it is ready to be replaced.